1999 Ford F-350 SD Electrical system Problems

“I havea 1999.5 Ford f-350 diesel crewcab dualley truck. On 05/15/2007 while driving on the freeway noticed a loss of power. I got off freeway, and truck was idling erracticly and roughly with loss of power. The next day truck started up like normal. I test drove the truck, and same symtoms occurred. This time the check engine light came on. I changed the cam positioner sensor (cps), and reset the computer. I test drove the truck with no problems I had before.”

“I have a 1999 f350 super duty diesel with a 7.3 engine and my inside light do not work right some times it will just come on as you are driving down the street and some times it wont come on when you open the door .the inside light is getting worse my truck would just stop running as you are driving down the street or at a stop light. I went into the fuse box under the steering wheel and I thought it could be a fuse come to fine out that my relay fuse to the inside light was so hot that it could have started a fire so I pulled it out now I drive around with no inside lighting.”

“The batteries on my 1999 f350 crew cab dually with a 7.3 diesel went dead. When I tried to charge the batteries the charger showed an extremely high draw. I heard a solenoid clicking under the drivers side battery and the radio would turn on and off. I also noticed that my heater control would work even with the key off. After taking to the local Ford dealer I was told that the windshield was leaking and water had damaged the gem module and the fuse block. Repair cost to replace the gem module, fuse block and seal the leaking area was $1063.01. …”

“I was driving and my truck stalled before getting to a complete stop. I was about to reach bumper to bumper traffic. Luckily there was grass on the right hand side and I pulled in there to avoid hitting a car. Had to go over the sidewalk. After turning off, I tried to start with no luck. After 10 minutes I tried again and it started. A little down the road same thing happened, it stalled. Happened like 2 more times until I got to work. Called my mechanic and he stated that the cps usually goes out and he bought one for me. Installed it and it worked. …”

“April 2nd of 2004 driving at 30 MPH and coasting to a stop sign the number 3 spark plug blew out of the right side cylinder head of my 1999 Ford f-350 with a v-10 engine in it. Ford in kingman,az. Installed a reconditioned cylinder head that had a spark plug blow out of it and a steel insert was the fix for that cylinder head. I was given a reconditioned head with the insert in it and told by the Ford mechanic in kingman,az. That it is just a matter of time before it blows another spark plug out or sucks the steel insert into the engine. …”