2024 Toyota Tacoma Technical Service Bulletins

94 technical service bulletins (TSBs) are on record for the 2024 Toyota Tacoma. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11037198Aug 19, 2026Transmission and drivetrain. Some 2022 – 2025 model year Tundra Hybrid, 2023 – 2025 model year Sequoia Hybrid, 2024 –2025 Land Cruiser and Tacoma Hybrid, and 2025 4Runner Hybrid vehicles may exhibit a whine noise from the transmission when in Ready ON mode.
• 11032477Apr 15, 2026Transmission and drivetrain. OBSOLETE NOTICE April 15, 2026: This bulletin is no longer applicable and is now obsolete
• 11032469Apr 10, 2026Body and structure. The condition is for vehicles equipped with an accessory Power Port or Tire Inflator. During the installation process of the Power Port or Tire Inflator, the pre-wire connector is removed from the dummy cap (which is attached to the harness) and is left attached when power is connected. The purpose of the dummy cap is to prevent connector water intrusion/corrosion when the accessory is not installed.
• 11029895Feb 26, 2026Electrical system. Some 2024 – 2026 model year Tacoma vehicles may exhibit a “chirp” noise from the HVAC magnetic clutch upon engagement.
• 11029877Feb 5, 2026Transmission and drivetrain. Some 2024 model year Tacoma and Tacoma Hybrid vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P07407F – Torque Converter Clutch Actuator Stuck Off •P074571 – Pressure Control Solenoid “A” Actuator Stuck •P079571 – Pressure Control Solenoid "C" Actuator Stuck •P08BA71 – Pressure Control Solenoid "L" Actuator Stuck •P271371 – Pressure Control…
• 11028712Jan 7, 2026Other or unknown. Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle…
• 11027561Dec 17, 2025Body and structure. Some 2024 – 2025 model year 4WD Tacoma and Tacoma Hybrid vehicles may exhibit a condition where the 4WD lights are flashing and a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P277111 – Four Wheel Drive (4WD) Low Switch Circuit Short to Ground •P178462 – 4WD/AWD Transfer Case Shift Motor Limit Switch and Transfer Case H4-L4 Position Switch Signal Compare Failure…
• 11020657Jun 13, 2025Electrical system. The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks.
• 11020652Jun 6, 2025Lane departure. TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 25TC07 Blind Spot Monitor System Reprogramming CERTAIN 2024 Model Year Tacoma and Tacoma HV
• 11019340Apr 16, 2025Electrical system. Some 2024 Tacoma and Tacoma Hybrid vehicles equipped with a Blind Spot Monitor (BSM) may exhibit a condition where the Trailer Driving Assist Active message is displayed without a trailer connected. The BSM software has been updated.
• 11018337Apr 16, 2025Electrical system. Some 2024 Tacoma and Tacoma Hybrid vehicles equipped with a Blind Spot Monitor (BSM) may exhibit a condition where the Trailer Driving Assist Active message is displayed without a trailer connected. The BSM software has been updated.
• 11019331Apr 2, 2025Electrical system. To assist with the early detection and early resolution of audio related concerns you may be asked to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by FTS and/or FPE.
• 11018328Apr 2, 2025Electrical system. To assist with the early detection and early resolution of audio related concerns you may be asked to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by FTS and/or FPE.
• 11016782Feb 10, 2025Engine. Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Global Techstream+ (GTS+) ECU flash reprogramming procedures and outlines use of the Technical Information System (TIS) and the Calibration…
• 11016781Feb 10, 2025Electrical system. The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Another feature, Add/Remove Key, is also available. Once a key is removed, it can never be reused.
• 11015496Feb 10, 2025Engine. Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Global Techstream+ (GTS+) ECU flash reprogramming procedures and outlines use of the Technical Information System (TIS) and the Calibration…
• 11015495Feb 10, 2025Electrical system. The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Another feature, Add/Remove Key, is also available. Once a key is removed, it can never be reused.
• 11014211Jan 30, 2025Electrical system. OBSOLETE NOTICE January 30, 2025: This bulletin is now obsolete. Please see T-SB-0015-25.
• 11014210Jan 29, 2025Body and structure. Some 2024 – 2025 model year Tacoma and Tacoma Hybrid vehicles equipped with an accessory roof rack may exhibit an abnormal vibration from the accessory roof rack while driving. New roof rack bumpers have been developed to address this vibration.
• 11014209Jan 29, 2025Electrical system. Some 2021 – 2025 model year Toyota vehicles may require the download and installation of vehicle specific software or configuration software when the Electronic Control Unit (ECU) is replaced. GTS+ software has been modified to indicate when configuration software is required. A new Configure column has been added to the GTS+ Health Check Results screen to show when configuration software is available for a…
• 11014192Jan 23, 2025Body and structure. Some 2024 model year Tacoma Hybrid TRD Pro vehicles equipped with a front seat suspension absorber assembly may exhibit a condition where any of the gauge lenses on the front seat suspension absorber assemblies may appear foggy. This condition may be present on either the driver or the front passenger seat.
• 11014190Jan 23, 2025Electrical system. When certain vehicle ECUs are replaced, the ECU Security Key must be written in order for that ECU to communicate on the vehicle network. The GTS+ Software Health Check Results screen has been enhanced to help identify if a replacement ECU requires an ECU Security Key.
• 10249320Dec 13, 2024Electrical system, Body and structure, Equipment. TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body dents/dings. ? Proper operation of electrical accessories (including interior light, clock, and radio reset). ? Interior cleanliness. ? Proper function of mechanical systems.
• 11012744Dec 6, 2024Body and structure. The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as…
• 11012743Dec 6, 2024Body and structure. To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible.
• 11012742Dec 6, 2024Body and structure. Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface…
• 11012740Dec 6, 2024Body and structure, Electrical system. TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 24TC06 Active Grille Shutter Engine Warning Light May Illuminate CERTAIN 2024 TACOMA
• 11012739Dec 6, 2024Body and structure, Electrical system. An incorrectly sized seal can allow water or moisture to enter a connector on the Active Grille Shutter. This can cause the engine warning light to illuminate and/or the Active Grille Shutter to no longer open or close as designed.
• 11012735Dec 5, 2024Body and structure. Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure in this bulletin to remove the RapgardTM protective film within 90 days from initial application.
• 11012727Dec 3, 2024Body and structure. Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the presence of small, red or brown particles on the paint surface. These particles are often difficult to see on dark color paints but can be easily felt when brushing a hand across…
• 11011649Nov 14, 2024Body and structure, Electrical system. Frequently Asked Questions Certain 2024 Model Year Tacoma Active Grille Shutter Engine Warning Light May Illuminate
• 11011648Nov 14, 2024Electrical system, Body and structure. TECHNICAL INSTRUCTIONS FOR SPECIAL SERVICE CAMPAIGN 24TC06 Active Grille Shutter Engine Warning Light May Illuminate CERTAIN 2024 TACOMA
• 11011647Nov 14, 2024Electrical system, Body and structure. An incorrectly sized seal can allow water or moisture to enter a connector on the Active Grille Shutter. This can cause the engine warning light to illuminate and/or the Active Grille Shutter to no longer open or close as designed.
• 11011646Nov 14, 2024Electrical system, Body and structure. An incorrectly sized seal can allow water or moisture to enter a connector on the Active Grille Shutter. This can cause the engine warning light to illuminate and/or the Active Grille Shutter to no longer open or close as designed.
• 11011639Nov 11, 2024Engine. Some 2022 – 2024 model year Tundra and Tundra Hybrid, 2023 – 2024 model year Sequoia Hybrid, and 2024 model year Tacoma and Tacoma Hybrid vehicles equipped with a premium 14-inch audio multimedia display may exhibit a condition where the radio receiver power/volume knob becomes detached. An updated radio receiver power/volume knob is available to reduce the possibility of this condition.
• 11010354Oct 22, 2024Electrical system. Some 2022 – 2024 model year Tundra and Tundra Hybrid, 2023 – 2024 model year Sequoia Hybrid, and 2024 model year Tacoma and Tacoma Hybrid vehicles equipped with a premium 14-inch audio multimedia display may exhibit a condition where the radio receiver power/volume knob becomes detached. An updated radio receiver power/volume knob is available to reduce the possibility of this condition.
• 11010343Oct 14, 2024Transmission and drivetrain. Some 2024 model year Tacoma and Tacoma Hybrid vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P07407F – Torque Converter Clutch Actuator Stuck Off •P074571 – Pressure Control Solenoid “A” Actuator Stuck •P079571 – Pressure Control Solenoid "C" Actuator Stuck •P08BA71 – Pressure Control Solenoid "L" Actuator Stuck •P271371 – Pressure Control…
• 11010342Oct 14, 2024Transmission and drivetrain. OBSOLETE NOTICE October 14, 2024: This bulletin is now obsolete. Please see T-SB-0094-24.
• 11010107Sep 30, 2024Lane departure. Some 2024 Tacoma vehicles equipped with a Blind Spot Monitor (BSM) may exhibit a condition where the Trailer Driving Assist Active message is displayed without a trailer connected. The BSM software has been updated.
• 11010106Sep 26, 2024Electrical system. Some 2024 Tacoma and Tacoma Hybrid vehicles equipped with an adaptive variable suspension may exhibit a condition where the custom drive mode is missing from the Vehicle Customize – Settings menu. The air conditioner supply amplifier software has been updated.
• 11010060Sep 9, 2024Transmission and drivetrain. Some 2024 model year Tacoma vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P07407F – Torque Converter Clutch Actuator Stuck Off •P079571 – Pressure Control Solenoid "C" Actuator Stuck •P08BA71 – Pressure Control Solenoid "L" Actuator Stuck •P271371 – Pressure Control Solenoid "D" Actuator Stuck •P280771 – Pressure Control Solenoid "G" Actuator…
• 11010059Sep 3, 2024Body and structure. Some customers have expressed concern that the wireless functions of their Key Fob stop working. Key Fob LEDs will not turn ON, but engine starts with key held up against start button. Key battery voltage is confirmed OK and no DTC/RoB is found. This condition may occur if customer places Key Fob near wireless charger while phone is charging. When the key battery is removed and reinstalled, the Key Fob begins to…
• 11007455Jul 29, 2024Body and structure. Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle…
• 11006161Jul 29, 2024Body and structure. Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle…
• 11007446Jul 15, 2024Transmission and drivetrain. When replacing the transmission, if debris is found in the pan, it is required to also replace the torque converter. If the torque converter is not replaced, then the remaining debris may be introduced into the replacement transmission.
• 11006152Jul 15, 2024Transmission and drivetrain. When replacing the transmission, if debris is found in the pan, it is required to also replace the torque converter. If the torque converter is not replaced, then the remaining debris may be introduced into the replacement transmission.
• 11007445Jul 12, 2024Body and structure. The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as…
• 11007444Jul 12, 2024Body and structure. To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible.
• 11007443Jul 12, 2024Body and structure. Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface…
• 11006151Jul 12, 2024Body and structure. The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof, and decklid, significant damage can occur. This damage is the result of actual etching of the paint and appears as…

← All problems reported for the 2024 Toyota Tacoma