2022 Toyota Highlander Hybrid Technical Service Bulletins

150 technical service bulletins (TSBs) are on record for the 2022 Toyota Highlander Hybrid. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10247809Nov 15, 2023Electrical system. TI: TECHNICAL INSTRUCTIONS FOR 23TJ01 Second Key Delivery Program Multiple Models and Model Years
• 10247796Nov 1, 2023Electrical system. TSB: Some 2016 ? 2023 model year Toyota vehicles may exhibit a hybrid system warning lamp occurring in below-freezing temperatures (below 32°F or 0°C). After performing a Health Check, one or both of the following Diagnostic Trouble Codes (DTCs) may be present: ?P1C8449 ? (High Voltage Power Resource Circuit Short during Ready ON) ?P300449 ? (High Voltage Power Resource Circuit Short during Pre-Charge) Follow the…
• 10244111Aug 17, 2023Other or unknown. TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. These resources, in conjunction with the Repair Manual, are for dealership personnel to assist those customers with user issues, user errors, and compatibility issues with other vehicle systems and external applications encountered while operating telematics features.
• 10240057Jun 8, 2023Engine cooling, Fuel system. TSB: Some 2020 ? 2023 model year Highlander Hybrid and 2021 ? 2023 model year RAV4 Hybrid, RAV4 Prime, Sienna Hybrid, and Venza Hybrid vehicles may exhibit a MIL ON condition with one or both of the following Diagnostic Trouble Codes (DTCs) present: ?P24517F ? Evaporative Emission System Switching Valve Actuator Stuck Off. ?P14502A ? Fuel Tank Pressure Sensor Signal Stuck in Range.
• 10238144May 18, 2023Engine cooling. TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced. In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine ECU or…
• 10238140May 18, 2023Electrical system, Engine cooling. Ti: technical instructions for customer support program 22te09 hv floor under wire harness and rear traction motor cable corrosion certain 2020 ?2022 model year highlander hybrid awd
• 10238139May 18, 2023Electrical system, Engine cooling. DP: Although the HV Floor Under Wire Harness and Rear Traction Motor Cable is covered by Toyota?s New Vehicle Limited Warranty for 3 years or 36,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to excessive corrosion to the wire harness connections at the Rear Motor Generator.
• 10236209Apr 21, 2023Engine cooling, Electrical system. TT: Some 2022-2024 MY vehicles equipped with the A25A engine may exhibit a leak from the engine water pump, and/or MIL On condition accompanied by DTC(s): ?P26CA14 Engine Coolant Pump Circuit Short to Ground or Open ?P26CA31 Engine Coolant Pump No Signal
• 10236191Apr 5, 2023Fuel system. DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the customers? ownership experience. Toyota is providing coverage for repairs related to the presence of a fuel odor in or around the engine bay originating at the high-pressure fuel pump of the subject vehicles.
• 10235240Feb 20, 2023Engine cooling. TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may experience an oil leak from the head/valve cover gasket. This issue is currently under investigation.
• 10230376Dec 19, 2022Equipment. TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs.
• 10206529Dec 17, 2022Equipment, Engine cooling. TT: Some 2021-2022 TMMK built vehicles with A25A-FKS/FXS engines may exhibit an oil leak from the No.2 Oil Pan. This issue is currently under investigation
• 10230364Dec 9, 2022Fuel system, Electrical system. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid and 2021 ? 2022 Sienna Hybrid vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0087 (Fuel Rail/System Pressure ? Too Low) and/or P107A2A (Fuel Rail Pressure Sensor (Low) Signal Stuck in Range) present. This condition may occur when the vehicle is operated at high altitude and high temperature; typically, above 3,300 feet (1,000…
• 10230360Dec 7, 2022Equipment. TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with a Premium Audio with Dynamic Navigation System, require a Special Service Tool (SST) USB flash drive to update the map, points of interest, and system software. The SST is used with applicable vehicles to deliver the update, however, the process for generating license keys differs from previous generations.
• 10220206Aug 29, 2022Engine cooling. DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured Crankcase Case Vent. If the engine is equipped with an incorrectly manufactured Crankcase Case Vent, the vehicle may release crankcase emissions
• 10220242Aug 23, 2022Engine cooling. DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured Crankcase Case Vent. If the engine is equipped with an incorrectly manufactured Crankcase Case Vent, the vehicle may not comply with certain Federal emissions regulations
• 10220234Aug 17, 2022Engine cooling. TI: TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 22TC05 Crankcase Case Vent
• 10220222Aug 11, 2022Engine cooling. DP: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured Crankcase Case Vent. If the engine is equipped with an incorrectly manufactured Crankcase Case Vent, the vehicle may not comply with certain Federal emissions regulations.
• 10220219Aug 10, 2022Engine cooling. TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced (Fig 1). In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine…
• 10220217Aug 10, 2022Equipment. Ti: technical instructions for special service campaign 22tc05
• 10220216Aug 10, 2022Engine cooling. RL: The subject vehicles may have been equipped with an engine containing an incorrectly manufactured Crankcase Case Vent. If the engine is equipped with an incorrectly manufactured Crankcase Case Vent, the vehicle may not comply with certain Federal emissions regulations.
• 10220214Aug 5, 2022Equipment. TT: Vehicles listed above equipped with a Denso Ten radio (Entune Audio Plus or Premium Audio) may exhibit a condition in which the radio screen continues to show a Bluetooth phone call in progress after the call has ended. This condition has been confirmed with multiple Android phones, including Samsung Galaxy S21 and S22, and Google Pixel 6.
• 10220212Aug 1, 2022Electrical system, Equipment. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid, and 2021 ? 2022 model year Venza Hybrid vehicles equipped with the 12.3-in. Premium Audio system may exhibit an abnormal multi-display operation, including but not limited to: an intermittent blank screen (reverse camera still operable), rebooting (Toyota logo present, audio still playing), touch screen inputs intermittently inoperative, or intermittent screen…
• 10217808Jul 29, 2022Engine cooling. TT: Some 2020-2022 vehicles equipped with North American Produced (NAP) A25A-FKS/FXS engines may experience an oil leak from the head/valve cover gasket. This issue is currently under investigation.
• 10220184Jun 15, 2022Equipment. TSB: Some 2020 ? 2022 Highlander and Highlander Hybrid, and 2021 ? 2022 model year Venza Hybrid vehicles equipped with the 12.3-in. Premium Audio system may exhibit an abnormal multi-display operation, including but not limited to: an intermittent blank screen (reverse camera still operable), rebooting (Toyota logo present, audio still playing), touch screen inputs intermittently inoperative, or intermittent screen…
• 10220183Jun 14, 2022Body and structure. TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk. Follow the Repair Procedure in this bulletin to address…
• 10213900May 31, 2022Electrical system, Equipment. TSB: This bulletin includes basic procedures for performing a rescue charge at battery on high voltage (HV) Ni-MH and Li-ion batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing the battery rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger
• 10213897May 27, 2022Equipment. TT: To assist with the early detection and early resolution of audio related concerns, it may be requested as part of the remanufactured head unit return to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by audio suppliers, FTS, and/or FPEs
• 10220174May 26, 2022Equipment. TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation.
• 10220155May 16, 2022Body and structure. TSB: Some 2020 ? 2022 model year Highlander (except XSE models) and Highlander Hybrid vehicles may exhibit an abnormal whistle noise from the front when driving over 35 mph. This may be caused by the radiator grille bracket. A new radiator grille bracket has been developed to address this condition
• 10220154May 13, 2022Other or unknown. TT: To improve customer support of telematics connected services features, additional resources have been provided in the Service Lane - Knowledge Center.
