2003 Ford Explorer Transmission and drivetrain Problems
- Complaints
- 335about this part
- Share
- 30%of 1,131 total for the year
- Median mileage
- 77,000miles
- Trend
- StableComplaints filed in the last 3 full calendar years are within 25% of the 3 years before.
NHTSA recorded 335 complaints about the transmission and drivetrain of the 2003 Ford Explorer, 30% of the 1,131 complaints for this model year. Where a mileage was given, the median is 77,000 miles. 9 of these say a crash was involved and 1 a fire, according to the filers.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“My 2003 Ford Explorer xls is having issues with the automatic transmission. When I accelerate from a stopped position, the transmission stalls, slips and delays when it shifts into the next gear. As I searched for issues with the transmission I found 100's of complaints regarding this matter. From what I have found, the transmission is a design flaw”
NHTSA complaint #10788981, filed 2015-11, 115,000 miles“We have recurring wheel bearing and hub assembly issue. The timing I put on the form may be off a bit but not much. Its all like a recurring Ford Explorer nightmare at this point! We have replaced bearings, hib assembly, tie rod, then rear end went up ( and shouldn't have)/now again, another bearing and wheel sensor. The truck cuts out when at a slower speed. …”
NHTSA complaint #10786962, filed 2015-10, 180,000 miles“Was leaving gas station, shifted from park to drive, shift lever broke off into my hand. Obviously a defect, as I have over 2 million miles under my belt, driven numerous cars & trucks, and have never had this happen before in over 40 years of driving, both personally and professionally. I see there are hundreds of similar complaints for this, why is there no recall??”
NHTSA complaint #10703385, filed 2015-04, 124,500 miles“Being that I am disabled, I'm affraid that when the transmission finally goes completely out, I'll be straned somewhere or the SUV will cause a wreck and hurt/kill me or someone else. There have been thousands of complaints about the transmission on this Explorer that a recall should have been sent out. I can not affored the repair cost or the cost of another SUV/car, please help!”
NHTSA complaint #10749638, filed 2015-08, 120,000 miles“While driving the o/d light began flashing on my dashboard, the vehicle slowed down to about 15 miles as if the transmission was pulling/slipping, the car made a hard jerk and began to pick-up speed. This cycle repeated until I reached my destination. The light came on again the next day and the same events occurred.”
NHTSA complaint #10525391, filed 2013-07, 117,000 milesRelated service bulletins
- 10028736May 1, 2009Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. Oil separation appears to be and is often misdiagnosed, as an axle…
- 10014100Jan 1, 2006Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers.
- 10012952Jun 7, 2005Driveline 1st order vibration/boom/drone.
- 10014668May 1, 2005Axle seal leaks.
- 10017892Apr 1, 2005Rear axle noise repair.
- 10014659Mar 1, 2005Axle whine howl. This includes 1997-05 ford vehicles.
- 10012959Feb 1, 2005Axle whine howl service with individual parts instead of an axle assembly.
- 10014086Dec 13, 2004General (pcm) power train control module programming procedures.
- 10013398Nov 15, 2004Gear selector lever - increased effort to shift from drive to park.
- 10013121Sep 6, 2004Front axle tube leak.
Transmission and drivetrain: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 3 | 7% |
| 2025 | 16 | 15% |
| 2024 | 1 | 5% |
| 2023 | 12 | 11% |
| 2022 | 61 | 23% |
| 2021 | 127 | 28% |
| 2020 | 502 | 40% |
| 2019 | 35 | 12% |
| 2018 | 50 | 7% |
| 2017 | 125 | 7% |
| 2016 | 215 | 9% |
| 2015 | 86 | 5% |
| 2014 | 80 | 5% |
| 2013 | 119 | 5% |
| 2012 | 55 | 7% |
| 2011 | 64 | 5% |
| 2010 | 28 | 24% |
| 2009 | 3 | 9% |
| 2008 | 36 | 24% |
| 2007 | 57 | 27% |
| 2006 | 296 | 47% |
| 2005 | 99 | 20% |
| 2004 | 460 | 35% |
| 2003 | 335 | 30% |
| 2002 | 1,502 | 46% |
| 2001 | 42 | 11% |
| 2000 | 133 | 14% |
| 1999 | 115 | 9% |
| 1998 | 103 | 5% |
| 1997 | 104 | 6% |
| 1996 | 120 | 8% |
| 1995 | 119 | 14% |
| 1994 | 86 | 7% |
| 1993 | 72 | 8% |
| 1992 | 77 | 12% |
| 1991 | 69 | 11% |
| 1990 | 2 | 17% |
Other parts of the 2003 Ford Explorer
354 complaintsEngine cooling
69 complaintsSuspension
63 complaintsVisibility (wipers, defrost, mirrors)
62 complaintsWheels
56 complaintsElectrical system
54 complaintsAir bags
50 complaintsOther or unknown
48 complaintsBrakes
45 complaintsVehicle speed control
37 complaintsSteering
27 complaintsEngine
22 complaints
← All problems reported for the 2003 Ford Explorer
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology