2006 Toyota Tundra Technical Service Bulletins

195 technical service bulletins (TSBs) are on record for the 2006 Toyota Tundra. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10131873Feb 27, 2014Body and structure. Toyota has been offering Corrosion-Resistant Compound ("CRC") campaigns for different model year ("MY") Toyota vehicles registered in certain cold climate states with high road salt use. Toyota Motor Sales. U.S.A. Inc. ("TMS") has developed this Dealer Information Pack to apply across all current and any potential future CRC campaigns
• 10131872Feb 27, 2014Body and structure. Toyota has been offering Corrosion-Resistant Compound ("CRC") campaigns for different model year ("MY") Toyota vehicles registered in certain cold climate states with high road salt use. Toyota Motor Sales. U.S.A. Inc. ("TMS") has developed this Dealer Information Pack to apply across all current and any potential future CRC campaigns
• 10131928Feb 5, 2014Brakes, Equipment. A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general tips for the inspection and/or installation of Toyota Complete Maintenance Care (TCMC) front brake pads and discs. Always refer to the model specific Repair manual and TIS…
• 10131951Jan 23, 2014Tires. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10131966Jan 17, 2014Body and structure. Toyota will initiate a Limited Service Campaign (LSC D0D) to inspect and, based upon Toyota?s inspection criteria, apply Corrosion-Resistant Compounds (CRC) to key areas of the frame assembly of certain 2004-2006 model year Tundra vehicles without significant rust perforation until July 31, 2015.
• 10131961Jan 14, 2014Air bags. Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
• 10131993Dec 19, 2013Visibility (wipers, defrost, mirrors). This bulletin is now obsolete. Please see T-SB-0185-13.
• 10131988Dec 19, 2013Visibility (wipers, defrost, mirrors). The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
• 10132055Nov 4, 2013Air bags, Seats, Equipment. Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Toyota may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in…
• 10132136Oct 23, 2013Visibility (wipers, defrost, mirrors). The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
• 10132097Oct 17, 2013Fuel system. Some 2005 ? 2009 model year 4Runner, 2006 ? 2007 model year Land Cruiser, 2005 ? 2007 model year Sequoia, and 2005 ? 2006 model year Tundra vehicles equipped with the 2UZ-FE (4.7 L) engine may exhibit a MIL ?ON? condition for the following Diagnostic Trouble Codes (DTCs): ? P0412 ? Secondary Air Injection System Switching Valve ?A? Circuit ? P0418 ? Secondary Air Injection System Relay ?A? Circuit ? P1440/P1443 ?…
• 10132084Oct 1, 2013Transmission and drivetrain. The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly
• 10062013Sep 13, 2013Equipment. Summary to be provided on a future date.
• 10131985Sep 12, 2013Equipment. Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
• 10131984Sep 9, 2013Equipment, Brakes. A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the Brake Pedal Force Gauge. Refer to the appropriate Repair Manual for parking brake pedal travel inspection and adjustment specification.
• 10062051Aug 1, 2013Equipment. Summary to be provided on a future date.
• 10132048May 22, 2013Tires. Please refer to the following recommendations for the best practices for vehicle tire rotations.
• 10062016May 22, 2013Tires. Summary to be provided on a future date.
• 10132295Apr 23, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0054-13.
• 10132287Apr 23, 2013Equipment. California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guidelines outlined in this bulletin to ensure proper label application.
• 10132281Apr 4, 2013Body and structure, Back-over prevention (rear camera). If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
• 10133860Feb 27, 2013Electrical system. The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.
• 10133836Feb 20, 2013Transmission and drivetrain. This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
• 10133867Feb 7, 2013Equipment. SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
• 10133901Jan 29, 2013Equipment. This bulletin is now obsolete. Please see T-SB-0012-13.
• 10133897Jan 29, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the TIS and the CUW.
• 10133915Jan 3, 2013Air bags. Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not perform as expected, please follow the steps in the recommendations section below.
• 10133878Jan 2, 2013Electrical system. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates…
• 10075945Nov 27, 2012Engine. Some 2005 - 2009 model year 4Runner, 2006 - 2007 model year Land Cruiser, 2005 - 2007 model year Sequoia, and 2005 - 2006 model year Tundra vehicles equipped with the 2UZ-FE (4.7 L) engine may exhibit a MIL "ON" condition for the following Diagnostic Trouble Codes (DTCs): • P0412 - Secondary Air Injection System Switching Valve "A" Circuit • P0418 - Secondary Air Injection System Relay "A" Circuit • P1440/P1443…
• 10061665Nov 27, 2012Engine. Summary to be provided on a future date.
• 10133974Oct 4, 2012Body and structure. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur.
• 10061649Oct 4, 2012Tires. Summary to be provided on a future date.
• 10045140Jun 13, 2012Vehicle speed control. Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied.
• 10042555Sep 6, 2011Air bags, Seats. Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags.
• 10039109May 31, 2011Transmission and drivetrain. Toyota: information on installing manual transmission shift lever or park neutral position switch.
• 10034284Feb 4, 2010Engine cooling. Toyota: techstream ecu flash reprogramming procedure. Flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. Model years from 2001-2011.
• 10021714May 15, 2007Engine cooling. Malfunction indicator lamp on with dtc p0418 and/or p2445.
• 10021180Nov 28, 2006Tires. Direct-type tire pressure warning system diagnostic tips.
• 10019674Mar 1, 2006Engine cooling. Excessive sulfur odor.
• 10019330Jan 20, 2006Transmission and drivetrain. Transmission extension housing seal leak (2wd only). A750e transmission may display evidence of a transmission fluid leak from the transmission extension housing seal (tailshaft seal assembly).
• 10018402Nov 18, 2005Tires. Tire pressure warning system diagnostic trouble code c2176.
• 10018230Nov 16, 2005Engine cooling. Malfunction indicator lamp on diagnostic trouble code p0171, p0174, p2195, or p2197.
• 10018292Nov 3, 2005Seat belts. Seat belt extender.
• 10197476May 4, 2001Equipment. Replacement vin plates.
• 10197473Jan 18, 1991Equipment. Product general information.

← All problems reported for the 2006 Toyota Tundra