2014 Chevrolet Silverado 3500 Technical Service Bulletins

826 technical service bulletins (TSBs) are on record for the 2014 Chevrolet Silverado 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10096046Feb 23, 2016Transmission and drivetrain. This preliminary information communication provides information to the technician on the steps need to diagnose and repair vehicles that may have stalling shudder and/or hard shifting into 1st gear or reverse vibration on launch (with excessive crankshaft end play). Technician will test to determine if the crank shaft end play is within specification 0.0015–0.0086 inch.
• 10116912Feb 22, 2016Equipment. This informational bulletin provides Information Regarding Servicing Components Located Near SIR Components and how to properly disable the SIR system for repairs at or near
• 10095945Feb 15, 2016Fuel system, Engine. This preliminary information communication provides information to the technician how to diagnose and repair a vehicle with an engine that runs with an intermittent crank no start with a diagnostic trouble code p0011 or p00c6 current or history. The camshaft position actuator solenoid valve may be sticking or binding causing the valve timing to be retarded. Dealer will need to cycle the camshaft position actuator…
• 10116896Feb 12, 2016Body and structure. This informational bulletin provides information on the proper ways to repair spray in bed liners and general information on the procedures around the spray in bed liners
• 10096033Feb 12, 2016Engine. This preliminary information communication advises the technician before replacing the crankshaft to review the following. Dealer should complete the service information diagnostics and the cost comparison worksheet for assembly repair vs replacement. Technician will use the latest version of 09-06-04-026g to verify the ecm calibration is not an aftermarket calibration. If the customer prefers to keep the original…
• 10095901Feb 9, 2016Engine. This preliminary information communication provides information to the technician about vehicles that may have a cold engine tick noise for 50 seconds at start up. Technician determines if the tick noise is possibly coming from the exhaust manifold, as this noise could easily be mistaken for an engine tick noise.
• 10096054Feb 8, 2016Equipment, Transmission and drivetrain. This preliminary information communication provides information to the technician that some vehicles may have a high pitched whine noise from the vehicle noticed when driving in auto 4wd. When the transfer case control module has to move the transfer case actuator motor the higher current passing through the module causes an "electronic buzz or whine" within some of the capacitors in the module that can be heard by…
• 10096079Feb 2, 2016Engine cooling. This preliminary information communication provides information to the technician that some vehicle may have an “exhaust fluid quality poor” on the driver information center or a diesel exhaust fluid warning lamp on or other exhaust fluid quality related concerns. Technician will inspect the diesel exhaust fluid for contamination.
• 10095683Feb 2, 2016Engine, Equipment. This preliminary information communication provides information to the technician on vehicles that may have an intermittent high idle. If a technician has duplicated, or the customer description aligns with the speeds mentioned in the idle speed description tables, the idle speed should be considered a normal characteristic of current vehicle design.
• 10095352Jan 30, 2016Steering. This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have a grind, pop, shudder or bind feeling/noise in the steering column when turning left or right. Technician will inspect for the lower column bearing to be out of position and the upper intermediate steering shaft to lower column shaft bolt and nut may be contacting the…
• 10112302Jan 28, 2016Seats, Air bags. This informational bulletin provides Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
• 10246963Jan 13, 2016Equipment. Changing Turn-By-Turn Voice Response To Metric Or English Units
• 10250067Jan 1, 2016Equipment. Infotainment System Will Not Return to Media After Bluetooth Call Ends
• 10246639Jan 1, 2016Steering. Power Steering Noise or Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Conditions
• 10201115Dec 1, 2015Equipment, Other or unknown. OnStar Voice Fallback Number Update
• 10201103Dec 1, 2015Equipment, Engine. Clean Exhaust Filter see owners manual now or cleaning exhaust filter keep driving until message is cleared displayed on DIC, DTC P2463 May be set
• 10201102Dec 1, 2015Fuel system, Engine cooling, Engine. Information on Diesel Exhaust Fluid (DEF) Filing Instructions, Frozen Tank Status and General Information
• 10201101Dec 1, 2015Equipment. Information on Mounting Points for Pickup Box Accessories
• 10201100Dec 1, 2015Engine, Engine cooling. New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber
• 10201098Dec 1, 2015Transmission and drivetrain, Engine. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10190503Dec 1, 2015Engine, Transmission and drivetrain. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
• 10190380Dec 1, 2015Engine cooling. Information on Diesel Exhaust Fluid (DEF) Filling Instructions, Frozen Tank Status and General Information In operating temperatures of 15°F (−9°C) or less, customers may comment on an “Exhaust Fluid Range” message displaying on the DIC even though the DEF fluid has been filled. When the DEF is frozen, the level sensor cannot determine the fluid level in the tank. If this occurs the logic of the PCM will…
• 10126401Oct 30, 2015Body and structure. This informational bulletin provides information on the PQC assembly replacement process - for dealers required to contact PQC prior to replacing an assembly (U.S. and Canada only).
• 10126395Oct 27, 2015Engine cooling. This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
• 10126393Oct 26, 2015Equipment. This warranty administration bulletin provides policy information on an updated warranty and policy exchange program for electronic products through GM authorized Electronic Service Centers (ESCs) (U.S. and Canada).
• 10126385Oct 22, 2015Electrical system, Equipment. This preliminary informational bulletin adds the 2014 - 2016 model years to cleaning information to correct a customer concern of seeing a white film/residue on the IP pad and/or door trim panels.
• 10126375Oct 14, 2015Electrical system, Equipment. This informational bulletin provides information to dealership personnel on the use of non-GM approved battery chargers and booster packs.
• 10126370Oct 13, 2015Equipment, Transmission and drivetrain. This informational bulletin provides information to dealership personnel on proper engine and automatic transmission/transaxle identification.
• 10126369Oct 13, 2015Electrical system. This informational bulletin provides information that may be useful in diagnosing/testing batteries that have set for a long period of time and/or set in cold weather climates to correct a customer concern of symptoms that include, but not limited to, a slow or no crank condition that may be caused by a discharged battery.
• 10126355Oct 6, 2015Equipment. This warranty administration bulletin provides policy information on Causal Part requirements for transactions submitted to GM for payment.
• 10126350Oct 5, 2015Equipment. This warranty administration bulletin provides policy information on an updated warranty and policy exchange program for electronic products through GM authorized Electronic Service Centers (ESCs) (U.S. and Canada).
• 10126349Oct 2, 2015Wheels. This warranty administration bulletin provides retail, wholesale and fleet personnel with General Motors recommendations for customer concerns related to wheel alignment.
• 10126346Oct 2, 2015Engine cooling, Fuel system. This informational bulletin provides information to dealership personnel on identifying Duramax Diesel overpower engine breakdown or non-function due to aftermarket power-up devices vs. non overpower engine non-function of pistons, cylinders, valve train components, and DTC P003A or P111D set.
• 10126345Oct 2, 2015Engine cooling. This preliminary informational bulletin provides service personnel with a guide to determine which SI documents and scan tool parameters to reference when encountering an: Exhaust Fluid Quality Poor message displayed, and a Reductant Fluid Quality Test status that will Pass, Time Out, Fail or Interrupt and other DEF messages that maybe observed.
• 10126344Oct 2, 2015Engine cooling. This preliminary informational bulletin provides technicians with repair information on removing seized exhaust temperature sensors.
• 10126343Oct 1, 2015Engine cooling. This preliminary informational bulletin provides dealership personnel with policies and procedures regarding damaged, disassembled or improperly packaged turbochargers returned to Warranty Part Center.
• 10114680Aug 24, 2015Engine cooling. This Preliminary Information communication advises the technician that the 6.6L Duramax Diesel Engine Part number 12638502 has been placed on a parts restriction through the General Motors Product Quality Center. Dealer will need to contact the General Motors Product Quality Center for further assistance.
• 10113787Aug 3, 2015Seat belts. This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button sticking.
• 10059095Aug 1, 2015Engine, Engine cooling. General motors: in some vehicles and trucks, when transferring intake manifold to replace an engine long service block, due to internal damage, extreme caution must be taken for component debris via broken, bent or missing intake valves.
• 10138148Jul 28, 2015Engine cooling, Electrical system. This informational bulletin provides technicians with information on identifying non-GM ECM Calibration use and Power-Up hardware detection in Duramax® Diesel Engines using GDS 2.
• 10138139Jul 23, 2015Electrical system, Equipment. This technical bulletin provides repair information for the correction of a customer concern of short duration musty odors emitted from the HVAC system at vehicle start-up in hot, humid conditions.
• 10138137Jul 21, 2015Electrical system, Equipment. This warranty administration bulletin provides policy information on ACDelco® replacement battery warranty procedures.
• 10114608Jul 16, 2015Equipment. This Preliminary Information communication advises the technician of a concern where the Onstar® menu is missing from the radio display. Pressing the white Onstar® push to talk button and say hide Onstar® menu will hide the menu and saying unhide menu will make the menu come back again.
• 10138124Jul 14, 2015Body and structure. This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only)
• 10114598Jul 10, 2015Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10089965Jun 15, 2015Brakes. 15203a - service update (revised service procedure). This bulletin provides a service procedure to inspect and, if required, retighten the torque on the right-rear-brake-line-bracket bolt to the rear-axle on certain fort wayne assembly plant built 2014-2015 chevrolet silverado ld, 2015 chevrolet silverado hd, 2014-2015 gmc sierra ld, 2015 gmc sierra hd and 2015 gmc sierra denali ld vehicles.
• 10089949Jun 15, 2015Fuel system. 14653 - special coverage. Some 2010-2014 model year chevrolet express, 2011-2014 model year chevrolet silverado hd, 2010-2014 model year gmc savana and 2011-2014 model year gmc sierra hd vehicles equipped with a 6.6l engine (rpo lml or lgh), may have a condition where the indirect fuel injector can become stuck in the closed position or can have low flow. This condition could result in the illumination of the…
• 10089964Jun 10, 2015Brakes. 15203 - service update. This bulletin provides a service procedure to inspect and, if required, retighten the torque on the right-rear-brake-line-bracket bolt to the rear-axle on certain fort wayne assembly plant built 2014-2015 chevrolet silverado ld, 2015 chevrolet silverado hd, 2014-2015 gmc sierra ld, 2015 gmc sierra hd and 2015 gmc sierra denali ld vehicles. These vehicles may have been assembled with an…
• 10059109Jun 1, 2015Brakes. Gmc/chevrolet: service procedures on certain vehicles to inspect, retighten the torque for right rear brake line bracket bolt to rear axle due to incorrectly being torqued allowing brake line to wear against rear axle housing and brake fluid leakage. Model 2014-15 silverado ld, sierra ld, 2015 silverado hd, sierra hd, sierra denali hd.
• 10114474Apr 20, 2015Equipment. This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Apple USB cable.

← All problems reported for the 2014 Chevrolet Silverado 3500