2022 Mercedes-Benz S 580 4MATIC Technical Service Bulletins

329 technical service bulletins (TSBs) are on record for the 2022 Mercedes-Benz S 580 4MATIC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10208739Feb 16, 2022Electrical system. Complaint The oil level is not correctly displayed while the instrument cluster display is in workshop mode. The oil level is reported in an inverted fashion when a correction is carried out. I.e. instead of an instruction to refill the oil quantity, an instruction to reduce the oil level is displayed, or vice versa. Cause Previous software release for instrument cluster control unit (N133/1) Remedy Update…
• 10208676Feb 14, 2022Suspension, Brakes. Correct torque of screw connection between hydraulic lines and all suspension struts
• 10208747Feb 10, 2022Equipment, Electrical system. Complaint Customer may have the following complaints: • Mobile device will not connect to the vehicle's WLAN network • No outbound internet access over WiFi • Mobile device bluetooth pairing is not possible • Apple Carplay and Android Auto are inoperable • USB devices are not recognized Cause Current MBUX multimedia system (A26/17) software release Remedy Performing a user data reset via the Central…
• 10208752Feb 3, 2022Seat belts. Complaint The warning message “PRE-SAFE inoperative” shown on IC display. “PRE-SAFE Inoperative” message found in cluster. Quick test shows that either left or right front Emergency Tensioning Retractor (ETRs) are unable to communicate with XENTRY Diagnosis. Instrument cluster confirms communication issues with ETRs. Note: If short or open circuit faults are found (or any other faults related to the ETRs)…
• 10208741Feb 2, 2022Latches, locks and linkages. • The flush-mounted door handle could jam or skip while extending and may move in a jerky manner while doing so. • In the area of the paneling section of the door, paint damage could be present (picture 1) and/or an abrasion point could be present at the door handle (picture 2). Cause The door handle could be installed too low in the y direction and/or the z direction (picture 3). As a result, the door handle…
• 10207203Jan 27, 2022Electrical system. Complaint Adjustment of the outside mirrors using the driver's door switch group may not be possible or it is not possible to select the left or right outside mirror. Cause Possible software update needed to the switch group, "DSM_WM_D223 - S20/1 - Switch group 'power window assembly and outside mirror adjustment, driver's side'." Remedy Update to the latest software version for DSM_WM_D223 - S20/1 - Switch group…
• 10207194Jan 27, 2022Suspension. Complaint Warning display message for eSuspension. Cause Various causes are possible. Remedy A general replacement of eABC components - MPE/EHSE (motor pump unit/electrohydraulic high-pressure pump) or suspension struts is not useful. First check and update AFW control unit N51/8 and the four EHSE pump units M67, M67/1, M67/2 and M67/3 with new software.
• 10207193Jan 27, 2022Equipment, Suspension. Complaint 1. Noises in recovery mode with the vehicle stationary 2. Noises when driving in a straight line on rough terrain 3. Noises when cornering and performing alternate steering movements 4. Non-assignable noises Cause Complaint 1. Noises in recovery mode with the vehicle stationary Complaint 2. Noises when driving in a straight line on rough terrain Cause: These are normal operating noises of the hydraulic…
• 10207188Jan 27, 2022Suspension. Complaint Height adjustment and deactivation of the production or transport mode not possible. Cause The deactivation of the production mode is not stored in the AIRMATIC control unit. The control unit is not operational. Remedy Perform software update of AIRMATIC control unit N51/8.
• 10207184Jan 26, 2022Engine cooling, Equipment. Complaint Check engine light illuminated. Fault code P012800 current or stored in MRG1AMGV8 control unit. Cause Thermostat may not close completely Remedy 1-Perform coolant warmup test via fault P012800 and save the results 2-Drain coolant through fine sieve or filter and check for debris. 3-Remove and replace coolant thermostat. Check for any debris in thermostat or connections on engine. If debris found in step 2…
• 10207199Jan 9, 2022Electrical system. Complaint The range of the integrated garage door opener (GTO) is too short. Cause 1. Vehicles equipped with infrared windows and/or a heated windshield may suffer from complaints involving low transmission power. 2. When comparing the range between the integrated GTO and the garage door hand transmitter, the garage door hand transmitter is tested outside the vehicle. 3. The garage door hand transmitter is being…
• 10207200Jan 8, 2022Electrical system. Complaint In the "single color" setting, it is not possible to select the color for the ambient lighting. If the setting is changed to "multicolored", the color can be changed. Cause Incorrect personalization in driver's side SAM control unit N10/6. Remedy Carry out personalization for driver's side SAM control unit N10/6. Procedure in XENTRY Diagnosis: 1. Select driver's side SAM control unit N10/6 2. Adaptations…
• 10207196Jan 6, 2022Transmission and drivetrain. Complaint The fault code C112502 is logged (as current or stored) in the rear axle control unit (N68/4). Cause The fault code is caused by communication with the ESP control unit: 1. After carrying out a quick test or performing a diagnosis on the ESP control unit (N30/3): This fault code occurs in the ESP control unit (N30/3) as a result of the diagnosis performed with XENTRY Diagnosis. At the point of diagnosis…
• 10207183Jan 4, 2022Equipment, Engine cooling. Complaint Sporadic warning message in instrument cluster "Engine oil pressure stop switch off vehicle" (or similar) is shown in red on vehicles with low mileage. Cause Directional control valve may stick. Remedy 1- Read off oil level in instrument cluster and correct if necessary. 2- Perform approx. 10-15 engine starts, then clear fault codes. 3- Perform road test with vehicle. If fault code reoccurs during road…
• 10206077Dec 8, 2021Engine cooling. "MY15+ M278 and M157 Equipped Vehicles with Fault Code ""P023400 – Boost Pressure is Too High"" "
• 10203888Nov 1, 2021Latches, locks and linkages. "Hands-Free Access non-functional. Key LED flashes multiple times."
• 10203871Nov 1, 2021Latches, locks and linkages. "Instrument Cluster warnings when Driver's door opened"
• 10205803Aug 27, 2021Equipment. The mobile phone address book may not be transferred completely to the multimedia system COMAND, Audio 20, or MBUX. The contact list may not be fully populated and in some instances, the call list will display telephone numbers but no names.
• 10205796Aug 17, 2021Body and structure. Clattering noise when raising lowering window using the front door window
• 10205814Aug 11, 2021Fuel system. Fuel filler flap opens slowly/switch flashes/tank is bleeding instrument cluster warning
• 10205795Aug 11, 2021Body and structure. Flushmounted door handle may be sluggish when retracting.
• 10205802Aug 9, 2021Electrical system. The "Ambient Light Warning Assistance Inoperative" warning message is displayed in the instrument cluster and/or the lightemitting diode strips are not working.
• 10205808Aug 3, 2021Electrical system. The rear entertainment system displays may flicker see attached.
• 10205800Jul 23, 2021Body and structure, Latches, locks and linkages. The flushmounted door handles are retracted and do not extend electrically in response to a command from the door handle sensor in center of door handle is touched see Picture 1, A, so that the door can be opened.
• 10202531Jun 16, 2021Interior lighting. Touch pad: Search lighting does not dim or does not turn on.
• 10205242Nov 29, 2016Equipment. Navigation system permanently displays "Activating".
• 10205241Aug 25, 2016Equipment. Navigation system permanently displays "Activating".
• 10205252Aug 11, 2016Electrical system. High voltage battery warning message in instrument cluster.
• 10205154Aug 5, 2016Engine cooling, Other or unknown. Gasket may settle causing a slight oil leak.

← All problems reported for the 2022 Mercedes-Benz S 580 4MATIC