2007 Ford F-450 SD Technical Service Bulletins

48 technical service bulletins (TSBs) are on record for the 2007 Ford F-450 SD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10243490Sep 7, 2023Transmission and drivetrain. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
• 10186678Jan 27, 2021Equipment. Some 2005-2021 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet
• 10178810Jul 8, 2020Electrical system, Other or unknown. These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer…
• 10170992Jan 29, 2020Suspension. Some 2005-2020 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet
• 10171326Jan 13, 2020Equipment. This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
• 10171325Jan 13, 2020Equipment. This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
• 10165713Sep 2, 2019Electrical system. Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the…
• 10160885May 14, 2019Suspension. Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet
• 10095225Jan 27, 2017Equipment. Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit gc3z-54024a38-a includes an instruction sheet.
• 10204983Oct 30, 2015Visibility (wipers, defrost, mirrors). Exterior Mirror - Tubular stainless steel west cpast style mirror - Loose mounting bracket
• 10056196May 1, 2014Transmission and drivetrain. Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward.
• 10055629Feb 1, 2014Transmission and drivetrain, Engine cooling. Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. Model 2003-2007 f super duty, 2004-2010 e series, 2003-2005 excursion.
• 10039053Mar 1, 2011Engine cooling, Electrical system, Transmission and drivetrain, Brakes. Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
• 10026387Oct 23, 2008Engine cooling. Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
• 10027985Sep 1, 2008Engine cooling. Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
• 10024867Apr 1, 2008Transmission and drivetrain. 2005-08 f250-550 super duty manual transmission - clutch pedal concern.
• 10024325Mar 1, 2008Engine cooling. 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08.
• 10021281Dec 1, 2007Fuel system. Water in the fuel tank behind rear axle - 6.0l, 6.4l and 7.3l diesel engine. *kb updated 2/29/08.
• 10023653Nov 1, 2007Transmission and drivetrain. 1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4.
• 10023855Oct 1, 2007Engine cooling. 6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles.
• 10023435Oct 1, 2007Transmission and drivetrain. 2005-2008 f-super duty manual transmission- clutch pedal concern.
• 10022675Sep 19, 2007Brakes. Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10022673Sep 19, 2007Electrical system, Brakes. Stuck or jumping/bouncing/erratic speedometer and/or tachometer.
• 10022293Jul 25, 2007Engine cooling. 6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct.
• 10022283Jul 25, 2007Suspension. Rear of vehicle is too high/low -5th wheel and goose neck applications.
• 10022280Jul 25, 2007Transmission and drivetrain. Buck/jerk when pulling large heavy gooseneck trailers. Diesel engines. Reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue.
• 10022204Jun 26, 2007Brakes. Customer satisfaction program. Vehicles equipped with fixed pedals accelerator pedal inspection. Effective until june 30, 2007. *kb this program is being extended until june 30, 2008. Updated on 09/25/07.
• 10021903Jun 25, 2007Brakes. Abs light on and possible c1175, c1236, p0500,p0503.
• 10021484May 8, 2007Exterior lighting. Adding additional bulbs to turn indicator or hazard flasher circuits.
• 10021978May 1, 2007Engine cooling. Power steering pump pulley alignment.
• 10021464Apr 27, 2007Engine cooling. 6.0l oil seep or boost pressure leak at hot side charge air cooler duct.
• 10021462Apr 27, 2007Engine cooling. Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start.
• 10022243Apr 1, 2007Engine cooling. Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10021236Mar 23, 2007Engine cooling. Lack of cooling fan operation.
• 10021234Mar 23, 2007Engine cooling. 6.0l - mil on with dtc p2138, p2139, and p2140.
• 10021233Mar 23, 2007Engine cooling. Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after initial cold engine start up.
• 10021232Mar 23, 2007Engine cooling. 6.0l turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke, surge, p0238, p0299, p0404, p2262, and/or p2263.
• 10021231Mar 23, 2007Engine cooling. High pressure system diagnostics - 6.0l engines.
• 10021230Mar 23, 2007Steering. Steering wheel oscillation.
• 10021621Feb 1, 2007Fuel system. Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10021619Feb 1, 2007Engine cooling. Air filter water ingestion / snow packing with codes p0103.
• 10021278Feb 1, 2007Engine cooling. 6.0l - reduced engine performance - high altitude.
• 10022236Dec 1, 2006Engine cooling. Misfire and dtc p0300.
• 10022233Dec 1, 2006Engine cooling. Misfire and dtc p0300.
• 10022229Dec 1, 2006Engine cooling. Lack of power or lack of performance condition when operated above 5,000 feet of altitude.
• 10021229Sep 1, 2006Engine cooling. Watch for oil flow from the base engine oil pump. Vehicles equipped with a 6.0l diesel engine.
• 10021235Jun 1, 2006Engine cooling. Runs rough or misfire due to a stuck valve.
• 10021173Jun 1, 2006Engine cooling. Oil flow from the base engine oil pump.

← All problems reported for the 2007 Ford F-450 SD