2004 Fleetwood Terry Problems
- Complaints
- 9filed with NHTSA
- Median mileage
- 25,000miles, 1 complaints with mileage
- Recalls
- 9campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 2004 Fleetwood Terry (complaints, recalls, investigations). Report an error
NHTSA recorded 9 consumer complaints for the 2004 Fleetwood Terry. The part named most often is body and structure, with 4 complaints (44% of the total), followed by equipment (3) and other or unknown (1). 1 of the complaints include a mileage, and 100% of those were filed for vehicles with under 50,000 miles; the median is 25,000 miles. Of all complaints, 2 a fire, according to the filers. NHTSA lists 9 recall campaigns and 0 technical service bulletins for this model year. Body and structure complaints overlap with 1 recall campaign filed under the same part. Equipment complaints overlap with 5 recall campaigns covering the labels filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Body and structure4 44%
- Equipment3 33%
- Other or unknown1 11%
- Suspension1 11%
- Tires1 11%
Example complaints
Body and structure: “The frame of my fifth wheel camping trailer broke in two where the king pin box is welded in the front while I was towing it on the highway. I was towing at approximately 60 MPH when I went over an overpass with an uneven lip at its edge which caused the failure. Online research that I've done shows that this is a problem common to trailer frames made by lippert components and supplied to numerous rv manufacturers. It is chalked up to normal wear and tear . Lippert only warranties their trailer frames for two years. …”
NHTSA complaint #11383230, filed 2020-12, 25,000 milesEquipment: “We were preparing to go camping in our '04 Terry quantum (bought new feb 08) and turned on frig to cool by electricity. Noticed next day unit was not cooling, tried the gas, still not cooling. My husband remembered someone told him about their rv catching on fire as result of the frig catching on fire. We called dometic service center, listened to a recording which stated a recall on all '04-'06 frig's with particular model/serial numbers to look for any leaks with yellow residue on back side of the unit or not cooling properly. …”
NHTSA complaint #10232769, filed 2008-06Suspension: “Dt: caller said that travel trailer came from the factory with a bent axle and axle alignment. Caller said vehicle jumped around the road. Dealer fixed the problem. Manufacturer paid dealer for the repairs. Caller was concerned about vehicle safety on the road.”
NHTSA complaint #10131966, filed 2005-09Mileage when problems were reported
100% of the 1 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 25,000 and 25,000 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 08V320000Jul 15, 2008Equipment › Recreational vehicle/trailerCovers: Fleetwood Terry 2003–2007, Revolution 2003–2007, Prowler 2003–2007 +20 more
Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel…
- 07V120000Mar 19, 2007Equipment › Recreational vehicle/trailerCovers: Fleetwood Terry 1997–2004, Bounder 1997–2004, Discovery 1997–2004 +20 more
Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is…
- 05V511000Nov 7, 2005Equipment › Other › LabelsCovers: Fleetwood Terry 2004, Prowler 2004, Wilderness 2004
Certain travel trailers fail to conform to the requirements of federal motor vehicle safety standard no. 120 "tire selection and rims for motor vehicles other than passenger cars." the tire and loading information placard contains incorrect "load range "b"…
- 05V433000Sep 27, 2005Equipment › Recreational vehicle/trailer › Lpg systems › Lines and fittingsCovers: Fleetwood Terry 2004–2005, Prowler 2004–2005, Wilderness 2004–2005
On certain fifth wheel trailers, the propane gas lines that run through the floor of the slide out room penetrate the floor too far from the outside wall causing the potential for pinched lines during slide out room operation.
- 05V289000Jun 21, 2005Body and structureCovers: Fleetwood Terry 2004–2005, Prowler 2004–2005, Wilderness 2004–2005
Certain fifth wheel travel trailers have missing welds on the chassis cross-members.
- 04V310000Jun 28, 2004WheelsCovers: Fleetwood Terry 2004, Triumph 2002–2004, Prowler 2004 +3 more
On certain fifth wheel and conventional travel trailers equipped with aluminum wheels may not have had the proper wheel lug nut torque applied. Additionally, paint applied to the mating surface of the hub may cause the lug nuts to be more sensitive to…
See all 9 recalls for the 2004 Fleetwood Terry → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
No technical service bulletins are on record for the 2004 Fleetwood Terry.
Other model years of the Fleetwood Terry
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2004 | 9 | 25,000 | 9 | — | — | — | Not enough data |
| 2001 | 9 | — | 3 | — | — | — | Not enough data |
| 1998 | 6 | — | 2 | — | — | — | Not enough data |
| 1997 | 6 | — | 1 | — | — | — | Not enough data |
All Fleetwood Terry model years
Frequently asked questions
How many NHTSA complaints does the 2004 Fleetwood Terry have?
NHTSA recorded 9 consumer complaints for the 2004 Fleetwood Terry as of Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2004 Fleetwood Terry is reported most often?
Body and structure is named most often, in 4 complaints (44% of the total), followed by equipment with 3.
Has the 2004 Fleetwood Terry been recalled?
NHTSA lists 9 recall campaigns for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2004 Fleetwood Terry reported?
Among the 1 complaints that include a mileage, the median is 25,000 miles and the middle half falls between 25,000 and 25,000 miles; 100% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.