2009 Mercedes-Benz E350 Technical Service Bulletins

116 technical service bulletins (TSBs) are on record for the 2009 Mercedes-Benz E350. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10041066Mar 6, 2011Exterior lighting. Mercedes benz: the turn signal light on the mirror fogs up due to temperature differences.
• 10037983Dec 13, 2010Exterior lighting. Mercedes-benz: curve illumination is inoperative.
• 10038225Dec 8, 2010Steering, Electrical system. Mercedes-benz: diagnostic procedures for the driver authorization system.
• 10038218Dec 1, 2010Electrical system. Mercedes-benz: software update for heater lines.
• 10037408Nov 19, 2010Suspension. Mercedes-benz: shock absorber procedure.
• 10034654Aug 17, 2010Exterior lighting. Mercedes: part change to banjo bolt for headlamp mount. The latch for the banjo bolt for the headlamp mount is no longer needed; therefore, the new part is now screwed onto the lamp frame using a thermoplastic nut
• 10033070Dec 16, 2009Engine cooling, Electrical system. Xentry (mercedes): engine warning lamp is currently on or was on and a delay fault of the camshaft adjust to current or stored in the engine control unit. Models 171, 203, 209, 211, 219, 221, 216, 230, 164, 251, and 403. No model years listed.
• 10033073Dec 3, 2009Steering. Xentry: steering leaky at internal oil lines. Connector of internal oil line or sealing washers/o-rings damaged. Not necessary to replace the entire steering system. Remove steering; replace both internal oil lines; install steering. Models 204 (except 4matic) and all model 207. No model years listed.
• 10034567Nov 20, 2009Electrical system. Mercedes benz (xentry): wiring harness is damaged in area of roof frame. Vehicle can not be started because the chassis can bus and/or interior can fault codes stored in quick test.
• 10032727Sep 17, 2009Suspension. Mercedes: following fault codes are entered in the control unit and displayed-fc5320 drain valve:open circuit or insufficient valve current in models series 211, 219; fc5260 drain valve open circuit or insufficient valve current in model 221; fc5250 drain open circuit or insufficient valve current in model series 251, 164. Defective connecting cables to drain valve at airmatic compressor. This results in the…
• 10032709Aug 13, 2009Transmission and drivetrain. Mercedes: cracking/creaking noises from front axle when vehicle is subject to torsion or when steering wheel is turned. This is mainly heard when the vehicle is stationary or when the vehicle is moving slowly. Relative movement between the frame type integral support and steering plate can cause the plate to make contact with the frame type integral support of the front axle, which in turn causes noises.
• 10032649Jul 31, 2009Electrical system. Mercedes benz: instrument cluster-analog pointers nonfunctional after vehicle is started. All analog pointers in the instrument cluster (a1) may not be functional for approx. One to two minutes after the engine is started. Full functionality is then restored. No model years listed.
• 10028686May 6, 2009Electrical system. Mercedes: air matic visit workshop displayed within instrument cluster. Models 164, 211, 219, 221 and 251. Included 4matic, amg (compressor) amg, bluetec and wagon. Model years unknown. *pe updated 9/18/09.
• 10030665Mar 1, 2009Equipment, Other or unknown. Mercedes: it has been determined that the tele aid may not function properly as a result of a hardware fault in the tele aid control module. If this condition exists an instrument cluster message of no service and tele aid inoperable will be seen.
• 10020460Dec 4, 2008Steering. Play in the rack and pinion steering system. Models 203, 209, 210, 211, 215, 220, 230. Mercedes benz. *kb updated 5/13/09.
• 10028628Nov 1, 2008Electrical system. Mercedes: replace circuit 30 terminal nut. Models 211 and 219. Model year 2009.

← All problems reported for the 2009 Mercedes-Benz E350