2024 Hyundai Ioniq 5 Steering Problems

“This is the second time the ICCU failed. The car is waiting for a full EV battery replacement. The first time the failure happened on 12/11/25, at 9,165 miles, the alert happened just before the car came to a full stop as we were driving along the road near our house, it was very difficult to steer, we were sort of stopped in the road and had to get it towed. The second time the alert came on 4/16/26 and we were able to get it to the dealer.”

“The vehicle was returned to me after a manufacturer-authorized high-voltage battery replacement that was completed on December 10, 2025. Immediately after pickup, the vehicle began exhibiting safety-related issues. I experienced abnormal and hard steering operation, repeated low coolant warnings, and battery management system (BMS) and electrical warning messages. These warning messages appeared immediately after the repair and before the vehicle was driven by me. I returned the vehicle to the dealership multiple times for the same issues. …”

“Vehicle steering or at least power steering failed catastrophically. Started with some electronic sounds at extremes of turning radius but subsequently failed completely and rendered car undriveable. Hyundai repair center attributed this to excessive dirt and dust or some external force, but was unable to substantiate or demonstrate any damage to parts they say need replacing. Ultimately this remains undiagnosed with regards to cause but dealer clearly identifies need to replace P/S motor and rack and pinion assembly. …”

“Going thru a parking lot to a drive thru at a fast food place, rounding a small curve at a very low speed then trying go to 1 st lane out of 2 lanes the car suddenly went out of control and accelerated to center pole. The pole was a barrier protecting the support pole for the canopy. The car front center hit the pole so hard that the front collapsed. The hood buckled in the center and the pole went half way to the windscreen. The air bags did not deploy. The driver got hit with steering or something in the chest and caused lot of pain for about 10 days. No internal injury was detected. …”