• 10220151May 11, 2022Electrical system. DL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call
• 10211819Apr 27, 2022Equipment, Electrical system. Technical instructions for 22tc01 data communication module (dcm) reprogramming certain 2021 model year c-hr, rav4 prime, tundra certain 2021-2022 4runner, highlander, highlander hv, prius prime, sequoia, tacoma certain 2022 prius
• 10211800Apr 7, 2022Equipment. SSC: Toyota Over-The- Air (OTA) Pilot Program Team Members SPECIAL SERVICE CAMPAIGN 22TC01
• 10211794Apr 6, 2022Electrical system. TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced (Fig 1). In several cases, it was found that the cause of the ECU damage was improper jump starting. Further investigation found that ECU damage may occur if the jumper cables are hooked up on or around the engine…
• 10214316Mar 10, 2022Equipment. TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately
• 10210379Mar 10, 2022Equipment. OBSOLETE NOTICE March 10, 2022: This bulletin is now obsolete. Please see T-SB-0016-22.
• 10210368Mar 4, 2022Equipment. TSB: 2022 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During Pre-Delivery Service (PDS), follow the appropriate Installation Procedure to attach the driver side, and if applicable, the passenger side and rear seat floor mats to the vehicle…
• 10209016Feb 24, 2022Electrical system. RL: Due to improper programming of the Data Communication Module (DCM), which provides cellular communication in various situations, including emergencies, the driver and Safety Connect operator may not be able to hear each other?s voices during a Safety Connect call.
• 10207963Jan 28, 2022Electrical system. TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year Electronic Wiring Diagram (EWD) and/or Repair Manual.
• 10207958Jan 20, 2022Electrical system. TT: Some customers may experience the inability to activate Remote Connect or Remote Connect becoming inoperative when attempting to send commands to the vehicle. To simplify the diagnosis of this system and prevent the unnecessary replacement of parts, please refer to the procedure below.
• 10207946Jan 12, 2022Wheels, Tires, Equipment. POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Toyota.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center…
• 10206528Dec 17, 2021Electrical system, Engine, Equipment. TSB: Some 2018 ? 2022 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, or M20A-FKS engine may exhibit one or more of the following conditions: ?Milky/Discolored engine oil. ?An ?Oil Pressure Low? warning message on the Multi-information Display (MID). ?A MIL ON condition with Diagnostic Trouble Codes (DTCs) P05202A (Engine Oil Pressure Sensor/Switch "A" Signal Stuck in Range) and/or P052477 (Engine…
• 10206517Dec 15, 2021Engine. TSB: Some 2020 ? 2022 model year Highlander Hybrid vehicle customers may express a concern of engine noise on acceleration from 0 ? 45 mph. Follow the Repair Procedure in this bulletin to address this condition.
• 10204571Nov 23, 2021Body and structure. TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation.
• 10204562Nov 12, 2021Equipment. TSB: Some 2020 model year vehicles equipped with Audio Plus (version 1186) or earlier may exhibit one or more of the following conditions: ?WiFi intermittently inoperative. ?DTC (Diagnostic Trouble Code) B15DB present. ?Changing the Auto Relock Timer setting also changes the Remote 2-Press unlock setting. Some 2020 ?
• 10204554Nov 9, 2021Equipment. TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio Plus, and Premium Audio head units before they are used for the first time on new vehicles. The initialization procedure may also be performed under other circumstances, such as following a head unit replacement or after the customer?s personal settings are erased.
• 10203558Oct 22, 2021Equipment. TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately.
• 10203557Oct 22, 2021Equipment, Electrical system. TSB: A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspection and maintenance are required in order to ensure proper operation and optimal battery life. As a matter of policy, Toyota does not provide battery warranty coverage for…
• 10201373Jul 12, 2021Equipment. TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. Long-term storage can affect a vehicle?s systems and components. Any problems that are found should be corrected immediately.

← All problems reported for the 2022 Toyota Highlander Hybrid