Skip to content
Fuel systemPart report

2008 Chevrolet HHR Fuel system Problems

Complaints
85about this part
Share
14%of 616 total for the year
Median mileage
123,027miles
Trend
FallingComplaints filed in the last 3 full calendar years are at least 25% lower than in the 3 years before.

NHTSA recorded 85 complaints about the fuel system of the 2008 Chevrolet HHR, 14% of the 616 complaints for this model year. Where a mileage was given, the median is 123,027 miles. 1 a fire, according to the filers.

Example complaints

Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.

“I went to start the car in my driveway, smelled gas from the rear driver's side tire. I then shut off my car and looked. I have a leak in the fuel line, after researching seems that this has happened before in this make and model. I do not want to move the car or pay for a repair that is a design flaw.”

NHTSA complaint #11375910, filed 2020-11, 108,500 miles

“Fuel line rusted and leaking near rear driver side door/tire (next to gas tank). I have seen numerous other complaints online regarding the same issue in hhrs. From my research, it appears that the routing of the line combined with the heat shielding lead to moisture trapping and corrosion more quickly than expected.”

NHTSA complaint #11048825, filed 2017-11, 65,000 miles

“Vehicle leaks gas, the fuel line leakes, below the driver side rear door. I've owned two HHR's and both have had this problem, same exact spot. The line rotted out and is leaking fuel on the ground. I can see and smell it.”

NHTSA complaint #11394352, filed 2021-02, 151,802 miles

“The fuel line on my vehicle developed a leak at the left rear tire. I had to buy and install an aftermarket fuel line kit. I found that the metal fuel line has rusted through. When removing the old fuel line the purge line broke open at a rusty area. These two lines and a brake line run through a tubular knitted heat shield in this area. The heat shield had collected dirt and salt and was damp on a dry day when I was working on the line replacement. Poor design.”

NHTSA complaint #11338691, filed 2020-07, 130,000 miles

“My 2008 HHR panel ls has a fuel leak and it is located on the driver side just in front of the rear left car. After investigation I believe it is rusted. I understand chevy put a sleeve around the fuel line for whatever reason and living up north it has trapped water and rusted. The fuel line is near the exhaust and I fear it might ignite or possibly trap myself or a drive in a flaming vehicle. Can you tell me if this problem is ongoing and has been recalled.”

NHTSA complaint #11256712, filed 2019-09, 81,000 miles

Related service bulletins

Fuel system: other model years

YearComplaintsShare of year
20114723%
20105210%
20098417%
20088514%
2007517%
2006515%

Other parts of the 2008 Chevrolet HHR

Steering
297 complaints
Electrical system
108 complaints
Brakes
55 complaints
Air bags
38 complaints
Latches, locks and linkages
25 complaints
Transmission and drivetrain
22 complaints
Engine
20 complaints
Other or unknown
16 complaints
Electronic stability control
15 complaints
Suspension
15 complaints
Body and structure
13 complaints
Exterior lighting
12 complaints

← All problems reported for the 2008 Chevrolet HHR

About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology