2015 Mercedes-Benz Sprinter 2500 Fuel system Problems
- Complaints
- 2about this part
- Share
- 9%of 23 total for the year
- Median mileage
- 112,500miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 2 complaints about the fuel system of the 2015 Mercedes-Benz Sprinter 2500, 9% of the 23 complaints for this model year. Where a mileage was given, the median is 112,500 miles. 1 recall campaign on record is filed under a similar system.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“The contact's employer owns a 2015 Mercedes-Benz Sprinter 2500. The contact stated that when the vehicle was started in the morning, there was a small puddle of fuel pooling under the fuel tank lid. The contact was not aware of any warning light being illuminated. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the leak was from the fuel filler neck and the fuel filler neck needed to be replaced. The vehicle was not repaired. …”
NHTSA complaint #11652614, filed 2025-04, 180,000 miles“The contact owns a 2015 Mercedes-Benz SPRINTER 2500. While the vehicle was at the dealer for inspection, it was discovered that the diesel particular filter was fractured. The chassis connecting bracket failed and fractured the diesel particular filter. The vehicle was not repaired. The manufacturer advised that the warranty was expired and the repair cost would not be covered. The approximate failure mileage was 45,000.”
NHTSA complaint #10970681, filed 2017-04, 45,000 milesRelated recalls
- 17V092000Feb 10, 2017Daimler Vans USA, LLC (DVUSA) is recalling certain 2015 Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles were manufactured without a protective…Covers: Mercedes-Benz Sprinter 2500 2015, Sprinter 3500 2015
Related service bulletins
- 11034416Jun 3, 2026OM642 DPF Filter Cracked or Broken Complaint Vehicle will not start or exhibits noisy exhaust. Check Engine Lamp (CEL) is on. Multiple control unit communication and system…
- 11030629Mar 23, 2026The check engine light is illuminated, or the AdBlue warning is active, with recorded faults related to AdBlue quality or concentration. Complaint Customer reports an illuminated…
- 11016427Mar 10, 2025Procedure for When Diesel Fuel Tank is Filled with Incorrect Fuel Type Complaint: Procedure for When Diesel Fuel Tank is Filled with Incorrect Fuel Type (e.g., gasoline, water…
- 11016423Mar 10, 2025EGR Valve Diagnosis and Cleaning Procedure Complaint A: The engine is jolting/bucking between 1700 and 1900 rpm. Complaint B: One or more mechanical related fault codes for EGR…
- 11014726Feb 12, 2025Complaint Fault code P06DA00 is found current or stored in engine control unit. Check engine light may be activated. Cause Various causes Remedy Up to Model year 2018: Fault code…
- 11014728Feb 4, 2025Complaint The check engine light or AdBlue warning is activated, accompanied by one or more of the following fault codes rela- ted to the AdBlue tank: P206B31: Malfunction of the…
- 10232323Feb 23, 2023Complaint MIL illuminated. Fault codes for 'position sensor of crankshaft' in combination with fault codes for 'Output stage fuel injectors' are set in the CDI control unit.
- 10227139Nov 21, 2022SMOG Test will not complete successfully. NOTE: Customers may come to dealership as instructed by ISP (Independent Service Provider) based on instructions from a TSB (Technical…
- 10214960Jun 13, 2022Complaint After installing new NOx sensors during the Approved Emission Modification (AEM), the Exhaust Aftertreatment Customer Service Measure in XENTRY/DAS displays incorrect…
- 10181196Sep 14, 2020Mercedes-Benz USA, LLC (?MBUSA?) has entered into an agreement with the United States Department of Justice (DOJ), the Environmental Protection Agency (EPA), the California Air…
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2024 | 1 | 8% |
| 2023 | 5 | 26% |
| 2022 | 4 | 10% |
| 2021 | 3 | 7% |
| 2020 | 4 | 5% |
| 2019 | 1 | 1% |
| 2018 | 1 | 7% |
| 2017 | 1 | 8% |
| 2015 | 2 | 9% |
| 2014 | 3 | 8% |
| 2011 | 1 | 7% |
| 2010 | 3 | 21% |
Other parts of the 2015 Mercedes-Benz Sprinter 2500
4 complaintsAir bags
3 complaintsVehicle speed control
3 complaintsBrakes
2 complaintsElectrical system
2 complaintsEngine
2 complaintsOther or unknown
2 complaintsForward collision avoidance
1 complaintsSeat belts
1 complaintsSeats
1 complaintsBody and structure
1 complaintsSuspension
1 complaints
← All problems reported for the 2015 Mercedes-Benz Sprinter 2500
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology