2004 Chevrolet Colorado Engine Problems
- Complaints
- 7about this part
- Share
- 2%of 361 total for the year
- Median mileage
- 93,500miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 7 complaints about the engine of the 2004 Chevrolet Colorado, 2% of the 361 complaints for this model year. Where a mileage was given, the median is 93,500 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“With the revelation of the GM ignition recall problem, there are much more ignition problems that were not included in the recall. The problem is in the ignition cylinder and alignment with the passlock or passkey sensor. My problem started shortly after the vehicle went out of warranty and I was told by the dealer that it was a $1000.00 repair. I can not afford $1000. So I have lived with it. …”
NHTSA complaint #10568922, filed 2014-03, 34,000 miles“Everyday now when I try to start the truck it turns over but will not start, wait 15 minutes then it will start. Today when I tried it the first time it turned over but would not start so when I turned it off at the key it stopped then tried to start again on its own for about 8 to 10 secs. The starter turned the engine over without touching the ignition switch it then stopped for about 3 or 4 secs then tried to start on its own again without touching the key, it did this start sequence 3 times in a row. …”
NHTSA complaint #10700963, filed 2015-03, 85,000 miles“Idle control via electronic throttle body raises RPM very high when the accelerator pedal is not depressed, causing uncontrolled acceleration of vehicle during coasting or when brake pedal is applied. Turning the vehicle off with the key is the only action that has resulted in a cessation of extremely high idle. After restarting the vehicle, the symptom is gone and the vehicle operates normally. This behavior is erratic and inconsistent, the problem has been difficult to duplicate during diagnosis. …”
NHTSA complaint #11030226, filed 2017-09, 182,500 miles“The contact owns a 2004 Chevrolet Colorado. The contact stated that the catalytic converter weld became fractured and separated. The failure recurred on multiple occasions. The vehicle was taken to the dealer where the technician diagnosed the exhaust manifold and catalytic converter needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 102,000 and the current mileage was 182,000. Ma 10/25/15”
NHTSA complaint #10576803, filed 2014-04, 102,000 miles“2004 Chevrolet Colorado. Consumer writes in regards to engine and ignition switch problems. The consumer stated on april 12, 2014, the vehicle shut off while driving 30 MPH. The brake pedal was hard to push and the dashboard read reduced power. After waiting three minutes, the consumer was able to re-start the vehicle. The vehicle stalled again, after driving two miles. According to the service invoice, the PCM computer was bad.”
NHTSA complaint #10609385, filed 2014-07Related service bulletins
- 11004761Jun 28, 2024This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or…
- 10242298Aug 10, 2023This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308…
- 10211658May 2, 2022This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
- 10178387Jul 27, 2020This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller…
- 10176326May 21, 2020This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308…
- 10176607May 8, 2020This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank…
- 10167437Oct 14, 2019This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the…
- 10160987May 7, 2019This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the…
- 10160983May 6, 2019This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller…
- 10149048Oct 26, 2018This Prelimary Information communicates to the dealer a condition where the engine idle RPM is too low causing an idle vibration concern. Dealers are instructed to reprogram the…
Engine: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 3 | 17% |
| 2025 | 3 | 11% |
| 2024 | 21 | 17% |
| 2023 | 21 | 15% |
| 2022 | 6 | 11% |
| 2021 | 19 | 24% |
| 2020 | 20 | 23% |
| 2019 | 20 | 13% |
| 2018 | 24 | 13% |
| 2017 | 26 | 12% |
| 2016 | 48 | 7% |
| 2015 | 34 | 7% |
| 2012 | 8 | 19% |
| 2011 | 3 | 7% |
| 2010 | 5 | 17% |
| 2009 | 10 | 15% |
| 2008 | 8 | 10% |
| 2007 | 18 | 13% |
| 2006 | 19 | 8% |
| 2005 | 7 | 2% |
| 2004 | 7 | 2% |
Other parts of the 2004 Chevrolet Colorado
88 complaintsBody and structure
61 complaintsBrakes
52 complaintsExterior lighting
43 complaintsSuspension
35 complaintsAir bags
29 complaintsTransmission and drivetrain
27 complaintsVisibility (wipers, defrost, mirrors)
26 complaintsOther or unknown
25 complaintsEngine cooling
23 complaintsTires
18 complaintsLatches, locks and linkages
15 complaints
← All problems reported for the 2004 Chevrolet Colorado
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology