2008 Audi TT Technical Service Bulletins

409 technical service bulletins (TSBs) are on record for the 2008 Audi TT. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10250668Nov 13, 2012Steering. Loud cracking or rubbing noises when steering (cars without Audi magnetic ride suspension)
• 10122857Nov 13, 2012Suspension, Steering, Equipment. Supersedes Technical Service Bulletin Group 40 number 12-24 dated June 6, 2012. Loud cracking or rubbing noises when turning steering wheel. Steering is not affected and will operate normally. Prior to performing this TSB, check whether the vehicle is equipped with rubber shock absorber stop and the plastic cap on the shock. Vehicles equipped with the Audi magnetic ride suspension may not be equipped with these…
• 10065366Nov 13, 2012Steering. Summary to be provided on a future date.
• 10122804Oct 29, 2012Fuel system, Electrical system. MIL on. Engine misfire. Poor performance. Unnecessary High Pressure Fuel Pumps replacement due to Guided Fault Finding test plans not being performed or interrupted when the following DTC?s are present in the engine control module.
• 10122766Oct 24, 2012Exterior lighting. Supersedes Technical Service Bulletin Group 94 number 11-52 dated October 11, 2011. Condensation is visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, or third brake light lens. Damp air settles on the inside of a cold lens, which creates condensation. The headlight circulation system allows air from the outside to flow through the headlights.
• 10122799Oct 12, 2012Engine. Supersedes Technical Service Bulletin Group 17 number 12 - 31 dated August 30, 2012. Oil consumption measurement - Repair Authorization (CA). In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine.
• 10122771Oct 4, 2012Electrical system, Equipment. Supersedes Technical Service Bulletin Group 91 number 11 ? 83 dated April 15, 2011. The customer may report that the illumination of the dash insert, the air conditioning control panel or the inside light flickers when briefly pressing the accelerator in P or N or when shifting down while driving downhill. Only vehicles with PR number 8GH may be affected.
• 10122772Oct 1, 2012Back-over prevention (rear camera). Supersedes Technical Service Bulletin Group 91 number 10 - 60 dated September 28, 2010. Parking aid sporadically warns of obstacles when none exist. Parking aid is inoperative or provides constant warning. Various parking aid sensor fitting issues. Environmental conditions.
• 10250430Aug 30, 2012Engine cooling. Oil consumption measurement - Repair Authorization (CA)
• 10043872Mar 16, 2012Engine cooling. Audi: 01 mil on (p1297, p2187, p2279), oil leaks, pressure loss, system too lean at idle speed, and intake air system leak. There may be whistle noise/air rushing noise from the engine. Also included model audi tts model years 2010-2011.
• 10043928Mar 9, 2012Engine cooling. Audi: imrc (intake manifold rc) motor warranty extension.
• 10043920Mar 9, 2012Fuel system. Audi: 24t4 update fuel pressure sender (warr_ext) it is possible that the fuel pressure sender for low-pressure may fail on audi vehicles with 2.0l tfsi engines built within a specific period.
• 10044087Mar 6, 2012Fuel system. Audi: on some vehicles, the fuel pressure sensor, imrc motor, or pressure valve may fail on tfsi engines, manufactured within specific period.
• 10043525Jan 12, 2012Electrical system, Engine cooling. Audi: engine has reduced engine performance without loss of power or stalling; circuit grounds; fuel quality poor; mil is constantly illuminated or flashing; rough idle; ignition coils incorrectly installed; electrical connections loose or damaged.
• 10043389Dec 9, 2011Air bags. Audi: some model year vehicles must have the service part for the airbag control unit coded and/or parameter using svm code listed in etka. Models a4, s4, a5, s5, q5, tt, tts, a3, pa , c6, a6 pa, d4, a8,c7 a7.
• 10043273Dec 9, 2011Engine cooling. Audi: some model year vehicles may experience an intake manifold runner control bank 1 stuck open, electrical malfunction of intake flap for airflow control and/or sensor voltage circuit a, low voltage.
• 10043026Dec 1, 2011Engine cooling. Audi: see document search button for owner letter. Information pertaining to certain model vehicles with 2.0l engine crankcase ventilation (pcv) valve and intake manifold runner control motor warranty extension.
• 10042390Oct 26, 2011Fuel system. Audi: bulletin to assistance in fuel pressure sensor being diagnose properly.
• 10037825Dec 3, 2010Equipment. Volkswagen: warranty extension for the headlight bulbs.
• 10037348Dec 1, 2010Transmission and drivetrain. Audi: the clutches could operate less smoothly than before due to a bushing wearing out prematurely. The transmission may jerk as it shifts. *rm updated 6/7/11.
• 10035345Oct 20, 2010Exterior lighting. Audi: daytime running lights do not work. Daytime running lights do not work on vehicles with xenon headlights. The thumb wheel or option for daytime running lights is turned off by mistake.
• 10066873Sep 10, 2010Suspension. Summary to be provided on a future date.
• 10035249Sep 1, 2010Engine cooling. Audi: mil on; rough idle; one or more of the following dtcs are stored-dtc p0300 (random/multiple cylinder misfire detected); dtc p0301-0312 (cyl. 1 misfire detected-cyl.12 misfire detected); engine may have reduced performance without significant loss of power or stalling.
• 10036487Aug 1, 2010Transmission and drivetrain. Audi service campaign: see document search button for owner letter. See document search button for owner letter. Vehicles equipped with direct shift gearbox (dsg) service mechatronic unit. It is possible that a bushing inside the mechatronic unit has the potential to wear out prematurely, causing the clutches inside the transmission to operate less smoothly than before.
• 10035248Jun 1, 2010Engine cooling. Audi: mil on; rough idle, one or more of the following dtcs are stored-dtc p0300 random/multiple cyliner misfire detected; dtc p0301-0312 (cyl. 1 misfire detected-cyl. 12 misfire detected); engine may have reduced performance without significant loss of power or stalling.
• 10034747May 25, 2010Seat belts. Audi: seat belts retract slowly. Seat belt is routed back to the reel in such a way that the speed of retraction is slowed. Routing and retraction force of the seat belt changed to improve the retraction and the belt guide has improved clearance for the belt webbing.
• 10034746May 5, 2010Exterior lighting. Audi: automatic headlight switches on and off without reason. Headlight turns on or off early or late when the light witch is in the auto position; after replacing the rain light sensor g397 or after replacing the windshield, the automatic headlight may turn or off without change of ambient brightness. Headlights operate normally if the light switch is in the on or off position.
• 10035268Mar 24, 2010Electrical system. Audi: software version management (svm) operating instructions. Detailing the general process for carrying out a software version management (svm) software update for any tsb or required vehicle update (rvu). Troubleshooting information is included.
• 10034344Jan 29, 2010Engine cooling, Fuel system, Other or unknown. Audi: mil on and one or more of the following dtcs are stored in the ecm data memory-p310b (low pressure fuel system regulation, fuel pressure outside tolerance); p129f or p008b (low pressure fuel system, pressure too high); p129e or p008a (low pressure system, pressure too low); p2540 (low pressure fuel system, pressure out of range); p0087 (rail fuel pressure system, pressure too low). Models a3,4,6,8, s6,8, rs4…
• 10033025Jan 12, 2010Fuel system. Audi: due to fuel intrusion into the low pressure system fuel pressure sensor (g410), a false signal may be sent to the controller, resulting in a reading that is out of tolerance. Comparing measure value block 103 with 106 is not an accurate method to diagnose low side fuel pressure sensor g410.
• 10033327Dec 1, 2009Engine cooling. Audi: engine stalls or idles erratically immediately after cold start in extremely cold weather (below 20%f).
• 10032191Aug 4, 2009Exterior lighting. Audi: there are two separate conditions that both occur in vehicles with bi-xenon, with or without adaptive lighting (afs). One xenon light on either side sporadically flickers or flashes and goes out. One xenon light on one side fails permanently.
• 10030593Jun 30, 2009Electrical system, Fuel system. Audi: mil light on and dtc p2294 (fuel pressure regulator 2 control circuit), p2295 (fuel pressure regulator 2 control circuit low), p2296 (fuel pressure regulator 2 control circuit high) in fault memory drivability is not affected. Wiring harness to high pressure pump might be stressed and tightly bent at the pump connector. The harness also might be bent around sharp edges of cylinder head. No models listed.
• 10030587May 19, 2009Exterior lighting. Audi: there are two separate conditions that both occur in vehicles with bi-xenon, with or without adaptive lighting (afs): one xenon light on either side sporadically flickers or flashes and goes out. When headlamps are turned off and on again or at ignition cycle, the headlamps may function properly or exhibit the same behavior; one xenon light on one side fails permanently.
• 10030630May 14, 2009Exterior lighting. Audi: headlight, low beam may not work. There are two separate conditions that both occur in vehicles with bi xenon, with or without adaptive lighting(afs). One xenon light on either side sporadically flickers or flashes and goes out. One xenon light on one side fails permanently.
• 10032290May 13, 2009Electrical system. Audi: software version management (svm), operating instructions. Svm is a process to update the programming in flashable (re-programmable) control modules and/or to document changes in software levels in audi vehicles. This system uses the vas 5051b or vas 5052 diagnostic tools to send vehicle specific data to the svm database, to download instructions from the svm database, and to flash control units for…
• 10028768Dec 15, 2008Electrical system. Audi: software version management(svm) operating instructions. Its a process to update the programming in flashable (reprogrammable) control modules and/or to document changes in software levels in all audi vehicles.
• 10027923Nov 19, 2008Wheels. Audi: wheel bolts require torque adjustment. Torque sticks and torque extension bars are not approved by audi of america, inc. And should not be used to apply torque to wheel bolts. All audi models included.
• 10026090Mar 3, 2008Fuel system. Audi: due to fuel intrusion into the low-pressure system fuel pressure sensor (g410), a false signal may be sent to the controller resulting in a reading that is out of tolerance.
• 10024698Mar 3, 2008Electrical system. Mil on (dtc p0642, p2004, p2008, p3137, p3138 in ecm).
• 10024697Mar 3, 2008Fuel system. Mil on (dtc p310b, p129f, p2293, p0087).
• 10032808Dec 20, 2007Transmission and drivetrain. Audi: avoiding damage to haldex clutch and final drive. The haldex clutch's oil filler plug and drain plug must not be confused with the final drive's oil filler plug and drain plug. The integrated housings of the haldex clutch and final drive, the drain plugs and the filler plugs of the two systems are often mixed up. This leads to avoidable maintenance mistakes, which can cause the malfunction of the haldex…
• 10024441Dec 20, 2007Engine cooling. Avoiding damage to haldex clutch and final drive.
• 10032848Dec 17, 2007Seat belts. Audi: seat belts retract slowly. Driver/passenger seatbelt retracts slowly after unbuckling. This condition does not affect seatbelt operation. The seatbelt is routed back to the reel in such a way that the speed of retraction is slowed. Replacement of seatbelt does not fix this condition. Model years 2007-2008 only.
• 10024446Dec 17, 2007Seat belts. Seat belts retract slowly after unbuckling.
• 10032251Nov 29, 2007Exterior lighting. Audi: automatic headlight switches on and off without reason. Automatic headlight switches on too early or too late, switches off too late or comes on too late when the sun shines brightly. After replacing the rain light sensor or after replacing the windshield, the automatic headlight switches on and off without reason. Headlight can still be operated manually.
• 10023949Nov 29, 2007Exterior lighting. Automatic headlight switches on and off without reason.
• 10032270Oct 16, 2007Exterior lighting. Audi: rear turn signal or backup light does not work on one side. Message concerning a light bulb is displayed in the driver information display. The message may be static or sporadic. The backup light and/or the turn signal on one side may not work.
• 10023895Oct 16, 2007Exterior lighting. Rear turn signal or backup light does not work on one side.
• 10032271Oct 9, 2007Electrical system, Engine cooling. Audi: rvu-3.2l rerouting engine wiring harness (17). Required vehicle update is in effect for 15 months from date of publication. After that date, this rvu will expire and no longer be in effect. Wiring to the secondary air solenoid must be rerouted in the engine compartment.

← All problems reported for the 2008 Audi TT