2022 Ford Transit Technical Service Bulletins

166 technical service bulletins (TSBs) are on record for the 2022 Ford Transit. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10214131Jun 14, 2022Engine cooling. Certain 2022 Model Year Transit Vehicles Reconfigure Instrument Panel Cluster Module (IPC) - In some of the affected vehicles, the Instrument Panel Cluster (IPC) Optional Engine Idle Shutdown feature will not function as expected and can fail to shut the engine off after the requested minutes of run time (5, 10, 15, or 20 minutes). This may result in the engine not shutting down as expected after the run timer…
• 10214158Jun 8, 2022Electrical system. Some 2018-2022 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals…
• 10213708Jun 6, 2022Equipment, Electrical system. 2021-2022 various Ford and Lincoln vehicles may exhibit an erroneous diagnostic trouble code (DTC) U1A01:93 stored in the telematics control unit (TCU). This may be due to various software parameters within the TCU. If this DTC is identified during normal diagnostics, but the vehicle does not exhibit any customer concerns around the TCU operation, clear this DTC and no further repairs are recommended.
• 10212957May 24, 2022Electrical system. Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle commands such as door lock/unlock, remote start, vehicle location, etc. The battery drain may be caused by excessive calls for data through the vehicle network keeping it in an…
• 10211706May 5, 2022Transmission and drivetrain. Some 20152022 Transit vehicles equipped with rear wheel drive (RWD), single rear wheel only, and a U-joint at the transmission flange and rear driveshaft may experience a boom/hum/moan noise or vibration from the rear while driving.
• 10210850Apr 28, 2022Tires. Some 2021 and 2022 Ford and Lincoln vehicles may experience a tire sidewall wavy/indentation appearance in the radial direction on one or both sidewalls. Sidewall wavy/indentation appearance is a common cosmetic characteristic of radial tire construction and will not affect the performance of the tire.
• 10210806Apr 22, 2022Brakes. 2020-2022 Transit vehicles equipped with the push down parking brake lever operate differently than the standard parking brake. When the push down parking brake is engaged by pulling the lever upward to its fullest extent, the lever can then be lowered and raised without the parking brake becoming disengaged. To disengage the parking brake, the button must be pressed and held when the lever is in the most upward…
• 10210419Apr 14, 2022Body and structure, Electrical system. Some 2019-2022 Transit vehicles may experience intermittent operation of the power sliding door (PSD) which may not open/close properly. It can still be closed manually. Diagnostic trouble code (DTC) U201A may or may not be present. The PSD may partially actuate with each press of the remote, dash button, or door handle actuation. Check and adjust the door strikers/hinges as needed per the Workshop Manual (WSM)…
• 10210242Apr 6, 2022Electrical system, Transmission and drivetrain. Some 2018-2022 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with Diagnostic Trouble Codes (DTCs) P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs or loose/corroded grounds.
• 10210240Apr 6, 2022Electrical system, Equipment, Back-over prevention (rear camera). Some 2017-2022 Transit Connect/Transit/Explorer vehicles equipped with a fleet telematics global positioning system (GPS) and a connected human machine interface (HMI) radio (CHR) may experience concerns with rear camera zoom, wrong map matching or a blank display. If these concerns are present, it's likely to be a software issue caused by the audio control module (ACM) that can be remedied by updating the ACM…
• 10210941Apr 5, 2022Equipment, Other or unknown. In various 2017-2022 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating "Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent…
• 10209213Mar 15, 2022Exterior lighting. 2015-2022 Transit vehicles equipped with DRW have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking lamps only. This information is available in Workshop Manual Section 417-01. The JDDAB feature code description, found under OASIS additional information, is common between single rear wheel and…
• 10209212Mar 15, 2022Equipment, Electrical system. Some 2017-2022 Transit Connect/Transit/Explorer vehicles equipped with a fleet telematics global positioning system (GPS) and a connected human machine interface (HMI) radio (CHR) may experience concerns with rear camera zoom, wrong map matching or a blank display.
• 10209030Mar 8, 2022Equipment, Other or unknown. Some 2022 Ford and Lincoln vehicles may need to perform A/C leak detection diagnostics. The 2022 Workshop Manual (WSM), Section 412-00 for A/C leak detection diagnosis is incomplete and is in the process of being updated. At this time, Pinpoint Test AN of Section 412-00 in the 2022 F-150 WSM can be used temporarily for the service procedure and specifications. Use the correct vehicle specific removal and…
• 10208154Feb 21, 2022Transmission and drivetrain. Some 2021-2022 Bronco/F-150/Explorer/Aviator/Police Interceptor Utility and 2022 Transit vehicles may exhibit harsh/delayed engagement and/or harsh/delayed shift concerns. These may be addressed with the powertrain control module (PCM)/transmission control module (TCM) Transmission Accelerated Main Control Break In Routine and/or a main control overhaul.
• 10207900Feb 7, 2022Electrical system, Other or unknown. 2021-2022 various Ford and Lincoln vehicles may exhibit an erroneous diagnostic trouble code (DTC) U1A01:93 stored in the telematics control unit (TCU). This may be due to various software parameters within the TCU. If this DTC is identified during normal diagnostics, but the vehicle does not exhibit any customer concerns around the TCU operation, clear this DTC and no further repairs are recommended.

← All problems reported for the 2022 Ford Transit