2007 Ford F-650 SD Problems
- Complaints
- 5filed with NHTSA
- Median mileage
- 36,000miles, 5 complaints with mileage
- Recalls
- 1campaigns on record
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
Sources: NHTSA records for the 2007 Ford F-650 SD (complaints, recalls, investigations). Report an error
NHTSA recorded 5 consumer complaints for the 2007 Ford F-650 SD. The part named most often is electrical system, with 2 complaints (40% of the total), followed by brakes (1) and fuel system (1). 5 of the complaints include a mileage, and 100% of those were filed for vehicles with under 50,000 miles; the median is 36,000 miles. Of all complaints, 1 a fire, according to the filers. NHTSA lists 1 recall campaign and 50 technical service bulletins for this model year. Electrical system complaints overlap with 2 technical service bulletins filed under the same part. Brakes complaints overlap with 4 technical service bulletins filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Electrical system2 40%
- Brakes1 20%
- Fuel system1 20%
Example complaints
Electrical system: “The contact owns a 2007 Ford f-650 superduty. The contact stated that an electrical fire ignited in the battery compartment. The wiring within the ECM melted down which caused the fire. The fire was put out with an extinguisher. The vehicle was towed to an authorized dealership where the dealer called the manufacturer who refused to assist in repair costs. The vehicle was repaired at that time. The current and failure mileages were 19,760.”
NHTSA complaint #10354441, filed 2010-09, 19,760 milesBrakes: “The contact owns a 2007 Ford F-650 SD. While driving 70 MPH, the vehicle failed to accelerate when the accelerator pedal was depressed. In addition, the anti-brake system warning light illuminated. The contact mentioned that smoke fumes were seen coming from all tires. The failure recurred intermittently. The vehicle was taken to the dealer where it was diagnosed, but the cause of the failure was undetermined. The brake calibers and pads were replaced, but the remedy failed. The manufacturer was made aware of the failure. The failure mileage was 2,000.”
NHTSA complaint #10885576, filed 2016-07, 2,000 milesFuel system: “Fuel tank defect. 2007 Ford f650 xlt super duty truck. Vin # it has come to our attention that numerous truck of this description have had replacement of fuel tanks that have a design flaw. We, aa susie's limousine and coach and carriage limousine operate as a livery transportation provider in jacksonville florida. We transport our customers locally, intrastate and interstate as this vehicle was purchased as a bus designed by glaval. This is a concern to us regarding this matter because it is a know fact that there is a flaw in the design or operation of the fuel tanks used on this vehicle. …”
NHTSA complaint #10278387, filed 2009-07, 36,000 milesTransmission and drivetrain: “The contact owns a 2007 Ford f-650. The contact stated that while driving 35 MPH, the axle seized without warning. The contact was able to maintain control of the vehicle. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was not included in campaign id number: 07v238000 (power train:axle assembly). The vehicle was not repaired. The VIN was not available. The failure and the current mileage was 42,300.”
NHTSA complaint #10452992, filed 2012-03, 42,300 milesMileage when problems were reported
100% of the 5 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 19,760 and 38,000 miles.
Complaints by year filed
Fewer than 15 complaints, too few for a reliable trend.
Recalls and investigations
- 07V238000Jun 5, 2007Power train › Axle assemblyCovers: Ford F-650 SD 2007, F-750 SD 2007
On certain trucks built with dana rear axles, the rear axle may have a housing that was built using steel that was thinner than specified.
Recall details for the 2007 Ford F-650 SD → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 50 on record; the latest 10 are shown.
- 10095225Jan 27, 2017Equipment. Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating…
- 10205026Apr 13, 2016Visibility (wipers, defrost, mirrors). Exterior mirror - tubular stainless steel west coast style mirror - loose mounting bracket
- 10183762Apr 13, 2016Visibility (wipers, defrost, mirrors). Some 2006-2015 F-Super Duty 650/750 vehicles equipped with exterior tubular stainless steel west coast style mirrors may have a loose mounting bracket due to poor rivet retention.
- 10204983Oct 30, 2015Visibility (wipers, defrost, mirrors). Exterior Mirror - Tubular stainless steel west cpast style mirror - Loose mounting bracket
- 10056196May 1, 2014Transmission and drivetrain. Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, f-53 motorhome…
- 10055629Feb 1, 2014Engine cooling, Transmission and drivetrain. Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck…
- 10039053Mar 1, 2011Transmission and drivetrain, Electrical system, Engine…. Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
- 10029424Jul 1, 2009Seats. Ford truck: some vehicles may exhibit a loose set back. Follow the service procedure steps to correct the condition.
- 10026387Oct 23, 2008Engine cooling. Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
- 10024325Mar 1, 2008Engine cooling. 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08.
Other model years of the Ford F-650 SD
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2007 | 5 | 36,000 | 1 | — | — | — | Not enough data |
| 2005 | 6 | 60,000 | 2 | — | — | — | Not enough data |
| 2004 | 10 | 9,000 | 2 | — | — | — | Not enough data |
Frequently asked questions
How many NHTSA complaints does the 2007 Ford F-650 SD have?
NHTSA recorded 5 consumer complaints for the 2007 Ford F-650 SD as of Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2007 Ford F-650 SD is reported most often?
Electrical system is named most often, in 2 complaints (40% of the total), followed by brakes with 1.
Has the 2007 Ford F-650 SD been recalled?
NHTSA lists 1 recall campaign for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2007 Ford F-650 SD reported?
Among the 5 complaints that include a mileage, the median is 36,000 miles and the middle half falls between 19,760 and 38,000 miles; 100% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.