2024 Ram 3500 Technical Service Bulletins

302 technical service bulletins (TSBs) are on record for the 2024 Ram 3500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11005229Jul 25, 2024Electrical system. Driver Hears Noise, Static or Can Not Hear Phone Caller on Other End
• 11005320Jul 24, 2024Body and structure. "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market.
• 11005319Jul 24, 2024Engine, Other or unknown. "Heavy Duty Exhaust Gas Recirculation (EGR) Valve Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P1404 - EGR Position Sensor Rationality Closed This bulletin involves replacing the EGR valve."
• 11005228Jul 24, 2024Transmission and drivetrain. TRANSFER CASE BW 44-46 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal - service part numbers 68161329AA OR 68449218AA (max tow application) - should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary
• 11004995Jul 20, 2024Electrical system. Satellite Radio Displays “Satellite Hardware Error” Message
• 11004948Jul 18, 2024Engine. Perceived Oil Leak From The Rear Of The Engine
• 11004151Jul 10, 2024Electrical system. Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start
• 11003786Jul 2, 2024Steering, Electrical system. MODULE Steering Control Before replacing the steering column control module (SCCM), please follow these steps: 1.- Make sure all the switches' and airbag's harness are properly connected, disconnect the switches and reconnect them, and reverify the issue. 2.- Pull the SCCM fuse for 60 sec and then reinstall it. 3.- Reverify if Steering wheel switches are inoperative. If there are no DTC's, physical defects, nor…
• 11002804Jun 29, 2024Transmission and drivetrain. "Rear Axle Vibration Shudder Or Chatter Customers may experience the following: ● A chatter, shudder, or vibration from the rear axle during turns. NOTE: This may happen more as the vehicle ages, especially if the vehicle is used extensively for towing or hauling heavy loads. The cause of the concern may be due to degradation of the rear axle fluid.
• 11002531Jun 28, 2024Electrical system. Drained Battery, Low System Voltage, Battery Not Charging, High System Voltage
• 11002753Jun 26, 2024Visibility (wipers, defrost, mirrors). Motor - windshield wiper & wiperunit - windshield wiper
• 11002316Jun 26, 2024Visibility (wipers, defrost, mirrors). Motor - windshield wiper & wiperunit - windshield wiper
• 11002828Jun 25, 2024Engine, Electrical system. "Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
• 11002424Jun 20, 2024Visibility (wipers, defrost, mirrors). Wiperunit - windshield wiper, blade - front wiper
• 11002315Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper
• 11002314Jun 20, 2024Body and structure. Wiperunit - windshield wiper, blade - front wiper.
• 11002024Jun 18, 2024Electrical system, Exterior lighting. Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative
• 11001758Jun 17, 2024Brakes. Module - anti-lock brake system
• 11001756Jun 15, 2024Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)
• 11001767Jun 14, 2024Steering, Brakes. "Leaking Power Steering Fluid from the Power Brake Hydro-Booster Assembly Customers may experience the following: ● Leaking power steering fluid from the hydroboost assembly. This bulletin involves inspecting and possibly replacing the power brake hydro-booster assembly if a leak is found."
• 11001759Jun 5, 2024Brakes. Module - anti-lock brake system
• 11000611May 30, 2024Electrical system. Module - telematics
• 11000608May 30, 2024Engine. Valve - EGR
• 11001020May 28, 2024Other or unknown, Engine. On Board Diagnosis (OBD) Monitor Readiness Information
• 11001018May 28, 2024Electrical system, Engine. Malfunction Indicator Lamp (MIL) Illumination. One Or More Exhaust Temperature Sensor (EGT) Diagnostic Trouble Codes (DTCs), Set.
• 11000600May 22, 2024Electrical system, Engine. Module - engine controller
• 11000824May 21, 2024Engine. "GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c.
• 11000992May 16, 2024Electrical system. Checking Radio Software Level On A VP2 Radio
• 11000174May 9, 2024Body and structure. DAMPER - STRUT
• 11000170May 7, 2024Steering. Module - steering control
• 11000866May 3, 2024Electrical system. Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed
• 10251770Jan 30, 2024Equipment. UCONNECT 5 W 8.4" DISPLAY Prior to replacing the radio, please check for any related recalls, TSBs, or any STAR Online publications. Please verify the radio is at the latest available software level. If active DTCs are set, perform the appropriate diagnostic procedure in service information. If the condition is intermittent, refer to Section 29 Non-DTC Based Diagnostics and perform the diagnostic procedure related…
• 10251794Jan 25, 2024Visibility (wipers, defrost, mirrors). Rain Sensing Auto Wipers Or Auto Headlamps Inoperative, DTC B221D-00, B23AA-00
• 10251783Jan 10, 2024Electrical system. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
• 10248903Nov 30, 2023Equipment. Radio Navigation Displays Message ?No Maps Available?
• 10248847Nov 20, 2023Suspension. AIR SUSPENSION COMPRESSOR ASSE When servicing a 23 model year Ram 2500/3500 - Service Air Suspension Light On (DTC C2202-00)~ Prior to replacing for a C2202-00 (Original VIN mismatch) contact engineer FCA REDACTED CONTENT~ If no response in 15 minutes proceed with repair.~ ~ Please replace the ASCM for this DTC and do not reset the module. Hold it for parts return~
• 10248912Nov 15, 2023Equipment. Transportation Bulletin T-23-01 Dealer Cleaning Program - 2023 - 2024 RAM Trucks - DJ, D2, DF, DD, DP, DS Models (Mexico RAM Built Trucks Only)
• 10248909Nov 15, 2023Equipment. FCA Caribbean Transportation Bulletin IT-23-01 Dealer Cleaning Program - 2023 - 2024 RAM Trucks - DJ, D2, DF, DD, DP, DS Models (Mexico RAM Built Trucks Only)
• 10248841Nov 6, 2023Brakes. brake hydroboost When replacing the Hydrobooster Assembly for a warrantable concern, please save the removed unit and call FCA REDACTED CONTENT for a FasTrack part return. ~ If no response in 15 minutes, proceed with repair. Please leave the last 8 of VIN, plus vehicle mileage, and dealer code.
• 10247463Oct 18, 2023Electrical system. FCA Caribbean Warranty Bulletin ID-22-10 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 - 2024 Ram 2500 Pickup (DJ), 2022 - 2024 Ram 3500 Pickup (D2), 2022 - 2024 Ram 3500 Cab Chassis (DD) and 2022 - 2024 4500/5500 Ram Cab Chassis (DP) (Rev. C)
• 10247462Oct 18, 2023Electrical system. Warranty Bulletin D-22-07 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 - 2024 Ram 2500 Pickup (DJ), 2022 - 2024 Ram 3500 Pickup (D2), 2022 - 2024 Ram 3500 Cab Chassis (DD) and 2022 - 2024 4500/5500 Ram Cab Chassis (DP) (Rev. C)
• 10244356Sep 20, 2023Suspension. LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
• 10248570Sep 19, 2023Seats. 2nd Row Center Seat Lazy Or Slow When Folding.
• 10248509Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10244348Sep 15, 2023Electrical system. Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10243209Aug 30, 2023Equipment. FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
• 10243208Aug 30, 2023Equipment. Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
• 10243271Aug 24, 2023Visibility (wipers, defrost, mirrors). A/C Diagnostic LOP Change
• 10241146Jun 30, 2023Visibility (wipers, defrost, mirrors). A/C Diagnostic LOP Change (Except Alfa Romeo Vehicles)
• 10239957May 18, 2023Engine cooling. Water Quality When Mixed With Engine Coolant

← All problems reported for the 2024 Ram 3500