2007 Mercury Milan Body and structure Problems
- Complaints
- 17about this part
- Share
- 4%of 434 total for the year
- Median mileage
- 72,793miles
- Trend
- StableComplaints filed in the last 3 full calendar years are within 25% of the 3 years before.
NHTSA recorded 17 complaints about the body and structure of the 2007 Mercury Milan, 4% of the 434 complaints for this model year. Where a mileage was given, the median is 72,793 miles. 1 of these say a crash was involved, according to the filers.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Arrived at destination parking lot and driver door handle seemed to snap and unable to open the driver door. Crawled over the center consul to exit the passenger side. Locked car and when I returned I entered the passenger side and crawled over the consul to the driver seat. Once I got home I repeated the same exit process and went around to open the driver door and once opened it did not close. Had to bungie cord the door shut in the garage to turn off the courtesy lights and silence door ajar alarm. Next morning immediately took it to dealer. …”
NHTSA complaint #10905087, filed 2016-09, 72,793 miles“I was driving forward at about 15 MPH on a snow covered road (residential city street). I came upon an uncontrolled intersection when I noticed a car coming from my right side, I then attempted to slow down and stop. While trying to slow down my brake pedal lost all pressure and went to the floor, causing an inability to slow down properly. Resulting in my car hitting the rear driver side of the other car in the middle of the intersection. My brake pedal has lost pressure 3 times previously all in the same winter conditions (snow and icy road) and while trying to slow down. …”
NHTSA complaint #10940172, filed 2017-01, 120,000 miles“Door handles and latches popping off. Door handles on driver and passenger door came right off. Driver door swings opens and swings back shut as soon as you open the door. Locking individuals out of the car without being locked.”
NHTSA complaint #10782420, filed 2015-10, 100,000 miles“Takata recall. The contact owns a 2007 Mercury Milan. The contact stated that the dashboard had a crack near the air bags. The vehicle was not diagnosed or repaired. Contact received notification of NHTSA campaign number: 16v384000 (air bags). The part needed for the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 82,465. Vin tool confirms parts not available.”
NHTSA complaint #10934889, filed 2016-12, 82,465 miles“The passenger side front door flew open while driving. The door was in locked position and opened while going around a curve in the road. Passenger was wearing seatbelt so no injury occurred. Attempts were made to close door, however it opened under slightest of pressure, even when locked. Door was tied closed with rope and taken to dealership for repair. The latch assembly on the door was found to be broken and replaced.”
NHTSA complaint #10336125, filed 2010-06, 63,000 milesBody and structure: other model years
Other parts of the 2007 Mercury Milan
232 complaintsBrakes
127 complaintsTransmission and drivetrain
22 complaintsVehicle speed control
18 complaintsElectrical system
14 complaintsEngine
13 complaintsOther or unknown
12 complaintsFuel system
10 complaintsTires
10 complaintsLatches, locks and linkages
8 complaintsEngine cooling
5 complaintsSteering
3 complaints
← All problems reported for the 2007 Mercury Milan
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology