Skip to content
Chevrolet Express 2500Model year report

2003 Chevrolet Express 2500 Problems

Complaints
12filed with NHTSA
Median mileage
74,162miles, 10 complaints with mileage
Recalls
0campaigns on record
Trend
Not enough dataFewer than 15 complaints, too few for a reliable trend.

Sources: NHTSA records for the 2003 Chevrolet Express 2500 (complaints, recalls, investigations). Report an error

NHTSA recorded 12 consumer complaints for the 2003 Chevrolet Express 2500. The part named most often is brakes, with 5 complaints (42% of the total), followed by fuel system (3) and other or unknown (2). 10 of the complaints include a mileage, and 30% of those were filed for vehicles with under 50,000 miles; the median is 74,162 miles. NHTSA lists 0 recall campaigns and 90 technical service bulletins for this model year. Brakes complaints overlap with 1 technical service bulletin filed under the same part. Fuel system complaints overlap with 2 technical service bulletins filed under the same part.

This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.

Which parts are reported most

Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.

Example complaints

Brakes: “I was traveling on the highway at the speed of 50 MPH and the van suddenly began to violently shake and shudder from the front wheels and up and including the shake of the steering wheel. I slowed the vehicle down by braking to 35 MPH and it slowly stopped shaking. This has become a regular issue with the vehicle and I have taken it from shop to shop and mechanics cannot figure out the problem. I fear for my family's safety as well as my own when driving alone in this vehicle. It has been a year since this has begun. …”

NHTSA complaint #10660170, filed 2014-11, 36,000 miles

Fuel system: “Filling up the van, notice that gasoline was leaking from the fuel filler tube. Investigation concluded that the plastic corrigated wrap that chevy placed on the tube, traps water, salt, dirt, ect... In it, allowing the pipe to rust, without the driver/owner noticing the damage until it starts leaking. As a firefighter, I realize the dangers of gasoline leaking under a vehicle, I feel that this is a serious design flaw for the filler tube.”

NHTSA complaint #10411911, filed 2011-07, 140,000 miles

Other or unknown: “I have a 2003 Chevrolet express van 2500 that the paint just started falling off in large flakes on the rear and side doors, and the front hood. I have tried touch up paint to try and stop the peeling, but it has not helped.when I wash the vehicle or it rains makes the problem worsen by filling up pockets behind the paint. This is a my company van which has decal lettering on it. The flaking is starting to get to the lettering. If it continues, I will loose approx. $800.00 to a $1000.00 in decal lettering plus the van looks terrible for a company van. The color of the van is white. …”

NHTSA complaint #10443849, filed 2012-01, 96,000 miles

Mileage when problems were reported

30% of the 10 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 49,000 and 120,000 miles.

0%0–100%10–2530%25–5020%50–7520%75–10020%100–15010%150+
Share of complaints by mileage when the problem was reported, in thousands of miles (10 complaints with mileage). Red bars: under 50,000 miles. Bucket widths differ. Median: 74,162 miles.

Complaints by year filed

Fewer than 15 complaints, too few for a reliable trend.

200620074200920102011201220142016
Complaints by year the complaint was filed with NHTSA. Red bars: the last 3 full calendar years used for the trend. The current year (2026) is partial.

Recalls and investigations

NHTSA lists no recall campaigns for the 2003 Chevrolet Express 2500 in the data used here. A recall can apply to some vehicles of a model year and not others, so check a specific vehicle by VIN at nhtsa.gov/recalls.

Technical service bulletins

TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 90 on record; the latest 10 are shown.

See all 90 bulletins →

Other model years of the Chevrolet Express 2500

YearComplaintsMedian miRecallsCrash ★MPGScore (50 = typical)Trend
2010746,5000———Not enough data
2008742,1500———Not enough data
2007777,2260———Not enough data
20061356,5650———Not enough data
2005950,2240———Not enough data
2004864,7501———Not enough data
20031274,1620———Not enough data

All Chevrolet Express 2500 model years

Frequently asked questions

How many NHTSA complaints does the 2003 Chevrolet Express 2500 have?

NHTSA recorded 12 consumer complaints for the 2003 Chevrolet Express 2500 as of Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

What part of the 2003 Chevrolet Express 2500 is reported most often?

Brakes is named most often, in 5 complaints (42% of the total), followed by fuel system with 3.

Has the 2003 Chevrolet Express 2500 been recalled?

NHTSA lists no recall campaigns for this model year in the data used here. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.

At what mileage are problems with the 2003 Chevrolet Express 2500 reported?

Among the 10 complaints that include a mileage, the median is 74,162 miles and the middle half falls between 49,000 and 120,000 miles; 30% were filed for vehicles with under 50,000 miles.

About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.

Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.