2023 Toyota RAV4 Suspension Problems

“Happened at ~644pm on 04/08/24- I heard the noise like a thump or thunk, The car initially pulled towards the roadside, then I corrected the wheel and slowly stopped the car. Upon exiting the car, it became apparent that the ball joint broke just above the plate that attaches to the axle.”

“After routine service at South Coast Toyota in Costa Mesa, CA, I unknowingly drove my 2023 Toyota RAV4 Hybrid for over a week with two missing lug nuts and one extremely loose lug nut on the front passenger wheel. The service performed on April 5, 2025, included an oil change, tire rotation, and full inspection. No issues were reported to me at pickup. Over the next several days, I heard increasing thumping and metallic noises from the front right wheel area, especially at highway speeds. …”

“At estimated 25500 miles in the vehicle, I started to feel vibration at 65- 75 mph. Bouncy ride and slight bad bearing noise at 45 mph . After taking to the dealer, they also felt vibration and recommended tire balancing. After having that done, the problem still existed. I took the car next day and at first they where not willing to check my car but then when I forced, they test drove and confirmed light road noise and light vibration. After a little checking, they said the tires are feathering and should get new tires and or alignment. …”

“Had safety inspection done when having oil changed on 3/5/26. was informed by dealer that it needed both outer tie rod ends replaced has play in it. this came to a cost of $735.00 with alignment. Of course not covered by vehicle warranty which is useless at this point. I have never had this problem on any vehicles I have owned since starting to drive in 1975. This is a safety and quality issue and I should be reimbursed. I will seriously think about about an American owned company in the future. Having Friend at another dealership TCO 3/18/26 I was away last week and SUV parked in garage.”

“The contact owns a 2023 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the vehicle was swaying back and forth. There was no warning light illuminated. The contact stated that the vehicle became inoperable and failed to properly switch lanes. The vehicle was taken to the dealer, where it was diagnosed and determined that the front and rear wheel alignment had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer, but was not diagnosed or repaired. …”