2022 Ford Transit Technical Service Bulletins

166 technical service bulletins (TSBs) are on record for the 2022 Ford Transit. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10238868Jun 2, 2023Electrical system. Certain 2021-2022 Model Year Mustang Mach-E and 2022 Model Year E-Transit Vehicles - Off-Board Charger Controller Module Programming Some Mustang Mach-E, and E-Transit battery electric vehicles (BEV) may experience inability to charge at certain charging stations
• 10236680May 29, 2023Transmission and drivetrain. Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60 transmission and built on or before 23-Dec-2022 or with a 18R80/10R80MHT transmission and built on or before 15-Aug-2022 may exhibit a harsh/delayed engagement and/or harsh/delayed shift.
• 10237457May 26, 2023Equipment. Certain 2022 & 2023 Model Year Transit Vehicles Passenger Airbag Deactivation Switch Instructions Not in Owners Manual
• 10236582May 16, 2023Electrical system, Equipment. Some 2022-2023 Transit/E-Transit vehicles built on or before 05-May-2023 may experience an inaccurate air discharge temperature when the electronic automatic temperature control (EATC) is operating in auto or manual mode and the temperature set to 60°F (15.5°C) or above. During this condition, the system commands full or mostly heat and the air discharge temperature will only reduce in the LO setting.
• 10236575May 16, 2023Transmission and drivetrain, Back-over prevention (rear camera). 2021-2022 F-150 vehicles with 2.7L, 3.3L, 3.5L EcoBoost or 5.0L engines, 2020-2022 Transit vehicles with 3.5L Duratec/3.5L EcoBoost engines, 2021-2023 Bronco with the 2.3L or 2.7L engine having charging system diagnostics performed in the Workshop Manual (WSM) may experience the generator voltage desired (GENVDSD) parameter identification (PID) missing from the powertrain control module (PCM) PID list in the Ford…
• 10236574May 16, 2023Transmission and drivetrain. Some 2022 Aviator/Bronco/Expedition/Explorer/F-150/Mustang/Navigator/Ranger/Transit vehicles built on or before 31-Jul-2022 equipped with a 10R60/10R80/10R80 MHT automatic transmission may exhibit a fluid leak from the selector shaft seal. This may be caused by a crack in the manual shaft. To correct this condition, follow the Service Procedure to replace the manual shaft, the manual shaft-to-sensor roll pin and…
• 10235078Apr 19, 2023Electrical system. Some 2021-2023 Transit, 2022-2023 E-Transit vehicles built on or before 17-feb-2023 may exhibit an uncommanded/erratic wipers and/or washer operation. It may also exhibit diagnostic trouble code (DTC) B1131, an inoperative left headlamp, and/or inoperative horn. This may be due to a poor connection at ground G110 in the left side of the engine compartment.
• 10234125Apr 3, 2023Transmission and drivetrain. Some 2020-2023 Explorer/Aviator/Transit, 2021-2023 F-150/Bronco, 2022-2023 Expedition/Navigator/Mustang and 2023 F-250/F-350 Super Duty vehicles may exhibit harsh/delayed engagement and/or harsh/delayed shift concerns. These may be addressed with the powertrain control module (PCM)/transmission control module (TCM) Transmission Accelerated Main Control Break In Routine and/or a main control overhaul.
• 10233921Mar 27, 2023Electrical system. Some 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P2C94 stored in the secondary on-board diagnostic control module A (SOBDM). To restore charging capability, disconnect the off-board charging station charge handle from the…
• 10233738Mar 15, 2023Equipment. Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass®/LincolnWay® app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops…
• 10233695Mar 8, 2023Transmission and drivetrain. Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P)…
• 10233686Mar 6, 2023Body and structure. Some 2021-2022 Transit vehicles may exhibit a rear door that does not open or close correctly. The vehicle may also exhibit a condition of the rear door swinging all the way open. This may be due to the rear door switch. Inform customers the operation of the rear door switch has been updated in the Owner´s Manual. Refer Owner´s Manual (HTML), section Doors and Locks > Operating the doors from outside your…
• 10233656Mar 2, 2023Back-over prevention (rear camera). Some 2021-2022 Ford and Lincoln vehicles equipped with SYNC 4 may experience an error message during the gateway module (GWM) software update application which states Procedure Unsuccessful- GetConfigDataFromGIVIS. This may be the result of a server related concern. To correct the condition, download and run the Ford Diagnosis and Repair System (FDRS) application GWM-Read the Gateway Module A (GWM) Configuration…
• 10233580Mar 2, 2023Electrical system. This article supersedes TSB 22-2355 to update the vehicle model years affected. Some 2021-2023 Mustang Mach-E, 2022-2023 e-Transit and F-150 Lightning vehicles may experience inoperative level 3 charging with an illuminated Charger Service Required indicator in the instrument panel cluster (IPC) and diagnostic trouble codes (DTCs) P0D93:00, P0D94:00, P0D98:00, P0D9E:00 and/or P0DA0:00 in the secondary on-board…
• 10232480Feb 23, 2023Electrical system. Some 2021-2023 F-150/Transit, 2022-2023 F-150 Lightning vehicles may experience issues utilizing the Smart Hitch, ProPower Onboard or Onboard Scales features (if equipped) in the FordPass app. Symptoms may include inability to connect, incorrect data displayed in the app, no weight displayed, unable to power on/off the feature, unable to turn on generator mode (gas vehicles only).
• 10232440Feb 17, 2023Engine cooling. Some 2022-2023 Transit/E-Transit vehicles may experience an inaccurate air discharge temperature when the EATC is operating in auto or manual mode and the temperature set to 60°F (15.5°C) or above. During this condition, the system commands full or mostly heat and the air discharge temperature will only reduce in the LO setting. This may be due to calibration in the heating, ventilation and air conditioning…
• 10232487Feb 6, 2023Back-over prevention (rear camera). Some 2022 Transit vehicles may exhibit a DTC U0198:00 stored in the APIM but does not exhibit any customer concerns around the vehicle location or global positioning system (GPS). This may be due to the software in the gateway module (GWM). To correct the condition, follow the Service Procedure to reprogram the GWM.
• 10230775Jan 23, 2023Engine cooling, Transmission and drivetrain. 2021-2022 F-150 vehicles with 2.7L, 3.3L, 3.5L EcoBoost or 5.0L engines, 2020-2022 Transit vehicles with 3.5L Duratec/3.5L EcoBoost engines, 2023 Bronco with the 2.3L engine having charging system diagnostics performed in the Workshop Manual (WSM) may experience the generator voltage desired (GENVDSD) parameter identification (PID) missing from the powertrain control module (PCM) PID list in the Ford Diagnosis And…
• 10230835Jan 19, 2023Electrical system. Some 2018-2023 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals…
• 10230797Jan 11, 2023Electrical system, Steering. Some 2020-2022 Transit, 2022 E-Transit vehicles built on or before 26-Apr-2022 may exhibit a lack of power steering assist at initial vehicle start-up with diagnostic trouble code (DTC) C102D:00 stored in the power steering control module (PSCM). This may be due to the PSCM software. To correct this condition, update the PSCM to the latest software level using the latest version of Ford Diagnosis and Repair System…
• 10230787Jan 10, 2023Electrical system, Exterior lighting. Some 2022 Transit vehicles built on or before 01-Sep-2022 with halogen lamp assemblies may exhibit a turn signal indicator fast flashing in the instrument cluster panel (IPC) with diagnostic trouble code(s) (DTC) B123A and/or B123B stored in the body control module (BCM). This may be due to a front turn signal lamp socket being internally damaged. To correct this condition, replace the affected front turn lamp…
• 10228832Dec 20, 2022Electrical system, Other or unknown. This article supersedes TSB 22-2402 to update the vehicle model years affected. Some 2021-2022 Mustang Mach-E base model (non-GT) built on or before 25-Jul-2022, 2022-2023 e-Transit vehicles built on or before 17-Sep-2022 may experience an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P1A3C, U3000:16, U3000:64, U3000:04 and/or U3000:45 in the off-board charging controller…
• 10228876Dec 16, 2022Brakes. Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting…
• 10228802Dec 16, 2022Electrical system. Some 2021-2022 Mustang Mach-E built on or before 17-Sep-2022, 2022 e-Transit vehicles may exhibit an illuminated red triangle indicator lamp with diagnostic trouble code (DTC) P27B4 stored in the secondary on-board diagnostic control module C (SOBDMC) or the charge status indicator (CSI) is blinking red with DTC P0A7F stored in the battery energy control module (BECM) and/or P0CF7 stored in the secondary on-board…
• 10228870Dec 14, 2022Engine cooling, Equipment, Back-over prevention (rear camera). Some 2022 Transit vehicles that are not equipped with a telematics control unit (TCU) module and built on or before 28-Mar-2022 may exhibit a no crank/no start condition due to a discharged battery. If no parasitic draw is found during normal diagnostics, run the GWM - Gateway Module A (GWM) Configuration application using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool to correct…
• 10228763Dec 6, 2022Electrical system. This article supersedes TSB 21-2205 to update the vehicles and vehicle model years affected. 2021-2022 F-150 vehicles with 2.7L, 3.5L EcoBoost or 5.0L engines, 2020-2022 Transit vehicles with 3.5L EcoBoost engine having charging system diagnostics performed in the Workshop Manual (WSM) may experience the generator voltage desired (GENVDSD) parameter identification (PID) missing from the powertrain control module…
• 10228846Dec 1, 2022Other or unknown. Some 2020-2023 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session…
• 10226939Nov 21, 2022Transmission and drivetrain, Other or unknown. This article supersedes TSB 22-2271 to update the vehicle model years affected. Some 2015-2023 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft may experience a boom/hum/moan noise from the rear while driving.
• 10226757Nov 10, 2022Transmission and drivetrain. Some 2021-2022 Mustang Mach-E built on or before 17-Jan-2022, 2022 Escape built on or before 03-Mar-2022, Bronco Sport built on or before 04-Mar-2022, 2022 Maverick built on or before 25-Jan-2022 and 2022 Transit built on or before 17-May-2022 may exhibit a powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0929:77 stored in the gear shift module (GSM). This may be due to the software in…
• 10226726Nov 1, 2022Electrical system. 2015-2023 Transit vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01. The JDDAB feature code description, found under OASIS additional information, is common between single rear wheel and…
• 10225507Oct 25, 2022Electrical system. Some 2021-2022 Mustang Mach-E base model (non-GT) built on or before 25-Jul-2022, 2022 e-Transit vehicles built on or before 17-Sep-2022 may experience an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P1A3C, U3000:16, U3000:64, U3000:04 and/or U3000:45 in the off-board charging controller (OBCC) module and the high voltage (HV) battery will not charge using a level 3…
• 10225543Oct 21, 2022Equipment. Certain 2022 Model Year Transit Vehicles with Missing or Unconfigured Audio Control Module (ACM) - ACM Module Installation and/or Programming The affected vehicles were manufactured with a missing or unprogrammed Audio Control Module (ACM). The ACM supports various functions including rear-view camera display, radio Functionality, center stack display, center stack button functionality, USB functionality and others.
• 10224777Oct 20, 2022Transmission and drivetrain. Some 2021-2022 Mustang Mach-E/Escape plug-in hybrid electric vehicle (PHEV), 2020-2022 Aviator PHEV, and 2022 Transit battery electric vehicle (BEV) vehicles may experience an illuminated powertrain malfunction (Wrench) indicator and/or malfunction indicator lamp (MIL) with secondary on board diagnostic control module (SOBDM) diagnostic trouble code (DTC) U3000:49. This may be due to an internal SOBDM concern.
• 10224334Oct 13, 2022Other or unknown. Some 2020-2022 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session…
• 10224332Oct 13, 2022Other or unknown. Some 2023 Ford Transit with 12 inch center display screen built on or after 01-Sep-2022 may exhibit inoperative connected vehicle features, such as the activate button missing in FordPass, unable to connect wirelessly to Android Auto or Apple CarPlay, or in-vehicle Wi-Fi hotspot unavailable and TCU diagnostic trouble code (DTC) U2100. This may be due to various software parameters in the TCU.
• 10222788Oct 6, 2022Brakes. Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting…
• 10225801Oct 5, 2022Electrical system. Software Update 3 for 2022 Model Year Transit vehicles is now available. Quality Improvements Include: enable DC charge/energy estimation, addition of extra signals to high voltage battery monitoring alert.
• 10222065Sep 23, 2022Electrical system. Some 2021-2022 Mustang Mach-E non-GT, 2022 e-Transit vehicles may experience concerns with DC fast charge dropouts at certain EVgo Fat Boy charging stations with a red flashing charge status indicator (CSI), a charge failure notification on the touchscreen panel and the FordPass app. To correct the condition, update the off-board charger controller (OBCC) module to the latest software level of the Ford Diagnosis…
• 10222067Sep 22, 2022Electrical system. Some 2021-2022 Mustang Mach-E, 2022 F-150 Lightning/e-Transit may experience diagnostic trouble codes (DTCs) P1A10 in the secondary on-board diagnostic module C (SOBDMC) and U3012 in the battery energy control module (BECM) after a low voltage service disconnect (LVSD). If both DTCs have set simultaneously, this may be due to the LVSD not being fully seated. Inspect the LVSD C1001 for being fully seated which is…
• 10222189Sep 20, 2022Electrical system. Some 2021-2022 Mach-E, 2022 Transit BEV and F-150 Lightning vehicles may experience inoperative level 3 charging with an illuminated Charger Service Required indicator in the instrument panel cluster (IPC) and diagnostic trouble codes (DTCs) P0D93:00, P0D94:00, P0D98:00, P0D9E:00 and/or P0DA0:00 in the secondary on-board diagnostic module (SOBDM).
• 10219146Aug 31, 2022Body and structure. Some 2020-2022 Transit vehicles may experience intermittent operation of the power sliding door (PSD) which may not open/close properly. It can still be closed manually. Diagnostic trouble code (DTC) U201A may or may not be present in the door control module H (DCMH). The PSD may partially actuate with each press of the remote, dash button, or door handle actuation. To correct the condition, follow the Service…
• 10219068Aug 31, 2022Transmission and drivetrain. Some 2021-2022 Mustang Mach-E, 2022 Escape/Bronco Sport/Maverick/Transit vehicles may exhibit a powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0929:77 stored in the gear shift module (GSM). This may be due to the software in the GSM. To correct this condition, reprogram the GSM module using the latest software level of the Ford Diagnosis and Repair System (FDRS).
• 10217896Aug 17, 2022Equipment, Body and structure. This Service bulletin is related to the exhaust fan that we install on the roof. After seeing an increasing trend in warranty calls regarding leaks, we launched an investigation into the source of the leaks and found the exhaust fan seal to be the culprit. The repair procedure outlined below has been successfully tested and incorporated into our current production process. There are no safety risks involved rather…
• 10218620Aug 11, 2022Body and structure, Equipment. Some 2015-2022 Transit vehicles may experience a snap, click and/or pop noise from the door check when opening/closing the front door(s). This may be due to a cracked/broken door check and/or fastener. To correct the condition, follow the Service Procedure to inspect/replace the front door check and/or fastener.
• 10217840Aug 10, 2022Electrical system. Some 2021-2022 Mustang Mach-E, 2022 F-150 Lightning/E-Transit vehicles may exhibit a concern where the vehicle is unable to achieve 100 percent state of charge immediately after high voltage (HV) battery module replacement. This may be due to the battery energy control module (BECM) adjusting the cell balance (conditioning) of the battery module and should be corrected within 16 days.
• 10217837Aug 9, 2022Equipment. Some 2022 Transit vehicles may exhibit a DTC U0198:00 stored in the APIM but does not exhibit any customer concerns around the vehicle location or global positioning system (GPS). If the vehicle exhibits GPS or location concerns, continue with normal Workshop Manual (WSM) diagnostics. This DTC alone does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time.
• 10215619Jul 7, 2022Transmission and drivetrain. This article supersedes TSB 22-2175 to update the Issue, Action, and Service Procedure. Some 2015-2022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel (only), and U-joints at the transmission flange and rear driveshaft may experience a boom/hum/moan noise from the rear while driving.
• 10216042Jul 6, 2022Electrical system, Equipment. Some 2021-2022 Mach-E, 2022 Transit battery electric vehicle (BEV)/F-150 Lightning vehicles may experience concerns with DC fast charge dropouts at certain EVgo Fat Boy charging stations with a red flashing charge status indicator (CSI), a charge failure notification on the touchscreen panel and the FordPass app. To correct the condition, update the off-board charger controller (OBCC) module to the latest software…
• 10215590Jul 4, 2022Electrical system. Some 2021-2022 Mustang Mach-E, 2022 Transit battery electric vehicles (BEV) may experience an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P1A3C, U3000:16, U3000:64, U3000:04 and/or U3000:45 in the off board charging controller (OBCC) module and the high voltage (HV) battery will not charge using a level 3 direct current (DC) fast charging station/electrical vehicle…
• 10214830Jun 22, 2022Seat belts. Some 2015-2022 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front seats and cargo area has been added to the vehicle. Fasteners or holes in the lower b-pillar are indicators that the seat belt retractor mechanism could have been compromised.

← All problems reported for the 2022 Ford Transit