2023 Ford F-250 SD Technical Service Bulletins

288 technical service bulletins (TSBs) are on record for the 2023 Ford F-250 SD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11024900Oct 29, 2025Transmission and drivetrain. Some 2021-2025 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2026 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping noise upon startup that may remain after the engine is running. This may be due to the starter motor drive gear not retracting after…
• 11024882Oct 28, 2025Electrical system, Steering, Brakes. Some 2023-2025 F-Super Duty vehicles may exhibit a no crank/no start or intermittent no crank/no start with multiple warning indicators and DTC U0100 stored in the anti-lock brake system (ABS), audio front control module (ACM) and power steering control module (PSCM). This may be due to an incorrectly tightened ground 113 (G113). Inspect G113 for proper connection and tighten to 12 Nm (8.9 ft-lb). If the condition…
• 11024523Oct 27, 2025Electrical system, Transmission and drivetrain. Some of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated MIL with DTC P0384 stored in the powertrain control module (PCM). This may be due to the calibration in the PCM. This condition does not affect vehicle drivability or durability.
• 11024532Oct 24, 2025Other or unknown, Body and structure. Some 2018-2025 F-150 and 2018-2026 F-Super Duty vehicles equipped with a tailgate step may exhibit a step assembly that binds/will not open or opens/pops up while driving. This could be due to an incorrect adjustment of the tailgate step assembly. Before replacing any components for this concern, follow the revised Tailgate Step Adjustment procedure in Workshop Manual (WSM), Section 501-04.
• 11024530Oct 21, 2025Electrical system, Fuel system. Some 2021-2025 F-150, 2022-2025 Expedition/Navigator, 2023-2025 F-Super Duty, 2024-2025 Ranger and 2026 Transit vehicles may exhibit a discharged battery and/or a no crank/no start condition. The vehicle may also exhibit a clicking noise from the trailer module (TRM) while the vehicle is off.
• 11024526Oct 21, 2025Lane departure, Electrical system. Some 2020-2025 various Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the…
• 11024524Oct 21, 2025Transmission and drivetrain, Steering. 2023-2026 F-Super Duty vehicles may be equipped from the factory with a power steering system filled with Motorcraft® MERCON® LV Automatic Transmission Fluid XT-10-QLVC or XL-22 high temperature power steering fluid that looks like clear hydraulic fluid. Both fluids are interchangeable in the power steering system when service is required. Workshop Manual, Section 211-02 > Power Steering > Specifications has been…
• 11024021Oct 4, 2025Engine. Some 2021-2025 Expedition/Navigator/F-150/F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis/F-650/F-750/Transit vehicles equipped with a 2.7L,3.5L EcoBoost (non-hybrid), 3.5L Cyclone, 6.8L or 7.3L engine, may exhibit a rattle/scraping noise from the bellhousing area on start-up. Workshop Manual (WSM), Section 303-00 Engine System - General Information > Diagnosis and Testing and 303-06 > Starting System…
• 11024199Oct 1, 2025Body and structure, Other or unknown. Some of the vehicles listed in the Model statement above may exhibit a headliner rattle or sagging condition around the roof opening panel. This may be due to the adhesive separating from the headliner substrate.
• 11023296Sep 17, 2025Transmission and drivetrain. Some of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with cylinder injection pulse offset DTCs P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D, and/or P2B1F stored in the powertrain control module (PCM). The vehicle may also exhibit a slight running rough condition at idle. This may be due to incorrect learned values in the PCM from…
• 11023203Sep 12, 2025Fuel system. Some 2019-2026 F-Super Duty vehicles equipped with a 6.7L engine may require various repairs and/or maintenance to the fuel system where quick release couplings are utilized, such as the secondary fuel filter. The Workshop Manual (WSM), Section 310-00 > General Procedures > Quick Release Coupling has been updated to include videos and instructions of proper disconnect/connect steps involving the Type 27 quick…
• 11022272Aug 27, 2025Electrical system. Some 2023-2025 F-Super Duty vehicles may exhibit a no crank/no start or intermittent no crank/no start with multiple warning indicators and DTC U0100 stored in the anti-lock brake system (ABS), audio front control module (ACM) and power steering control module (PSCM). This may be due to an incorrectly tightened ground 113 (G113). Inspect G113 for proper connection and tighten to 12 Nm (8.9 ft-lb). If the condition…
• 11022271Aug 27, 2025Electrical system. Some 2023-2025 F-Super Duty vehicles may exhibit multiple warning indicators with DTCs U0252, U0137, U0199, U0438 stored in the body control module (BCM), image processing module A (IPMA), power steering control module (PSCM), instrument panel cluster (IPC) and/or inoperative power windows and locks. This may be due to an incorrectly tightened ground 201 (G201). Inspect G201 for proper connection, locating tab…
• 11022152Aug 22, 2025Brakes. Some 2023-2025 F-Super Duty vehicles may exhibit a "Hill Start Assist Unavailable" and/or "Parking Brake Limited Function" message at vehicle start-up with diagnostic trouble codes (DTCs) U0151, U023A, U0159, and/or U0146 stored in the anti-lock brake system (ABS) module. These DTCs and/or U0415 may also be present in various other modules related to "invalid data received from the ABS control module". This may be…
• 11022431Aug 15, 2025Other or unknown, Electrical system. "Quality improvements include: -Prevents Telematics Control Unit memory from going over 70%. Ensuring it has enough space to install the latest Over The Air updates"
• 11021975Aug 14, 2025Other or unknown, Visibility (wipers, defrost, mirrors). Various 2021-2025 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit "Please Check Surroundings For Safety" or "Full View Not Available" messages when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown…
• 11021801Aug 6, 2025Electrical system, Visibility (wipers, defrost, mirrors). Some 2023-2025 F-150 and F-Super Duty vehicles equipped with minor feature code B2DAC may exhibit an inoperative rear passenger window. To confirm a vehicle is built with a certain minor feature code, review the build information by clicking "Additional Information" under Vehicle Information or double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System…
• 11022094Aug 1, 2025Other or unknown, Electrical system, Visibility (wipers, defrost, mirrors). "Quality improvements include: -Addresses rear-view camera image being obstructed by the passcode screen when the vehicle start inhibit is enabled -Customers will be able to finish the Trailer Backup Assist setup without the camera screen showing, interrupting the process -Rear seat occupant center screen alert will show when opening the door and shutting off the engine -Improved audio experience while using…
• 11021358Jul 29, 2025Electrical system. Some 2021-2025 Ford and Lincoln vehicles equipped with SYNC4/Digital Experience may exhibit an unsuccessful telematics control unit module (TCU) software update or software activation during a universal serial bus (USB) update. This may be due to the vehicle connectivity setting being disabled.
• 11020976Jul 25, 2025Engine. Some of the vehicles listed in the Model statement above may exhibit a roaring fan noise from under the hood at highway speeds with either a hot or cold engine. This may be due to a condition where the engine cooling fan clutch remains fully engaged when not commanded.
• 11020894Jul 18, 2025Electrical system, Transmission and drivetrain. This article supersedes TSB 25-2200 to update the parts list to add the new camshaft and tappet service kit and add F-650/F-750. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing rough engine performance, engine misfire, or a malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0301-P0308 in…
• 11020888Jul 15, 2025Steering, Electrical system. Some 2023-2025 F-Super Duty vehicles may display an error during replacement of the SCCM that contains the following message: "Reprogramming has failed, would you like to retry?". If this error is present, the SCCM will not complete PMI and may store diagnostic trouble codes (DTC) U2100 and/or U2101 in the SCCM. This may be due to a concern with the compatibility of the software with a hardware change in the SCCM.
• 11020414Jul 2, 2025Exterior lighting. Some 2021-2025 F-150 non-Lightning, 2023-2025 F-Super Duty, 2024-2025 Ranger, and 2025 Explorer vehicles may exhibit a perceived improper functioning fog lamp(s). Customers may describe fog lamps blinking, turning on or off, or flashing. If the vehicle is equipped with cornering lamps, this may be normal function. Under certain conditions and inputs, either lamp might turn on or off independently to aid visibility…
• 11020080Jun 30, 2025Vehicle speed control, Transmission and drivetrain. Some 2023-2025 F-Super Duty vehicles may exhibit a no crank/no start with diagnostic trouble code (DTC) U0100 in various modules. This condition may be due to the ground connection at G113. Inspect G113 for proper connection and tighten to 12 +/- 1.8 Nm. If condition remains after tightening G113, continue with normal diagnostics. Refer to Workshop Manual, Section 303-06 Starting System.
• 11020044Jun 25, 2025Engine, Transmission and drivetrain. Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco Sport/E-Series/Escape/Corsair/Expedition/Navigator/Explorer/Aviator/F-150/F-Super Duty/Mustang/Ranger, and 2022-2025 Maverick vehicles may require an A/C compressor clutch assembly replacement be performed for various concerns. Workshop Manual (WSM), Section 412-00 Removal and Installation has been updated to eliminate the need to remove and install the A/C…
• 11020042Jun 25, 2025Transmission and drivetrain, Engine. Some 2023-2025 F-Super Duty vehicles equipped with a 6.7L engine may require replacement of the air conditioning compressor due to various concerns. Workshop Manual (WSM), Section 412-00 has been updated with improved removal and installation service procedure steps.
• 11020051Jun 24, 2025Electrical system. Some 2023-2025 F-Super Duty vehicles may exhibit multiple warning indicators with DTCs U0252, U0137, U0199, U0438 stored in the body control module (BCM), image processing module A (IPMA), power steering control module (PSCM), instrument panel cluster (IPC) and/or inoperative power windows and locks. This may be due to an incorrectly tightened ground 201 (G201). Inspect G201 for proper connection, locating tab…
• 11019702Jun 20, 2025Other or unknown, Electrical system. Some 2021-2025 Ford/ Lincoln vehicles equipped with SYNC4 may not be able to perform an update to the accessory protocol interface module (APIM). This may be due to the software in the APIM. Ford Engineering has de-activated the ability to update these SYNC4 APIM modules as applicable, and the Ford Diagnosis and Repair System (FDRS) will not present an update for the APIM module.
• 11019654Jun 12, 2025Transmission and drivetrain. Some 2023-2025 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with cylinder injection pulse offset diagnostic trouble codes (DTCs) P2B11, P2B13, P2B15, P2B17, P2B19, P2B1B, P2B1D, and/or P2B1F stored in the powertrain control module (PCM) when operating at elevations greater than 2500 feet (762 meters).
• 11019650Jun 11, 2025Brakes. Some 2023-2025 F-Super Duty vehicles may exhibit a "Hill Start Assist Unavailable" and/or "Parking Brake Limited Function" message at vehicle start-up with diagnostic trouble codes (DTC) U0151, U023A, U0159, and/or U0146 stored in the anti-lock brake system (ABS) module. These DTCs and/or U0415 may also be present in various other modules related to "invalid data received from the ABS control module". Replacement…
• 11019647Jun 11, 2025Electrical system, Brakes. Some 2023-2025 F-Super Duty vehicles equipped with a trailer brake control module may exhibit a "Trailer Disconnected" message after cycling the ignition off and back on with a trailer connected. This may be due to the presence of an integrated battery charger on a trailer equipped with electric over hydraulic brakes.
• 11019495Jun 6, 2025Transmission and drivetrain. Some 2020-2025 F-Super Duty vehicles equipped with a 10R140 automatic transmission may exhibit a delayed engagement into drive and/or reverse on initial start-up. The condition may occur at times after sitting overnight or for a couple of days. This may be due to the transmission fluid draining back from the torque converter. This is a normal characteristic of the 10R140 transmission and has no effect on…
• 11019263May 19, 2025Visibility (wipers, defrost, mirrors). "Quality improvements include: -Addresses rear-view camera image being obstructed by the passcode screen when the vehicle start inhibit is enabled -Customers will be able to finish the Trailer Backup Assist setup without the camera screen showing, interrupting the process -Rear seat occupant center screen alert will show when opening the door and shutting off the engine"
• 11018524May 19, 2025Transmission and drivetrain, Engine. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing rough engine performance, engine misfire, or a malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0301-P0308 in the powertrain control module (PCM). This may be due to camshaft and/or valve tappet having excess wear within the engine assembly.
• 11018521May 13, 2025Engine, Transmission and drivetrain. Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super Duty/Ranger/Transit/E-Series, 2021-2025 Bronco, and 2022-2025 Maverick vehicles may require an engine cooling system flush to be performed for various concerns. Workshop Manual (WSM), Section 303-03 has been updated to eliminate the need to remove and install the radiator assembly to perform a radiator flush.
• 11018238May 12, 2025Other or unknown. After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occurring between modules and/or a module is not responding.
• 11019259May 10, 2025Other or unknown. Certain 2018-2024 model year various vehicles — update sync software
• 11017971Apr 25, 2025Other or unknown. "Quality improvements include - Headlamps won't turn on during Over the Air updates, reducing battery drain - Enhanced passive entry feature for a better customer experience. This update resets some vehicle settings, causing a Check Engine Light that disappears after a few key cycles."
• 11017163Apr 17, 2025Other or unknown. Some 2020-2023 F-Super Duty vehicles equipped with a 10R140 transmission may exhibit harsh or delayed engagement/shift concerns. Refer to Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing for normal diagnostics. The WSM has been updated with all information from previously published articles related to this concern.
• 11017064Apr 14, 2025Other or unknown. After replacement of any TRON module, the gateway module (GWM) and the TRON capable modules can set diagnostic trouble codes (DTCs) U211A, U211B, U211C, U3034, U3035, U3036, U35D9, U35DA and/or U35DB if the secret authentication security keys are not aligned between the modules, a loss of communication is occuring between modules and/or a module is not responding.
• 11017061Apr 8, 2025Other or unknown. Some 2022-2025 Ford or Lincoln vehicles may exhibit DTCs B142E:78, B1432:78, and/or B1433:54 diagnostic trouble codes (DTCs) in the CCM. This may be due to non-factory sized tires that may cause inaccurate speedometer readings that can impact the functionality of the CCM. When a vehicle is modified in this manner, replacement or realignment of the CCM may impact the normal operation of the system and/or performance…
• 11016916Apr 4, 2025Other or unknown. Some 2023 F-Super Duty vehicles equipped with a 12 inch center display screen and driver assistance package (minor feature code DBCAY) may exhibit the brakes applying without brake pedal input during parking lot type driving below 5 mph (8 km/h).
• 11016915Apr 4, 2025Other or unknown. Some 2021-2025 Ford and Lincoln vehicles may exhibit diagnostic trouble code (DTCs) U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement.
• 11016086Mar 25, 2025Other or unknown. Some 2023-2025 F-Super Duty vehicles may set diagnostic trouble codes (DTCS) U023A:00, U0159:00, and/or U0146:00 in the anti-lock brake system (ABS) module after the vehicle is remote started.
• 11016079Mar 19, 2025Other or unknown. This article supersedes TSB 25-2055 to update the labor time description.
• 11016220Mar 14, 2025Other or unknown. Customer Satisfaction Program 25B04 Certain 2024-2025 Model Year F-250 - F-600 XL & XLT Vehicles with optional Pickup Box Delete (66D) and Pro Power Onboard (43K) Install Pro Power Onboard
• 11015679Mar 14, 2025Other or unknown. Some 2023-2025 F-Super Duty and 2023-2026 F-650/F-750 vehicles may exhibit an illuminated malfunction indicator light (MIL) with diagnostic trouble code (DTC) P0384 stored in the powertrain control module (PCM).
• 11015686Mar 13, 2025Other or unknown. This TSB supersedes article 24-2009 to update the model years affected, Issue, Action, Service Procedure, and labor times associated with the Service Procedure from M-time to AP-time and add a cap.
• 11015685Mar 13, 2025Other or unknown. This article supersedes TSB 24-2566 to update the Issue, Action, Service Procedure, and labor times associated with the Service Procedure from M-time to AP-time and add a cap
• 11015069Feb 25, 2025Other or unknown. "Quality improvements -Better oil life monitoring accuracy -Enhanced display functions in various drive modes -Improves cluster graphics consistency"

← All problems reported for the 2023 Ford F-250 SD