2004 Chrysler Town And Country Suspension Problems
- Complaints
- 7about this part
- Share
- 4%of 167 total for the year
- Median mileage
- 64,918miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 7 complaints about the suspension of the 2004 Chrysler Town And Country, 4% of the 167 complaints for this model year. Where a mileage was given, the median is 64,918 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Consumer 2004 Chrysler Town And Country ball sockets were loose, rack and pinion was leaking red and pink fluid. The bushings had worn out, which was due to the rattle the consumer was hearing from the front of the vehicle.”
NHTSA complaint #10148620, filed 2006-01, 13,880 miles“The contact owns a 2004 Chrysler Town And Country. The contact recently purchased the vehicle and noticed that the rear beam axle developed extreme rust. The contact also stated that the mounts that held the rear leaf springs were almost completely rusted as well. In addition, the vehicle was loosing oil abnormally, but there was no signs of where the oil was leaking. The vehicle was not inspected or repaired. The failure and current mileages were 101,000.”
NHTSA complaint #10402577, filed 2011-05, 101,000 miles“The contact owns a 20045 Chrysler Town And Country lx. While driving various speeds over bumps in the road, the vehicle makes loud noises. The contact took the vehicle to the dealer on november 15, 2007 and they replaced the sway bar bushing; however, the repair did not permanently correct the failure. The vehicle was taken back to the dealer on feb 12, 2009. The dealer stated that the failure could recur two or three times in the lifetime of the vehicle. The repair would cost $475. …”
NHTSA complaint #10258567, filed 2009-02, 65,836 miles“The contact owns a 2004 Chrysler Town And Country. The contact took the vehicle to the dealer because of a loud knocking sound when driving over bumps. The mechanic stated that the noise was from the wear and tear of the suspension. The defect was replaced with a front suspension bushing sway eliminator module. The dealer stated that this was a common failure with this year, make, and model vehicle. The dealer further stated that there were no recalls available. The speed was unknown. The failure mileage was 64,000 and current mileage was 65,000. Updated 3/5/08”
NHTSA complaint #10211808, filed 2007-12, 64,000 milesRelated service bulletins
- 10016751May 27, 2005Creaking/squawking sound from front strut area.
- 10013699Mar 16, 2005Rattle/knocking sound from the front suspension.
Suspension: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2016 | 2 | 0% |
| 2015 | 6 | 2% |
| 2014 | 3 | 0% |
| 2013 | 2 | 0% |
| 2012 | 7 | 1% |
| 2011 | 8 | 1% |
| 2010 | 10 | 1% |
| 2009 | 4 | 1% |
| 2008 | 25 | 1% |
| 2007 | 4 | 2% |
| 2006 | 8 | 2% |
| 2005 | 25 | 3% |
| 2004 | 7 | 4% |
| 2003 | 11 | 4% |
| 2002 | 17 | 4% |
| 2001 | 29 | 6% |
| 2000 | 22 | 7% |
| 1999 | 32 | 9% |
| 1998 | 18 | 6% |
| 1997 | 18 | 5% |
| 1996 | 38 | 4% |
| 1995 | 3 | 5% |
| 1994 | 4 | 3% |
| 1993 | 3 | 1% |
| 1992 | 2 | 1% |
Other parts of the 2004 Chrysler Town And Country
58 complaintsElectrical system
23 complaintsSteering
22 complaintsEngine cooling
16 complaintsAir bags
14 complaintsTransmission and drivetrain
13 complaintsBrakes
10 complaintsEngine
9 complaintsExterior lighting
9 complaintsBody and structure
9 complaintsEquipment
5 complaintsVehicle speed control
5 complaints
← All problems reported for the 2004 Chrysler Town And Country
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology