2015 Ford Edge Technical Service Bulletins

182 technical service bulletins (TSBs) are on record for the 2015 Ford Edge. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10137145Apr 25, 2018Engine cooling. Some Ford and Lincoln vehicles equipped with a 2.7L or 3.0L EcoBoost engines may exhibit an oil leak from the engine oil pan RTV seal. Replace the oil pan by performing the published Workshop Manual (WSM) service procedures. After removing the oil pan, it is suggested to allow the crankcase to drain overnight to minimize the chance of residual oil contaminating the crankcase sealing rail.
• 10137141Apr 19, 2018Electrical system, Equipment. Some 2015-2018 Edge and 2016-2018 MKX vehicles may exhibit a concern with the remote start selections for heated steering wheel and/or heated seats grayed out in the cluster. To correct this concern, reconfigure the front controls interface module (FCIM) using As-Built Programming. Make sure you are connected to the internet when entering module programming to obtain the latest data.
• 10137131Apr 11, 2018Equipment, Engine cooling. Some 2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Police Interceptor Sedan/Explorer/Police Interceptor Utility vehicles equipped with AWD and built on or before 30-Jun-2016 may exhibit a propane or natural gas odor during idle or low speed driving. This may be due to break down of the power transfer unit (PTU) fluid caused by excessive heat. If the source of the odor is identified as originating from the PTU, an…
• 10137115Mar 30, 2018Engine cooling. Some 2015-2018 Fusion/MKZ/MKC/Escape/Edge vehicles equipped with a 2.0L EcoBoost engine may exhibit a runs rough condition with DTCs P0300, P0301, P0302, P0303, P0304 and/or P0316. This may be due to coolant intrusion due to corrosion on the engine block. To diagnose this concern, with the engine at normal operating temperature, pressurize the cooling system to 138 kPa (20 psi) and hold for 5 hours.
• 10137113Mar 30, 2018Equipment. Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems.
• 10136580Feb 19, 2018Engine cooling. Some 2015-2018 Edge and 2016-2018 MKX vehicles may exhibit an exhaust odor in the vehicle while the climate control system is in auto or recirculation mode. Customers may indicate the odor smells like sulfur or exhaust odors are entering the vehicle cabin. This concern may be more pronounced after hard acceleration, driving in hilly conditions and/or towing a trailer.
• 10136579Feb 15, 2018Body and structure. Some 2015-2017 Edge vehicles built on or before 10-Aug-2017 and 2016-2018 MKX vehicles built on or before 15-Dec-2017, equipped with a power liftgate and the hands-free liftgate activation feature may exhibit the liftgate opening or closing when a rear door is slammed shut, or the rear fascia is contacted such as kneeling or resting a foot on the fascia while the key is present. Follow the Service Procedure steps…
• 10136597Feb 14, 2018Equipment. 2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No repair attempts should be attempted to correct this concern.
• 10136592Feb 9, 2018Electrical system. When connecting the Vehicle Communication Module (VCM) and Integrated Diagnostic System (IDS) or Ford Diagnosis and Repair System (FDRS) to the DLC located on the driver side under the steering column at the GWM, make sure that the ignition is off before connecting the VCM. If the ignition is on or the engine is running during the connection, it can result in various warning lights being illuminated with diagnostic…
• 10136575Feb 2, 2018Body and structure. Some 2015-2018 Edge and 2016-2018 MKX vehicles equipped with a power liftgate and built on or before 2-Jan-2018 may exhibit an intermittent bounce back after closing has been commanded. Follow the Service Procedure steps to correct this condition.
• 10140323Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10138524Jan 10, 2018Equipment. The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts and Service - Parts Product Line Information - Keys/Entry Devices - Aftermarket Keyless Entry Keypad Code Access.
• 10140315Jan 8, 2018Transmission and drivetrain, Engine. Some 2013-2018 Escape/Fusion/MKZ vehicles equipped with 2.5L or 1.5L/2.0L/3.0L Ecoboost engine, 2015-2018 MKC/Edge/Explorer vehicles equipped with 2.0L/2.3L/2.7L EcoBoost engine, 2016-2018 MKX vehicles equipped with 2.7L Ecoboost engine, 2017-2018 Continental vehicles equipped with 2.7L/3.0L EcoBoost, and AWD may exhibit a fluid leak from the PTU intermediate shaft seal.
• 10138516Jan 8, 2018Engine cooling. Some 2013-2018 Escape/Fusion/MKZ vehicles equipped with 2.5L or 1.5L/2.0L/3.0L Ecoboost engine, 2015-2018 MKC/Edge/Explorer vehicles equipped with 2.0L/2.3L/2.7L EcoBoost engine, 2016-2018 MKX vehicles equipped with 2.7L Ecoboost engine, 2017-2018 Continental vehicles equipped with 2.7L/3.0L EcoBoost, and AWD may exhibit a fluid leak from the PTU intermediate shaft seal.
• 10127410Nov 8, 2017Electrical system, Engine cooling. Some 2015-2018 F150/Edge, 2016-2018 MKX and 2017-2018 Fusion, Continental vehicles equipped with a 2.7L engine may experience a malfunction indicator lamp (MIL) and/or wrench lamp with Diagnostic Trouble Codes (DTCs): P0116, P0117, P0118, P0119, P0217, P0330, P1026, and/or P130D.
• 10127405Nov 2, 2017Electrical system, Transmission and drivetrain. Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use the Ford Integrated Diagnostic System (IDS) service tool or Ford J2534 Diagnostic Software, select - Toolbox - Body - Security - PATS Functions - Parameter Reset. Follow the…
• 10125065Oct 5, 2017Electrical system, Body and structure. Some 2015-2017 Edge and 2016-2017 MKX vehicles, equipped with a power liftgate, and built on or before 13-Sep-2017 may exhibit a liftgate that intermittently opens uncommanded while parked with no keys near the vehicle. Follow the Service Procedure steps to correct this condition.
• 10119658Sep 19, 2017Equipment. Some 2015-2017 Edge and 2016-2017 MKX vehicles built on or before 15-Apr-2017 and 2017 Continental vehicles built on or before 19-Oct-2016 may exhibit a rattle noise from the underbody of the vehicle while moving. This may be due to the movement of loose floor pan underbody shield fasteners which are attached to the underbody shields. Follow the Service Procedure steps to correct the condition.
• 10115943Jul 17, 2017Body and structure. Some 2015-2017 Edge vehicles may exhibit dirt and/or dust accumulation at the bottom of the front and/or rear door openings. This may be due to extended driving on non-paved roads. Follow the Service Procedure steps to correct the condition.
• 10115953Jul 14, 2017Equipment. Some 2013-2017 Edge/MKX/Escape/MKC/Fusion/MKZ/Flex/MKT/Mondeo/Kuga/EcoSport AWD vehicles where diagnosis leads to a RDU clutch issue, a rear drive unit (RDU) service kit is available. Use the vehicle identification number (VIN) in the parts catalog to look for base part 4A232. If clutch assembly (base 4A232) is not listed in the catalog, this message does not apply. For vehicle repairs refer to updated Workshop…
• 10109012Apr 12, 2017Equipment, Engine cooling. 2013-2017 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police/Continental vehicles equipped with a 3.5L or 3.7L engine, all wheel drive (AWD) and a power transfer unit (PTU) that is being repaired or replaced for an internal failure must also have the vent hose replaced due to contamination in the hose.
• 10099088Mar 30, 2017Engine cooling. Some 2015-2017 edge and 2016-2017 mkx vehicles may exhibit an exhaust odor in the vehicle while the climate control system is in auto or recirculation mode. Customers may indicate the odor smells like sulfur, the exhaust odors are entering the vehicle cabin. This concern may be more pronounced after hard acceleration, driving in hilly conditions and/or towing a trailer.
• 10095858Feb 27, 2017Transmission and drivetrain, Equipment. Some 2007-2016 edge/mkx/flex/mkt/mkz/mks/taurus/taurus police/explorer/explorer police equipped with all wheel drive (awd) and built on or before 30-jun-2016 may exhibit a ticking and/or knocking noise coming from the driveline area. To identify this noise, refer to workshop manual (wsm), section 100-04, and follow the symptom chart. If the source of the noise is identified as the ptu and/or internal to the ptu…
• 10095624Feb 2, 2017Transmission and drivetrain. Multiple 2014-2016 vehicles equipped with 6f35 transmission and built on 1-jan-2014 and through 31-dec-2015 may exhibit harsh reverse engagement and harsh/delayed 3rd and 5th gear up/down shifts with no dtcs present. This may be due to a mechanically binding shift solenoid b (ssb). Verify harsh reverse and 3rd and 5th gear shift events are present. Using ids, identify the band number of ssb for use when ordering…
• 10095224Jan 27, 2017Equipment. Some 2015 edge,mustang and f150 vehicles with a 4" display may exhibit a 24 hour clock display that resets itself to a 12 hour display after cycling the ignition key. To correct the concern, reflash the front control display interface module (fcdim) to the latest calibration using ids version 103.05 or higher. Make sure you are connected to the internet when entering module programming to obtain the latest updates…
• 10095216Jan 27, 2017Engine. When servicing a 2.7l or 3.0l ecoboost engine, if the crankshaft pulley is removed, correct reassembly is critical to prevent potential engine failure. This includes installing a new crankshaft pulley bolt and accurately performing each stage of the crankshaft pulley bolt torque sequence. Crankshaft pulley related workshop manual (wsm) procedure and recommended tool (otc 4754 or equivalent) information have been…
• 10094643Dec 22, 2016Engine. Some 2015-2017 edge/mkx, escape/mkc, fusion/mkz and explorer vehicles equipped with a 2.0l or 2.3l may exhibit damage to the engine appearance cover, valve cover and/or intake manifold when attempting to remove the appearance cover. To reduce the possibility of damage, carefully pull straight upward on the underside of the cover at each fastener location to remove. Do not pull the cover forward or to the side.
• 10094612Dec 9, 2016Engine. Some 2015-2016 edge with 2.0l gasoline turbocharged direct injection (gtdi), 2015-2016 mustang and f-150 with 5.0l engine and 2016 explorer equipped with 2.3l gtdi engine may exhibit oil leak at engine oil pressure (eop) sensor threads. It is not required to replace the sensor if it is leaking from the threads. Remove and reseal the eop sensor, refer to workshop manual (wsm), sections 303-14. Check the oil level…
• 10094601Dec 2, 2016Seats. Some 2015-2016 edge and 2016 mkx vehicles built on or before 9-sep-2016 may exhibit a left side rear seat backrest that will not fold to less than 45 degrees from the floor on its own when unlatching the seat backrest using the second row seat control switch or second row seat backrest recline handle. This is caused by excessive resistance between the rear seat backrest frame and rear seat riser frame. Follow the…
• 10095995Nov 17, 2016Steering. Some 2010-2016 epas equipped vehicles may exhibit steering related noises. The workshop manual (wsm) diagnostic procedures have been updated in section 211-02. When diagnosing and repairing epas steering noises use the updated procedures.
• 10095972Nov 2, 2016Engine. Some 2015-2017 f-150, 2016 mkx, 2015 edge, 2017 fusion, mkz and continental vehicles equipped with a 2.7l/3.0l engine may appear to have low engine oil level if the proper procedures are not followed. Refer to the owners guide, maintenance, engine oil check section. When checking the engine oil level after shutting off the engine wait at least 15 minutes prior to checking in order to allow the oil to drain back to…
• 10091139Oct 27, 2016Equipment. Certain 2015 model year edge, 2015-2016 model year f-150, mkt, and police interceptor sedan, and 2016 model year escape, explorer, flex, fusion, mkx, mustang, police interceptor utility, taurus, and transit vehicles - electronic throttle body replacement
• 10091003Oct 26, 2016Tires. Setting the correct tire inflation pressure is an important step in the pre-delivery process and during routine maintenance intervals. Recent customer clinics revealed that most every vehicle in the clinics had the tire pressures set incorrectly. Tire pressures from the factory are not set to the correct specification. Maintaining the correct tire pressure is key to the ride characteristics of the vehicle and…
• 10091151Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090681Oct 17, 2016Brakes. Some 2008-2017 ford/mercury/lincoln vehicles equipped with sync may generate a vhr that identifies a concern with the brakes and suspension category indicating service is required due to a brake system warning lamp being illuminated. If the park brake was applied when the vhr was gathering data from the major vehicle systems, the brakes and suspension message will be reported as the vhr looks for any warning lamps…
• 10090671Oct 14, 2016Electrical system. Some 2013-2016 fusion/escape/mkt/flex/mks/taurus, 2015-2016 mkz/mkc/edge and 2016 mkx vehicles may exhibit various radio concerns including: speaker static with key-off, no audio after vehicle is first started with diagnostic trouble code (dtc) u0184, no volume control, or a stuck cd with no slot blockage. Prior to starting normal diagnosis for any of these conditions, verify the acm is at the latest calibration…
• 10090662Oct 10, 2016Steering. When hooking up the vehicle communication module (vcm) and integrated diagnostic system (ids) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition is off before connecting to ids. If the ignition is on or the engine is running during the hook up, it can result in various warning lights being illuminated with diagnostic trouble codes (dtcs), no start or no crank…
• 10090505Oct 10, 2016Engine. Some 2015-2016 f-150, c-max, edge, mks, taurus, and flex and 2016 expedition, explorer, escape, fusion, mustang, mkz, mkx, navigator, transit and transit connect vehicles equipped with a 2.0l, 2.5l, 3.5l or 3.7l gasoline engine and built on or before 31-may-2016 may exhibit an intermittent loss of power and/or an illuminated powertrain malfunction (wrench) lamp with diagnostic trouble codes (dtcs) p2111, p2112…
• 10109079Sep 30, 2016Seat belts. Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatbelt retracts at a high rate of speed. The Workshop Manual, Section 501-20A General Procedures has been updated with a locked seatbelt retractor releasing procedure.
• 10109074Sep 28, 2016Visibility (wipers, defrost, mirrors), Equipment. Some 2015-2016 Edge vehicles may exhibit a roof opening panel that is slow to close, stops, or bounces back while closing. Refer to the revised WSM, Section 501-17 for updated cleaning procedure and diagnostics.
• 10109046Sep 22, 2016Engine. Some 2015 Edge vehicles equipped with a 2.0L GTDI engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0054, P0137 and/or P0141 stored in the powertrain control module (PCM) memory. Follow the Service Procedure steps to correct the condition.
• 10109070Sep 21, 2016Engine cooling, Engine. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes…
• 10109065Sep 16, 2016Equipment. For 2015-2016 Edge vehicles, update the Integrated Diagnostic Software (IDS) to version 102.02 or higher prior to reprogramming or installing an anti-lock brake system (ABS) module.
• 10109063Sep 16, 2016Transmission and drivetrain. Some 2015-2016 vehicles equipped with 6F50/6F55 transmission Built On 11/2/2015 And Through 2/1/2016 may exhibit no reverse, 3rd and 5th gear and/or DTCs P0715, P0717, P0756 and/or P2701. This may be caused by the direct clutch snap ring out of position and/or damage to the direct clutch hub. The cause of the failure is the Tone Wheel surface putting uneven load on the snap ring.
• 10109085Sep 14, 2016Vehicle speed control. Certain 2015 Model Year Edge, 2015-2016 Model Year F-150, MKT, and Police Interceptor Sedan, and 2016 Model Year Escape, Explorer, Flex, Fusion, MKX, Mustang, Police Interceptor Utility, Taurus, and Transit Vehicles - Electronic Throttle Body Repair
• 10109029Sep 1, 2016Transmission and drivetrain. Some 2014-2016 Fusion and 2015-2016 Edge vehicles equipped with a 6F35 transmission and active start/stop feature may exhibit an illuminated malfunction indicator lamp (MIL) with a harsh transmission engagement after an active stop/start event. Diagnostic trouble code (DTC) P0C27 will be stored in the powertrain control module (PCM) memory. This condition may be caused by air entering the transmission fluid…
• 10092567Aug 23, 2016Equipment, Body and structure. Some 2015-2016 edge vehicle may exhibit a roof opening panel that is slow to close. This may be caused by dirt or debris in the roof opening panel main and/or idler tracks or an issue with the roof opening panel main track assembly or idler track assembly. Engineering is currently investigating this concern. Continue to monitor oasis for updates.
• 10092562Aug 22, 2016Electrical system, Steering. When hooking up the vehicle communication module (vcm) and integrated diagnostic system (ids) to the dlc located on the driver side under the steering column at the gwm, make sure that the ignition is off before connecting to ids. If the ignition is on or the engine is running during the hook up, it can result in various warning lights being illuminated with diagnostic trouble codes (dtcs), no start or no crank…
• 10091422Jul 15, 2016Engine cooling, Electrical system. Some 2015-2016 edge and 2016 mkx vehicles built on or before 6/11/2016 may exhibit a noise from the electric cooling fans, most noticeable right after the engine is turned off as they spin down to a stop. If the noise can be pinpointed to the cooling fan motor, install a new cooling fan motor and shroud f2gz-8c607-e which was released for service to resolve this concern.
• 10091272Jul 13, 2016Transmission and drivetrain. 2013-2017 fusion/escape/mkz (excluding 3.7l), 2015-2016 edge/explorer (excluding 3.5l/3.7l), 2015-2016 mkc, and 2016 mkx vehicles (excluding 3.7l) equipped with all wheel drive (awd) may exhibit a leaking passenger side power transfer unit (ptu) halfshaft/linkshaft seal. This may be due to a worn ptu bushing. The ptu bushing can now be repaired without ptu replacement.

← All problems reported for the 2015 Ford Edge