2015 Ford F-350 SD Engine cooling Problems
- Complaints
- 3about this part
- Share
- 1%of 208 total for the year
- Median mileage
- 120,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 3 complaints about the engine cooling of the 2015 Ford F-350 SD, 1% of the 208 complaints for this model year. Where a mileage was given, the median is 120,000 miles. 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“The contact owns a 2015 Ford F-350. The contact stated that while driving 55 MPH, the vehicle drove over a bump in the roadway and started losing motive power. There was no warning light illuminated. Despite the failure, the contact was able to drive at a reduced speed back to the residence. Upon inspection, the contact discovered that the intercooler hose had cracked, causing the vehicle to lose motive power. The contact replaced the intercooler hoses and the MAP sensor. Upon investigation, the contact stated that the failure was a known issue. …”
NHTSA complaint #11639640, filed 2025-01, 120,000 miles“The contact owns a 2015 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was taken to an independent mechanic, who determined that the diesel particulate filter was cracked and required a replacement. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 20M06, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. …”
NHTSA complaint #11568113, filed 2024-01, 49,000 miles“The contact owns a 2015 Ford F-250. The contact stated while driving approximately 72 MPH going downhill, the instrument panel was failing where it would illuminate and unilluminated. There were fireballs being exhausted from the pipe. The fireballs caused a fire in the desert. The contact then lost power steering and the engine shut down, but the contact was able to pull over safely. The fire department and highway patrol arrived on the scene. The fire department extinguished the fire. The contact was unaware of any report being filed. There were no injuries or medical treatment needed. …”
NHTSA complaint #11482580, filed 2022-09, 135,000 milesRelated service bulletins
- 10251453Feb 20, 2024This article supersedes TSB 22-2201 to update the Service Procedure and Parts List. Some 2015-2019 F-Super Duty and 2016-2019 F-650/F-750 vehicles equipped with a 6.7L engine may…
- 10237789Jun 8, 20232011-2023 F-Super Duty and 2016-2024 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an elevated idle condition. During prolonged idle time, vehicles may experience…
- 10228867Dec 13, 2022Some 2011-2022 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit a ticking noise at idle after an engine oil change. It is often referred to as Typewriter…
- 10209384Mar 24, 20222011-2022 F-Super Duty and 2016-2023 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an elevated idle condition. During prolonged idle time, vehicles may experience…
- 10206862Jan 11, 2022Customer Satisfaction Program 21M01 Certain 2013-2016 Model Year F-250-F-550 Vehicles Equipped with a 6.7L Diesel Engine - Reductant Heater and Sender Assembly Repair
- 10202716Oct 22, 2021Certain 2015 through 2016 Model Year Super Duty and 2016 through 2019 Medium Duty with 6.7L Diesel Engine; Diesel Particulate Filter Warranty Extension with Diagnostic Trouble…
- 10201580Sep 9, 2021Some 2013-2016 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an Exhaust System Fluid Fault message and a forced idle mode with various diagnostic trouble codes…
- 10201092Aug 31, 2021This program extends the warranty coverage of the catalytic converter portion of the selective catalyst reduction (SCR) system for twelve months of service, beginning on the date…
- 10201089Aug 31, 2021This program extends the coverage of the front nitrogen oxides (NOx) sensor for twelve months of service, beginning on the date the powertrain control module (PCM) is…
- 10201038Aug 27, 2021Some 2015-2019 F-Super Duty and 2016-2019 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an oil leak from the oil filter, crankcase vent oil separator, oil cooler…
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 2 | 14% |
| 2024 | 1 | 2% |
| 2023 | 1 | 2% |
| 2022 | 3 | 3% |
| 2021 | 1 | 1% |
| 2019 | 2 | 0% |
| 2018 | 3 | 1% |
| 2017 | 2 | 0% |
| 2016 | 3 | 1% |
| 2015 | 3 | 1% |
| 2012 | 5 | 17% |
| 2011 | 5 | 12% |
| 2010 | 2 | 4% |
| 2009 | 2 | 11% |
| 2008 | 21 | 21% |
| 2006 | 16 | 13% |
| 2005 | 48 | 22% |
| 2004 | 42 | 32% |
| 2003 | 51 | 39% |
| 2002 | 41 | 33% |
| 2001 | 40 | 25% |
| 2000 | 41 | 26% |
| 1999 | 32 | 23% |
Other parts of the 2015 Ford F-350 SD
67 complaintsSuspension
66 complaintsEngine
38 complaintsFuel system
26 complaintsOther or unknown
26 complaintsTransmission and drivetrain
17 complaintsElectrical system
16 complaintsWheels
14 complaintsBack-over prevention (rear camera)
13 complaintsBrakes
6 complaintsTires
5 complaintsVisibility (wipers, defrost, mirrors)
5 complaints
← All problems reported for the 2015 Ford F-350 SD
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology