2001 Chevrolet Cavalier Engine cooling Problems
- Complaints
- 29about this part
- Share
- 12%of 243 total for the year
- Median mileage
- 67,000miles
- Trend
- StableComplaints filed in the last 3 full calendar years are within 25% of the 3 years before.
NHTSA recorded 29 complaints about the engine cooling of the 2001 Chevrolet Cavalier, 12% of the 243 complaints for this model year. Where a mileage was given, the median is 67,000 miles. 1 a fire, according to the filers.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“In december, 2006 I had a new alternator and a new fuel pump put in (895.00). 1/10/07 my ignition module and the fuel pressure regulator went out (695.45). 5/14/07 my ignition coil needed replacing (252.18). November 8, 2007 I needed to replace the ignition switch and valve cover gasket ($500) I'm am tired of repairing. It's got an electrical problem that's causing my ignition stuff to burn out.”
NHTSA complaint #10252905, filed 2008-12, 115,000 miles“While driving, the vehicle stalled. The cause was not determined. The vehicle was taken in four times. The spark plug wires were replaced. The vehicle stalled while in motion then would restart. The problem could not be duplicated on one occasion. The passenger window was clicking, and the regulator in the front door window was replaced.”
NHTSA complaint #10074301, filed 2004-06, 40,000 miles“05-17/01 replace left front strut & bearing sublet: install new clips 12-26-01 replace surge tank cap 01-28-02 replace wire ends at evap canister vent switch 12-06-02 replaced left rear wheel hub replaced evap core and evac 04-03-03 replaced 2 sensors 06-05-03 air quit - got estimate to replace suction line & shaft seal for air conditioner 06-09-03 cruise control quit coolant light came on twice while driving - haven't gotten estimate on yet”
NHTSA complaint #10070373, filed 2004-01, 23 miles“Vehicle making a whining noise when accelerating. Temperature gauge raising to 200. Occasionally, the thermostat light comes on and stays on for about 5 to 10 minutes then goes out. Checked water in overflow, level was only slightly low. Added some anti-freeze & then noticed water on the ground after driving. Engine was replaced in feb 2003. Then the problem was it overheated & ran out of water. At that time there was no indication of there even being a problem.”
NHTSA complaint #10047637, filed 2003-11, 57,800 miles“2001 Chevrolet Cavalier developed problems with the brakes and the engine.***no answer required***. While turning the steering wheel the consumer heard grinding/rubbing noises intermittently. The fog lamp went out. The brakes were noisy and would stick when applied. Water leaking into the trunk. The vehicle wouldn't start and the vehicle check engine light illuminated. The keyless entry system and alarm stopped working. The transmission not shift into low gear. The daytime running light would not shut off. The HVAC blower would not work in the first and second speed. …”
NHTSA complaint #10136689, filed 2005-09, 96,376 milesRelated service bulletins
- 10251890Mar 13, 2024This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank…
- 10250775Feb 22, 2024This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large…
- 10249579Jan 12, 2024This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10242843Sep 1, 2023The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the…
- 10242262Aug 24, 2023This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and…
- 10236164Apr 24, 2023This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308…
- 10234110Mar 17, 2023This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
- 10228888Dec 14, 2022This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or…
- 10227056Nov 9, 2022This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large…
- 10222796Sep 14, 2022This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2005 | 6 | 2% |
| 2004 | 15 | 5% |
| 2003 | 43 | 6% |
| 2002 | 22 | 11% |
| 2001 | 29 | 12% |
| 2000 | 54 | 17% |
| 1999 | 44 | 18% |
| 1998 | 55 | 16% |
| 1997 | 106 | 20% |
| 1996 | 117 | 23% |
| 1995 | 82 | 30% |
| 1994 | 56 | 26% |
| 1993 | 41 | 28% |
| 1992 | 15 | 11% |
| 1991 | 8 | 15% |
| 1990 | 7 | 13% |
| 1989 | 10 | 23% |
| 1986 | 6 | 33% |
| 1984 | 1 | 13% |
Other parts of the 2001 Chevrolet Cavalier
56 complaintsBrakes
42 complaintsTransmission and drivetrain
34 complaintsFuel system
29 complaintsSteering
26 complaintsAir bags
21 complaintsSuspension
15 complaintsBody and structure
14 complaintsEquipment
11 complaintsVisibility (wipers, defrost, mirrors)
11 complaintsOther or unknown
10 complaintsSeat belts
8 complaints
← All problems reported for the 2001 Chevrolet Cavalier
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology