2023 Ram 1500 Technical Service Bulletins

548 technical service bulletins (TSBs) are on record for the 2023 Ram 1500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10241146Jun 30, 2023Visibility (wipers, defrost, mirrors). A/C Diagnostic LOP Change (Except Alfa Romeo Vehicles)
• 10241040Jun 30, 2023Engine cooling. Offroad Pages App Does Not Show Coolant Temp Or Oil Pressure
• 10241035Jun 29, 2023Equipment, Other or unknown. Radio Black Screen, Freezing, Reset, Cutting Out Or Inoperative Intermittently
• 10241050Jun 28, 2023Electrical system, Equipment. FCA Caribbean Warranty Bulletin ID-22-11 STAR Center Uconnect 5 (R1) Radio Pre-Authorization Program ? Select Radios (New and Exchange) ?2023 Jeep Grand Cherokee (WL), 2023 Wagoneer and Grand Wagoneer (WS), 2023 Ram 1500 Pickup (DT), 2023 Ram Heavy Duty Pickup (DD/DF/DJ/ DP/D2), 2024 Jeep Wrangler (JL) and 2024 Jeep Gladiator (JT) (Rev. B)
• 10241049Jun 28, 2023Electrical system, Equipment. Warranty Bulletin D-20-13 STAR Center Uconnect 5 (R1) Radio Pre-Authorization Program ? Select Radios (New and Exchange) ?2023 Jeep Grand Cherokee (WL), 2023 Wagoneer and Grand Wagoneer (WS), 2023 Ram 1500 Pickup (DT), 2023 Ram Heavy Duty Pickup (DD/DF/DJ/DP/D2), 2024 Jeep Wrangler (JL) and 2024 Jeep Gladiator (JT) (Rev. F)
• 10241148Jun 23, 2023Visibility (wipers, defrost, mirrors), Electrical system. Power wndow switch passenger
• 10241111Jun 21, 2023Electrical system. Telematics Box Module (TBM) Over The Air Software Update to 5.39.1 Customers may experience one or more of the following: ? Uconnect Box Message at Startup. ? Uconnect Box Error Or Requires Service Message. ? Connectivity: Uconnect Mobile App trunk status showing as closed when trunk is open. ? Connectivity: Diagnostic Trouble Codes (DTCs) for Electronic Control Modules (ECUs) won?t be shown to customer through the…
• 10241058Jun 21, 2023Electrical system, Equipment. Customer Satisfaction Notification 70A - Radio Date/Time Update
• 10241026Jun 21, 2023Body and structure, Other or unknown. Power Side Steps Reverse, Stop In Motion, And/Or Do Not Deploy Or Stow
• 10240991Jun 1, 2023Body and structure. Stamping Mark On Under Hood Reinforcement.
• 10240040May 26, 2023Body and structure. rear door high closing effort.
• 10240035May 21, 2023Engine cooling. MIL lamp-on. Engine noise, rattle. Misfire or rough running.
• 10240004May 18, 2023Equipment. SOS, Assistance Calls Not Successful After Radio Replacement or Radio Software Update
• 10240000May 18, 2023Equipment. B2768-49 Right Impact Pressure Sensor-Internal Failure, prior to replacement of any components please contact FCA Redacted Content for further assistance. If no response in 15 minutes, proceed with repair.
• 10239957May 18, 2023Engine cooling. Water Quality When Mixed With Engine Coolant
• 10239951May 17, 2023Engine cooling. Engine Ticking Noise Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTC)s present. This bulletin involves inspecting and if needed, replacing the intake HLAs. NOTE: **ALL VEHICLES ON THE RSU VIN LIST REQUIRE ALL 12 INTAKE HYDRAULIC LASH ADJUSTERS TO BE REPLACED**.
• 10239859May 16, 2023Back-over prevention (rear camera), Wheels. SENSOR, Wheel Speed When replacing a front wheel speed sensor, hold the convolute towards the sensor head and add a zip tie over the convolute to secure it with the sensor pigtail wire to prevent movement. This will protect the wire from the brake splash shield.
• 10240030May 12, 2023Engine cooling. Clunk Noise From Front End Driving Between 15 And 35 MPH And When Decelerating. C0604- Active Air Dam Control Performance
• 10240026May 8, 2023Transmission and drivetrain. Service 4WD Message, Front Axle Disconnect (FAD) Diagnostic Trouble Codes (DTCs) Set.
• 10240003May 3, 2023Equipment. Radio Display Screen Blank Or Screen Cuts In And Out
• 10239855May 2, 2023Engine cooling. PSU right intake camshaft Case 1) If you are to flash the PSU (Pentastar Upgrade Engine) PCM due to P0300 code presence, only AB or previous LEVEL PSU right intake camshaft PN 05047913AA or AB (old version) should be replaced. If the engine is equipped with the AC/AD LEVEL PSU right intake camshaft PN 05047913AC or AD (new version), camshaft should NOT be replaced.
• 10239854May 2, 2023Back-over prevention (rear camera). ROCKER ARM ASSY - ROLLER ROCKER Case 1.- Before replacing the intake or exhaust rocker arms due to an abnormal ticking noise, please check that the INTAKE Hydraulic Lash Adjusters are not "collapsed". If a collapsed INTAKE HLA is found, replace all INTAKE HLAs on the suspect cylinder head (no need to replace rocker arms). The noise can occur at low or high RPMs, and at low or high temperatures. There are no…
• 10236877Apr 26, 2023Electrical system, Transmission and drivetrain. Malfunction Indicator Lamp (MIL) Illuminated. Diagnostic Trouble Code (DTC) P2047 ? Reductant Injector 1/1 Circuit, Set.
• 10236969Apr 25, 2023Visibility (wipers, defrost, mirrors). Mirror
• 10236950Apr 25, 2023Engine cooling. Engine Ticking Noise Engine makes an abnormal ticking noise. There may be Diagnostic Trouble Codes (DTC)s present. This bulletin involves inspecting and if needed, replacing the intake HLAs.
• 10236806Apr 25, 2023Visibility (wipers, defrost, mirrors). Duct Assy Charge Air Cooler In If the seal is missing from inside a Henn connector, please search for the missing seal. It could have been pulled out while removal of the hose from the spigot if it was partially stuck to the spigot. It could have been blown into the hose or CAC. If that is the only concern with the CAC Hose Assembly, then replace the seal with a new replacement seal instead of replacing the entire…
• 10236805Apr 25, 2023Electrical system. Parking Assist For any of the following concerns: (PARK SENSOR or Park Assist or Park Sense or PARKING SENSOR) WARNING (PARK SENSOR or Park Assist or Park Sense or PARKING SENSOR) INOP (PARK SENSOR or Park Assist or Park Sense or PARKING SENSOR) SERVICE (PARK SENSOR or Park Assist or Park Sense or PARKING SENSOR) DOES NOT OPERATE PROPERLY Please contact FCA Redacted Content prior to part replacement. If no response…
• 10236873Apr 22, 2023Electrical system. Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC) P0070-15 Ambient Air Temperature Sensor Circuit-Circuit Short to Battery or Open, P0073 Ambient Air Temperature Sensor Circuit High
• 10236871Apr 20, 2023Electrical system. Ambient Temperature Sensor Servicing.
• 10236804Apr 20, 2023Equipment. 3.5 INCH - SPEAKER ASSY P2 Before ordering a speaker part for crackles or rattling noises make sure to take the following steps: 1. Check for electrical harness routing too close to speaker's rear moving parts, improper connection, and/or harness pinch or damage. 2. Ensure no loose components, including trim grilles, fasteners, surrounding IP parts, etc. were found when removing the speaker. 3. Try "bad" speaker at…
• 10236940Apr 19, 2023Transmission and drivetrain, Electrical system. Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set: ? U0402-00 - IMPLAUSIBLE DATA RECEIVED FROM TCM. When U0402-00 sets in the PCM, the module will start to deny torque requests from Transmission Control Module (TCM), the transmission will…
• 10236895Apr 19, 2023Electrical system. Customer Satisfaction Notification 48A 12-Volt Battery Discharge
• 10236933Apr 15, 2023Engine cooling, Equipment. wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
• 10236866Apr 15, 2023Seats. Heated Seat Cushion Element Inoperative
• 10236910Apr 13, 2023Electrical system, Transmission and drivetrain. Flash: Electronic Shift Module (ESM) Updates The customer may also experience one or more of the following: ? Instrument cluster remains illuminated when vehicle is off. ? Discharged/dead battery. The technician may also find the following: ? Diagnostic Trouble Codes (DTCs) may or may not be stored in Transmission Control Module (TCM) or the ESM. This bulletin involves reprogramming the ESM with the latest…
• 10236863Apr 13, 2023Visibility (wipers, defrost, mirrors). Customer Indicates Low Air Flow Coming From Rear Vents.
• 10236857Apr 7, 2023Electrical system. Uconnect Box Error Message With Active Or Stored Diagnostic Trouble Codes (DTC) B22A9-96, B1570-93, B1E21-96
• 10236967Apr 5, 2023Equipment. Fca caribbean warranty operations newsletter
• 10236903Apr 4, 2023Equipment, Electrical system. Radio Over The Air Uconnect R1L Radio Software Update to R160 Customers may experience one or more of the following: ? Media source changes to AM after the theme mode is changed (ex. headlights on - dark mode). ? Audio cuts out at volume levels 30 or above. ? System switches to Wireless after key cycle, profile change, or theme mode change. ? Wireless phone interface freezes after user accepts incoming call when in…
• 10236799Apr 4, 2023Visibility (wipers, defrost, mirrors), Electrical system. Power Window 1 Gang Before Replacing the Switch, please verify the following: 1- Check the switch internal resistance to verify the values are within specification stated in the service procedures. 2- Swap the switch with the issue with the other side. This switch is used in both rear doors. If after the swap the issue is now present at the other door and the original door position no longer has the issue, replace…
• 10247967Feb 28, 2023Exterior lighting, Back-over prevention (rear camera). Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set.
• 10247966Feb 28, 2023Engine cooling. No Start, No Crank, Diagnostic Trouble Codes (DTC) P2504 Charging System Output High
• 10234440Feb 28, 2023Back-over prevention (rear camera), Exterior lighting. Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set.
• 10234439Feb 28, 2023Electrical system, Engine. No Start, No Crank, Diagnostic Trouble Codes (DTC) P2504 Charging System Output High
• 10248045Feb 25, 2023Exterior lighting. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . This bulletin is to communicate the procedure for head lamp condensation clearing.
• 10234518Feb 25, 2023Exterior lighting. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . This bulletin is to communicate the procedure for head lamp condensation clearing.
• 10247906Feb 22, 2023Engine cooling. ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use…
• 10234379Feb 22, 2023Engine cooling. ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use…
• 10248027Feb 18, 2023Air bags, Steering, Transmission and drivetrain, Brakes, Suspension…. Incorrect Audio Configuration The customer may describe the following: ? Menu button on steering wheel control will activate Voice Recognition on the Head Unit (129 Cluster Vehicles Only). ? Suspension menu tile will be missing from vehicle settings list. ? Power side-step setting is missing from ?Safety & Driver Assistance? list. This bulletin involves performing a wiTECH routine.
• 10234500Feb 18, 2023Transmission and drivetrain, Suspension, Air bags, Brakes, Steering…. Incorrect Audio Configuration The customer may describe the following: ? Menu button on steering wheel control will activate Voice Recognition on the Head Unit (129 Cluster Vehicles Only). ? Suspension menu tile will be missing from vehicle settings list. ? Power side-step setting is missing from ?Safety & Driver Assistance? list. This bulletin involves performing a wiTECH routine.

← All problems reported for the 2023 Ram 1500