2004 Toyota RAV4 Electrical system Problems
- Complaints
- 10about this part
- Share
- 6%of 154 total for the year
- Median mileage
- 91,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 10 complaints about the electrical system of the 2004 Toyota RAV4, 6% of the 154 complaints for this model year. Where a mileage was given, the median is 91,000 miles. 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“My cars check engine and vsc trac lights came on at the same time when I started the car. I then put it in drive and pressed on the gas pedal and nothing happened, but sometimes the car suddenly accelerates. My husband had to drive my car and I had to follow him home b/c the car was so unpredictable. He would have to push down hard on the gas pedal and it would hesitate but then all of a sudden it would then jerk forward. He was terrified that he would get stuck in the middle of an intersection! …”
NHTSA complaint #10561694, filed 2014-01, 115,000 miles“When my car ignition key is in the accessory position the fm channels of my radio are clear. When I put the key in the on position the fm channels cannot be heard over the static.”
NHTSA complaint #10126040, filed 2005-06, 20,000 miles“The TRAC system which brakes the car when it senses the wheel loosing traction hits the breaks on curves, even when turned off. It is random. It is not part of the inspection. When the streets are rain slick it has caused my car to skid out of the lane I was in. It has not been reproduced by anyone as I have not turned the car in to an independent dealer or mechanic. This vehicle has not been inspected by manufacturer, police, insurance representatives or others. The TRAC light comes on and beeps when the car breaks.”
NHTSA complaint #11490185, filed 2022-10“My 2004 Toyota rav 4 caught fire in minutes while I was driving to work. It was only one year old, I had oil and filter changes done on schedule by Toyota and the vehivle was in excellent condition. I smelled something while I was driving and within a couple of minutes my car was filled with smoke and went up in flames.”
NHTSA complaint #10114166, filed 2005-03“I purchased the 2004 RAV4 the last week of november 2003. - after my 1st initial oil change, I noticed after getting my car back from the service department that all of my panel lights were on. I.e., tire gauge, vcs, trac off, maint req., & check engine light.. I took my car back to the dealership the day after hoping it would just turn off during the day & they said that I needed to reset my car. Like I'm suppose to know this & why does my car have to be reset if its brand new? …”
NHTSA complaint #10083067, filed 2004-07Related service bulletins
- 10238157May 30, 2023TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered…
- 10164330Jul 1, 2019TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections…
- 10133654Nov 22, 2017TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be…
- 10152205Jan 6, 2017TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles…
- 10132930Nov 29, 2016TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.
- 10150418Sep 14, 2016TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are…
- 10134140Jan 11, 2016Tech Tip: Some customers may experience difficulty programming HomeLink.
- 10134223Sep 15, 2015TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.
- 10132529Aug 24, 2015TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been…
- 10111323Jun 16, 2015TI: The subject vehicles are equipped with an oxygen sensor with an attached wire harness. Due to the oxygen sensor wire harness routing and engine vibration, the harness may…
Electrical system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 16 | 18% |
| 2024 | 32 | 18% |
| 2023 | 43 | 26% |
| 2022 | 40 | 27% |
| 2021 | 47 | 12% |
| 2020 | 119 | 19% |
| 2019 | 103 | 12% |
| 2018 | 130 | 39% |
| 2017 | 108 | 35% |
| 2016 | 59 | 25% |
| 2015 | 85 | 28% |
| 2014 | 69 | 35% |
| 2013 | 75 | 29% |
| 2012 | 30 | 12% |
| 2011 | 19 | 7% |
| 2010 | 15 | 4% |
| 2009 | 19 | 6% |
| 2008 | 27 | 5% |
| 2007 | 76 | 8% |
| 2006 | 42 | 6% |
| 2005 | 6 | 4% |
| 2004 | 10 | 6% |
| 2003 | 42 | 13% |
| 2002 | 92 | 17% |
| 2001 | 60 | 19% |
| 2000 | 1 | 3% |
| 1999 | 6 | 10% |
| 1998 | 3 | 4% |
| 1997 | 3 | 6% |
| 1996 | 2 | 4% |
Other parts of the 2004 Toyota RAV4
47 complaintsTransmission and drivetrain
23 complaintsVehicle speed control
20 complaintsEngine cooling
18 complaintsEngine
11 complaintsVisibility (wipers, defrost, mirrors)
11 complaintsOther or unknown
9 complaintsBrakes
8 complaintsElectronic stability control
7 complaintsBody and structure
4 complaintsSuspension
3 complaintsTires
3 complaints
← All problems reported for the 2004 Toyota RAV4
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology