2019 Ford F-350 SD Engine Problems

“On September 21, 2022 I was driving to Vail, CO. I hit a bump in the road as I was heading up the Vail pass. Immediately after, my truck started shaking violently out of control with no control of my steering. I skid across the highway and was lucky not to hit anything. When looking this up it appears it was the Ford Death Wobble.”

“I have about 54000 miles on a 2019 ford super duty 350 with the Power stroke 6.7. Engine light went on and its at Willowbrook ford in Illinois. Emission problem with Particular Sensor code 22e02. The cost of repair is between $816 plus another $1259 if it is cracked. This is absolutely ridiculous. After researching this is a big Ford problem. So they sold some trucks without them and have eliminated them on their 22 models. I think Ford should be responsible for the cost.”

“While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. …”

“Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a Reduced Engine Power Warning , and then shuddered. That was immediately followed by a Service Engine Soon warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material falling from underneath, I shouted fire, and my wife exited while I retrieved our dog from the back seat. …”

“An OBD2 engine code of P2002 came up, so I took it to my local Ford Dealership. While it was at the dealership, I did a little research and found out that this crack on the DPF filter was a common occurrence on 2017-2020 F250 and F350 Powerstrokes. Ford is aware of this problem but they told me that my warranty would not cover this, as it was a filter ! This crack is located on the piping right before a flange connection! It is a factory weld that is cracking in every one of this diesel trucks! I was quoted a repair cost of over $6300 ! …”