2023 Ford F-350 SD Technical Service Bulletins

285 technical service bulletins (TSBs) are on record for the 2023 Ford F-350 SD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11001575Jun 6, 2024Transmission and drivetrain. This article supersedes TSB 23-2376 to update the Part List and the Service Procedure. Some 2022-2024 F-550 and F-600 F-Super Duty vehicles equipped with a 10R140 automatic transmission and 6.7L diesel engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P2704 and P0771 stored in the transmission control module (TCM) with poor shift quality and over 5,000…
• 11001370Jun 6, 2024Electrical system. 2024 F-Super Duty vehicles equipped with a diesel engine and dual generators built on or after 02-May-2024 now utilize an accessory drive belt that is grooved on one side only. Prior to this build date, a dual groove accessory drive belt was used for this application. The accessory drive belt should not be considered a misbuild and not be changed to the dual-sided design.
• 11001368Jun 6, 2024Transmission and drivetrain. When replacing the E clutch hub (7P211) on 2020-2024 F-Super Duty and 2024-2025 F-650/F-750 vehicles equipped with a 10R140 transmission, a new washer (7482) has been added and must be installed with the new updated E clutch hub. Refer to the Workshop Manual (WSM), Section 307-01B for proper installation of the washer. Refer to the parts catalog for the appropriate part numbers for the E clutch hub and the washer.
• 11003269Jun 5, 2024Other or unknown, Visibility (wipers, defrost, mirrors). Quality improvements include: - Robustness to improve the with Rain Sensor automatic wiper and courtesy wiper features. - Robustness action to improve the Steering Column Control Module (SCCM) Key Off Load (KOL) Issue.
• 11001366Jun 5, 2024Brakes. Some 2023-2024 F-Super Duty vehicles may require a replacement of the anti-lock brake system (ABS) module for various reasons. Replacing the ABS module may result in an error state with diagnostic trouble code (DTC) C0020:64 stored in the ABS module due to the Ford Diagnosis and Repair System (FDRS) software.
• 11000739Jun 3, 2024Other or unknown. Some 2023-2024 F-Super Duty vehicles equipped with a flowthru floor console may exhibit a media bin door that will not open or is difficult to operate. This may be due to a missing or damaged guide finger and/or latch pin on the underside of the media bin. To correct the condition, follow the Service Procedure to replace the media bin at the front of the floor console, inspecting the guide finger and latch pin, and…
• 11001113May 31, 2024Transmission and drivetrain. 2023-2024 F-Super Duty/F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2023-2025 F-650/F-750/E-Series vehicles equipped with a Dana rear axle and built on or after 01-Nov-2022 may have orange/red RTV sealant used as the gasket on the differential housing cover. This does not indicate any previous repairs as it is used by Dana during assembly.
• 11001112May 30, 2024Other or unknown. Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent system reboots. - Intermittent Wireless CarPlay or Android Auto function. - Phone related concerns with intermittent No Audio or Static. - Navigation/global…
• 11000911May 18, 2024Other or unknown. Quality improvements include: - When pre theft event occurs customers will get a notification via Fordpass App. Secondarily, if customer vehicle stolen then call center will be able recieved theft location reports
• 11000297May 18, 2024Transmission and drivetrain. Various vehicles equiped with 10R80/10R80 MHT/10R100/10R140 transmissions may require replacement of the seal kits (7153) when internal repairs are being performed. These kits come with 4 wheel drive (4WD) seals and will no longer include the 2WD seals. When working on a 2WD vehicle, any 2WD seals must be ordered separately. Refer to the parts catalog for the proper 2WD seals required.
• 11000889May 15, 2024Seats. Quality improvements include: - Seats Modules enhancement to address Key Off Load issues
• 11001148May 13, 2024Other or unknown, Transmission and drivetrain. Certain 2023-2024 Super Duty and 2021-2025 Model Year Econoline Equipped With a 6.8L or 7.3L Gasoline Engine - Powertrain Control Module Software Update
• 11000288May 9, 2024Steering. Some 2023-2024 F-Super Duty vehicles built on 22-May-2023 and through 15-Dec-2023 may require repairs of the power steering system for various reasons. If repairing a power steering fluid leak at or near the power steering fluid cooler, a worm clamp (part number 376240-S100) can be used adjacent to the factory clamp in lieu of steering hose replacement for any power steering hoses affected by the repair.
• 11000179May 2, 2024Other or unknown. Some 2023 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated MIL with diagnostic trouble code (DTC) U3012 present in the powertrain control module (PCM). This may be due to the software in the body control module (BCM) and does not affect vehicle operation. To correct the condition, reprogram the BCM using the latest software level of the Ford Diagnosis and Repair System (FDRS) scan tool.
• 10254140Apr 24, 2024Steering. Some 2023-2024 F-Super Duty vehicles may exhibit various diagnostic trouble codes (DTCs) related to the steering angle sensor. Prior to any diagnosis, determine if the vehicle is equipped with an electronic steering actuator (ESA), also referred to as the power steering control module (PSCM), so appropriate pinpoint tests are followed. The ESA is located on the steering shaft and can be seen through the left fender…
• 10254138Apr 24, 2024Equipment. All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet…
• 10254133Apr 23, 2024Other or unknown. Some 2022 F-Super Duty vehicles equipped with a 12.3 inch center display screen and 2023-2024 F-Super Duty vehicles may exhibit DTCs B1D08 and/or B1D09 stored in the trailer module (TRM) with a Trailer Brake System Fault See Manual message in the instrument panel cluster (IPC) when a trailer is not connected to the vehicle. This may be due to water intrusion at the back side of the trailer tow connector. Disconnect…
• 10254127Apr 18, 2024Other or unknown, Engine cooling. Some 2023-2024 F-Super Duty/F-53 Motorhome/F-59 Commercial Stripped Chassis or 2023-2025 E-Series/F-650/F-750 vehicles equipped with a gas engine may exhibit an illuminated MIL with ignition system DTC(s) P0352, P0353, P0354, P0355, P0357, P2303, P2306, P2309, P2312, P2318, P2304, P2307, P2310, P2313, P2319, and/or P2322 set in the powertrain control module (PCM). This may be due to incorrect cylinder to DTC…
• 10254330Apr 17, 2024Electrical system. Quality improvements include: -Robustness action to improve the SYNC reboot issue that may occurs after 2 hours of continuous use. -Rear Seat Occupant Alert will re-trigger after Clear Exit Assist Alert ends. -Various other vehicle enhancement updates includes In vehicle Voice Feedback, Phone as a Key, Enable Customer Approach Detectability.
• 10254327Apr 11, 2024Electrical system. Quality improvements include: Rear Seat Occupant Alert will re-trigger after Clear Exit Assist Alert ends. Share Vehicle Analytics Customer Connectivity Setting toggle will become visible and be set to a regionally dependent default value. User (Fleet Owner) shall have the ability to execute inhibit/de-inhibit and scheduled inhibit/de-inhibit requests to vehicle.
• 10253682Apr 8, 2024Other or unknown, Engine cooling. Some 2023-2024 F-Super Duty vehicles equipped with a perimeter alarm and built on or before 27-Mar-2024 may exhibit a false alarm activation intermittently. This may be due to the software in the body control module (BCM). Monitor the BCM alarm event parameter identifications (PID). If ALARM_EVT_1/2/3/4 show a value of Intrusion Sensor, reprogram the BCM using the latest software level of the Ford Diagnosis and…
• 10253556Apr 5, 2024Engine cooling. Some 2023-2024 F-Super Duty vehicles may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2122, P2123, P2127, P2128, and/or P2138 stored in the powertrain control module (PCM). The vehicle may or may not exhibit a perceived lack of power intermittently. Perform a wiggle test of connector C1580 at the left rear of the engine compartment while the engine is at…
• 10252647Mar 26, 2024Transmission and drivetrain. Some 2022-2024 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with only diagnostic trouble code (DTC) U3012 stored in the PCM. If no drivability concerns or other DTCs are present, perform normal diagnostics per the Workshop Manual (WSM). If diagnostics lead to the powertrain control module (PCM) or body control module (BCM), the replacement of the PCM…
• 10252609Mar 20, 2024Electrical system. This article supersedes TSB 24-2030 to update the production fix date. Some 2023-2024 F-Super Duty vehicles built on or before 07-Feb-2024 and equipped with a 6.7L engine may exhibit an intermittent interruption of a split shaft PTO system installed by an upfitter. This may be due to the software in the powertrain control module (PCM).
• 10252704Mar 15, 2024Exterior lighting, Equipment. Quality Improvements include: - Fixing the headlamp staying ON issue during the BCM OTA update
• 10252627Mar 15, 2024Other or unknown. Some 2023-2024 F-Super Duty vehicles equipped with a trailer brake control module may exhibit a Trailer Disconnected message after cycling the ignition off and back on with a trailer connected. This may be due to the presence of an integrated battery charger on a trailer equipped with electric over hydraulic brakes.
• 10252626Mar 14, 2024Engine cooling. Some 2021-2024 Bronco Sport vehicles equipped with a 1.5L EcoBoost engine may exhibit water coolant pump leaks. This may be due to contamination in the coolant system. To correct this condition and prevent recurrent water pump failures, perform a coolant system flush. Refer to the Workshop Manual (WSM), Section 303-03A Engine Cooling - 1.5L EcoBoost > General Procedures > Engine Cooling System Flushing > Steps 1-8…
• 10252546Mar 12, 2024Electrical system, Transmission and drivetrain. This TSB supersedes article 24-2036 to update the vehicles affected. Some 2023-2024 F-Super Duty pickup vehicles built on or before 02-Jan-2024 equipped with a 6.7L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0133, P0139, and/or P0145 stored in the powertrain control module (PCM). This may be due to the software in the PCM and does not affect vehicle operation.
• 10252705Mar 11, 2024Transmission and drivetrain. Quality Improvements include: - To Improve the shift quality and more accurate OBD in-use performance ratios for Evap Monitor
• 10251956Mar 8, 2024Electrical system. Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To correct the concern, download and run the Transport and Factory Mode Deactivation app: under HS1 modules select BCM > Transport and Factory Mode > Download > Run. When the pop-up…
• 10252703Mar 7, 2024Equipment, Visibility (wipers, defrost, mirrors). Quality Improvements include: - Fix for Window One touch operation
• 10252530Mar 7, 2024Transmission and drivetrain, Electrical system. Some 2023 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P20A5 stored in the powertrain control module (PCM). This may be due to the software in the glow dosing module (GDM) and does not affect vehicle operation. Due to on-board diagnostic (OBD) functionality, the GDM may be referred to as the secondary OBD control…
• 10251952Mar 6, 2024Engine cooling. For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause…
• 10251950Mar 6, 2024Electrical system. Many body control module C (BCMC) warranty return parts are coming back with no trouble found. To verify that the BCMC is at fault prior to replacing, perform the following. First, disconnect the battery then check all BCMC connectors for terminal pushout, pin damage, spread terminals, and corrosion. Refer to Workshop Manual Section 100-00 Wire Terminal Inspection and Replacement. If none found, reconnect the BCMC…
• 10251947Mar 4, 2024Equipment. Some 2021-2024 Bronco/F-150, 2023-2024 Escape/F-Super Duty vehicles equipped with SYNC 4 may experience a concern during accessory protocol interface module (APIM) programming where the vehicle's center display screen indicates USB Error. This may be due to a lack of memory space available to perform the APIM software update. If it is a memory concern, the Ford Diagnosis and Repair System (FDRS) will provide an…
• 10251937Mar 1, 2024Electrical system, Other or unknown. 2023 F-Super Duty, 2023-2024 Expedition, 2024 Nautilus/F-150 vehicles will exhibit no light emitting diode (LED) confirmation from the key fob indicating that the vehicle has remote started (or not remote started). Factory key fobs with remote start no longer contain a LED feedback indicator. Do not replace the key fob for this condition. This is a normal operating characteristic and no service action is necessary.
• 10251934Mar 1, 2024Transmission and drivetrain. During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section…
• 10250854Feb 29, 2024Brakes. Some 2022 F-Super Duty vehicles equipped with a 12.3 inch center display screen and 2023-2024 F-Super Duty vehicles may exhibit DTCs B1D08:11 and/or B1D09:11 stored in the trailer module (TRM) with a Trailer Brake System Fault See Manual message in the instrument panel cluster (IPC) when a trailer is not connected to the vehicle. This may be due to water intrusion at the back side of the trailer tow connector.
• 10250850Feb 27, 2024Electrical system, Transmission and drivetrain. Some 2023-2024 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) U02A2, P206B, P203B, P208A, P20FA, P20FD, and/or P20FC stored in the powertrain control module (PCM). Before performing normal diagnostics, inspect connectors C1273C (32 pin) and C406 (14 pin) for proper connection.
• 10251261Feb 22, 2024Brakes. Certain 2023-2024 Model Year F-250/350 Vehicles - Brake Vacuum Sensor Replacement
• 10251257Feb 22, 2024Transmission and drivetrain. Certain 2023 Model Year Super Duty and Transit Vehicles Equipped with 10R Transmissions - Main Control Assembly Bolt Inspection
• 10250528Feb 16, 2024Equipment, Brakes. Some 2023 F-Super Duty vehicles equipped with a 12 inch center display screen and driver assistance package DBCAY (minor feature code) may exhibit the brakes applying without brake pedal input during parking lot type driving below 5 mph (8 km/h). To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left…
• 10251461Feb 6, 2024Back-over prevention (rear camera), Electrical system. Some 2023-2024 F-Super Duty chassis cab vehicles built on or before 02-Jan-2024 equipped with a 6.7L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0133, P0139, and/or P0145 stored in the powertrain control module (PCM). This may be due to the software in the PCM and does not affect vehicle operation. To correct the condition, reprogram the PCM and transmission control module (TCM).
• 10251459Feb 1, 2024Electrical system, Back-over prevention (rear camera). Some 2023-2024 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an intermittent interruption of a split shaft PTO system installed by an upfitter. This may be due to the software in the PCM. To correct the condition, follow the Service Procedure to reprogram the powertrain control module (PCM) and the transmission control module (TCM).
• 10249432Jan 26, 2024Electrical system, Other or unknown. Some 2022-2023 F-150 and 2023 F-Super Duty vehicles equipped with a direct current/alternating current converter module A (DCACA) inverter (minor feature code HUKAK) may exhibit a Please Contact Authorized Dealer For Service message in the center display screen with DTC P0A93:96 stored in the DCACA. This may be due to the software level of the DCACA and has no effect on vehicle operation.
• 10249178Jan 19, 2024Engine cooling. Some 2023-2024 F-Super Duty vehicles equipped with a 6.7L engine may require fuel injector removal and replacement for various reasons. Fuel injector o-ring and supply tube kits LC3Z-9229-A and LC3Z-9229-B for 2020-2022 F-Super Duty vehicles should be utilized when instructed to replace these parts in Workshop Manual, Section 303-04. The parts catalog is in the process of being updated.
• 10249175Jan 18, 2024Steering. 2024 F-Super Duty vehicles are equipped with XL-22 (WSS-M2C184-A1) high temperature power steering fluid that looks like clear hydraulic fluid. This fluid is an improvement in high temperature and thermal oxidative stability compared to Mercon LV. This power steering fluid is also compatible and highly recommended to use when filling or topping off power steering systems of all 2012-2023 F-Super Duty vehicles…
• 10249756Jan 12, 2024Back-over prevention (rear camera), Electrical system. This TSB supersedes article 23-2386 to update the Service Procedure. Some 2023 F-Super Duty vehicles equipped with a 12.3 inch instrument cluster display screen may exhibit various concerns with the instrument panel cluster (IPC). This may be due to the software in the IPC.
• 10248367Dec 20, 2023Engine cooling. Some 2023 F-Super Duty chassis cab vehicles equipped with a 6.7L engine may exhibit an engine coolant temperature gauge reading at the high end of the normal range while towing in high ambient temperatures with no diagnostic trouble codes (DTC) stored in the powertrain control module (PCM) or warning messages present in the instrument panel cluster (IPC). This may be due to the software in the IPC.
• 10248365Dec 20, 2023Transmission and drivetrain. Some 2023 F-Super Duty vehicles equipped with a 6.8L or 7.3L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P061B, U0140, U3035 and/or U3036 stored in the powertrain control module (PCM). This may be due to the software in the PCM. To correct the condition, follow the Service Procedure to reprogram the PCM.

← All problems reported for the 2023 Ford F-350 SD