2022 Chevrolet Silverado 3500 Electrical system Problems
- Complaints
- 5about this part
- Share
- 18%of 28 total for the year
- Median mileage
- 50,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 5 complaints about the electrical system of the 2022 Chevrolet Silverado 3500, 18% of the 28 complaints for this model year. Where a mileage was given, the median is 50,000 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Message will appear that states : trailer brake system needs serviced “ When that appears and I am currently towing a trailer I lose all power to trailer including the brakes. I can’t signal I can’t use the trailer brakes. I’m towing 14,000 lbs and when I’m going down a 6% grade this is very dangerous. I have had vehicle in twice for this issue , first time I was told they replaced a controller, 2nd time they said no problems detected. For me to lose all power to tow vehicle is unacceptable and extremely dangerous”
NHTSA complaint #11574193, filed 2024-02“The contact owns a 2022 Chevrolet Silverado 3500. The contact stated that while driving 35 MPH with a trailer hitched to the vehicle, the trailer brake failed to respond on and off independently. Neither an independent mechanic nor a dealer was contacted. The trailer brake failure warning light was illuminated. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. …”
NHTSA complaint #11744609, filed 2026-06, 50,000 miles“The contact owns a 2022 Chevrolet Silverado 3500. The contact stated that while driving at various speeds, the tailgate would lower independently. Additionally, the contact stated the failure had been occurring from the day of the vehicle purchase and had gradually worsened. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 43,000.”
NHTSA complaint #11620583, filed 2024-10, 43,000 miles“The contact owns a 2022 Chevrolet Silverado 3500. The contact stated while the vehicle was in park(P), the tailgate opened unintendedly. There was no warning light illuminated. The contact stated that the failure was with the tailgate electronic switch. The contact was concerned that the vehicle could present a hazard for other drivers on the roadway should the tailgate open unintendedly. The dealer was not contacted; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 55,000.”
NHTSA complaint #11587902, filed 2024-05, 55,000 miles“The onstart module stopped working, no internet or gps conection is working, also the emergency call system is disabled, Onstart systems is disabled due the telematic control module fault..”
NHTSA complaint #11592177, filed 2024-06Related service bulletins
- 11024486May 16, 2025This bulletin advises the tech to inspect deeper into what may be to main cause of an engine failure.
- 11019017Apr 10, 2025This bulletin provides a procedure on how to check for a battery drain utilizing the Picoscope and how to measure the load on the system that may be causing a drain.
- 11017595Apr 3, 2025This service bulletin provides information on the proper Reflective High Temperature Heat and/or Insulating Tape to use for certain repairs, such as Wiring Harness Repairs.
- 11017244Mar 31, 2025The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other…
- 11017255Mar 25, 2025This service bulletin helps diagnose/reduce possible CCND issues on Transfer Cases - Service 4WD on DIC, Intermittent Failures, Noise Concerns, Driveline/Steering…
- 11017207Mar 21, 2025This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414…
- 11017031Mar 12, 2025This service bulletin provides information to diagnose batteries that have set for a long period of time and/or cold weather climates and testing those batteries.
- 11014579Feb 19, 2025This technical bulletin provides repair information to correct a customer concern of Diagnostic Tips For Park Assist Off Message / Unwanted Or False Park Assist Alerts / No DTCs.
- 11014230Jan 31, 2025This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
- 11014239Jan 29, 2025This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during…
Electrical system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 4 | 33% |
| 2024 | 19 | 37% |
| 2023 | 1 | 6% |
| 2022 | 5 | 18% |
| 2021 | 13 | 32% |
| 2020 | 5 | 12% |
| 2019 | 5 | 23% |
| 2018 | 3 | 16% |
| 2017 | 1 | 8% |
| 2016 | 6 | 12% |
| 2015 | 16 | 31% |
| 2014 | 1 | 10% |
| 2013 | 4 | 15% |
| 2012 | 2 | 9% |
| 2011 | 2 | 7% |
| 2009 | 1 | 10% |
| 2008 | 6 | 19% |
| 2007 | 2 | 5% |
| 2006 | 3 | 6% |
| 2005 | 9 | 20% |
| 2004 | 4 | 10% |
| 2003 | 6 | 14% |
| 2002 | 1 | 2% |
| 2001 | 4 | 6% |
| 2000 | 5 | 6% |
| 1999 | 2 | 4% |
| 1998 | 3 | 4% |
| 1997 | 3 | 5% |
Other parts of the 2022 Chevrolet Silverado 3500
5 complaintsBrakes
4 complaintsLatches, locks and linkages
4 complaintsEngine
3 complaintsTransmission and drivetrain
3 complaintsAir bags
2 complaintsVisibility (wipers, defrost, mirrors)
2 complaintsEngine cooling
1 complaintsExterior lighting
1 complaintsSteering
1 complaintsBody and structure
1 complaintsSuspension
1 complaints
← All problems reported for the 2022 Chevrolet Silverado 3500
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology