2023 Mercedes-Benz Sprinter 2500 Technical Service Bulletins

106 technical service bulletins (TSBs) are on record for the 2023 Mercedes-Benz Sprinter 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10232322Feb 13, 2023Engine cooling. Complaint Engine runs irregularly and it shakes. Indicator lamp lights up. Information: Fault codes for injectors and/or combustion misfires may be stored in the CDI control unit: • On engine 642 cylinder 6 is affected. • On engine 651 cylinder 2 is affected. Cause Charge air from the exhaust gas recirculation is condensed after being introduced into the charge air section.
• 10232325Feb 3, 2023Engine cooling. Complaint Check engine warning light active. Fault code P300CA8 or P300CA9 "Hot film mass air flow sensor malfunction" is present in engine control unit.
• 10231020Jan 13, 2023Electrical system. Complaint Various issues including control unit programming procedure will not complete successfully/no newer software found, communication faults, or sporadic malfunction of systems. Cause Aftermarket CAN device could be installed into the vehicle's CAN network. Such devices can be but are not limited to, remote start modules, CAN blockers, or high idle modules.
• 10228818Dec 11, 2022Visibility (wipers, defrost, mirrors). Complaint Various customer concerns of Climate Control system operating inadequately. Cause Stepper motor linkage in the heater case may cause a mechanical fault during actuation during unfavorable environmental conditions. NOTE: If the vehicle is equipped with H13 (rear additional heat exchanger), There is an additional stepper motor in the rear heater case under the vehicle. This stepper motor can influence the…
• 10228812Dec 10, 2022Electrical system. Complaint Distronic and/or Active Brake Assist inoperative after driving for an extended period Cause Blindness detection of the radar sensor. When driving for extended periods in areas with few or no objects for the radar sensor to detect, the radar sensor switches off due to the self-test and sets fault code C174AFB - The adjustment of the 'Active Brake Assist' control unit has malfunctioned. Remedy • Check the…
• 10228609Nov 17, 2022Body and structure. (SC)Replace Front Door Check

← All problems reported for the 2023 Mercedes-Benz Sprinter 2500