1999 Rexhall Aerbus Problems
- Complaints
- 5filed with NHTSA
- Median mileage
- 28,084miles, 1 complaints with mileage
- Recalls
- 2campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 1999 Rexhall Aerbus (complaints, recalls, investigations). Report an error
NHTSA recorded 5 consumer complaints for the 1999 Rexhall Aerbus. The part named most often is transmission and drivetrain, with 3 complaints (60% of the total), followed by brakes (1) and electrical system (1). 1 of the complaints include a mileage, and 100% of those were filed for vehicles with under 50,000 miles; the median is 28,084 miles. NHTSA lists 2 recall campaigns and 0 technical service bulletins for this model year. Transmission and drivetrain complaints overlap with 1 recall campaign covering the driveshaft filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Brakes1 20%
- Electrical system1 20%
Example complaints
Transmission and drivetrain: “Ford engineer inspection concluded that manufacturer did not follow ford specifications for extending chasis/ driveshaft was 3 inches too long and not at the proper angle. Also parts that should have been bolted were welded. I have proof of all these all. The driveshaft fell off on three separate occasions due to this defect.”
NHTSA complaint #718109, filed 2000-01Brakes: “Anti-lock braking system has caught overheated and locked up a couple of times. Master cylinder was replaced, but did not stop the problems. Dealer has been contacted.”
NHTSA complaint #870845, filed 2000-09Electrical system: “Battery disconnect failed while driving our 20,200 pound rv at highway speed. The failure resulted in total loss of chassis power (engine stopped, power steering ceased, power steering ceased, all dash indicators non-operational, emergency flasher non-operational, etc.). The failure caused us to coast to a stop as there was nothing else we could do. The failed part was later identified as: battery disconnect solenoid (intellitec 01-00055-002 04098 bcc relay (printed on sticker placed on top portion of unit), 612-12v 797 (printed on bottom of unit). …”
NHTSA complaint #10467600, filed 2012-07, 28,084 milesMileage when problems were reported
100% of the 1 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 28,084 and 28,084 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 07V417000Sep 5, 2007Equipment › Recreational vehicle/trailerCovers: Rexhall Aerbus 1998–2005, Rexair 1998–2005, American Clipper 1998–2005 +2 more
On certain motor homes equipped with a two-door refrigerator manufactured by the dometic corporation, the refrigerator may have a defect in the refrigerator boiler tube. Pressurized coolant solution could be released into an area where an ignition source…
- 01V163000May 9, 2001Power train › Driveline › DriveshaftCovers: Rexhall Aerbus 1998–1999, Rexair 1998–1999, American Clipper 1998–1999 +2 more
Vehicle description: motor homes. The drive shaft bolts can come loose at the transmission and fall off. When the drive shaft separates from the transmission, the forward end of the shaft can drop to the ground, or come through the floorboards of the motor…
Recall details for the 1999 Rexhall Aerbus → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
No technical service bulletins are on record for the 1999 Rexhall Aerbus.
Other model years of the Rexhall Aerbus
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 1999 | 5 | 28,084 | 2 | — | — | — | Not enough data |
| 1997 | 5 | 65,000 | 0 | — | — | — | Not enough data |
All Rexhall Aerbus model years
Frequently asked questions
How many NHTSA complaints does the 1999 Rexhall Aerbus have?
NHTSA recorded 5 consumer complaints for the 1999 Rexhall Aerbus as of Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 1999 Rexhall Aerbus is reported most often?
Transmission and drivetrain is named most often, in 3 complaints (60% of the total), followed by brakes with 1.
Has the 1999 Rexhall Aerbus been recalled?
NHTSA lists 2 recall campaigns for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 1999 Rexhall Aerbus reported?
Among the 1 complaints that include a mileage, the median is 28,084 miles and the middle half falls between 28,084 and 28,084 miles; 100% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.