2007 Ford E-350 Engine cooling Problems
- Complaints
- 3about this part
- Share
- 17%of 18 total for the year
- Median mileage
- 156,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 3 complaints about the engine cooling of the 2007 Ford E-350, 17% of the 18 complaints for this model year. Where a mileage was given, the median is 156,000 miles. 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Yesterday I went to start a 2007 Ford E-350 super duty cargo van with a 5.4l triton engine. One of the spark plugs was immediately ejected which resulted in ruining the plug and coil. I was able to re-insert the plug and tighten it up, but it is also the second time it has happened to me. Previously it also happened on a 1999 E-350 with the same engine and also the same cylinder. I traded the 99 in for the 2007 and in less than a month had the same exact problem.”
NHTSA complaint #10436934, filed 2011-11, 127,500 miles“Private ambulance based in chicago has diesel fumes coming into the cabin and in the back of the ambulance. It has been a recurring issue over and over again. The rigs are 116, 120 and 112. I have notify the issue to the owner and it has not been resolved.”
NHTSA complaint #10451717, filed 2012-03, 184,500 milesRelated service bulletins
- 10055629Feb 1, 2014Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch…
- 10039053Mar 1, 2011Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
- 10039130Nov 17, 2010Ford: there may be a lack of rpm, hesitation, or rough running concerns when the vehicle is in idle. There may be two trouble codes stored. The problem may be caused by…
- 10028826Jun 1, 2009Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378…
- 10028730May 1, 2009Ford: some vehicles equipped with 6.0l diesel engine may exhibit any one or combination of the following concerns-lack of power, white/black smoke or a surge.
- 10028284Mar 20, 2009Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. There are several potential causes for these symptoms.
- 10026387Oct 23, 2008Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
- 10027985Sep 1, 2008Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
- 10024325Mar 1, 20086.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08.
- 10023855Oct 1, 20076.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles.
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2013 | 1 | 8% |
| 2009 | 2 | 20% |
| 2008 | 1 | 3% |
| 2007 | 3 | 17% |
| 2006 | 13 | 25% |
| 2005 | 16 | 29% |
| 2004 | 10 | 22% |
| 2003 | 6 | 13% |
| 2002 | 16 | 30% |
| 2001 | 14 | 27% |
| 2000 | 6 | 10% |
| 1999 | 12 | 17% |
| 1998 | 8 | 13% |
| 1997 | 15 | 19% |
| 1996 | 3 | 6% |
| 1995 | 4 | 6% |
| 1994 | 8 | 16% |
| 1993 | 7 | 16% |
| 1992 | 4 | 10% |
| 1991 | 2 | 11% |
| 1990 | 2 | 9% |
| 1989 | 4 | 15% |
| 1988 | 1 | 9% |
| 1987 | 3 | 21% |
| 1986 | 3 | 27% |
| 1983 | 1 | 20% |
Other parts of the 2007 Ford E-350
4 complaintsFuel system
3 complaintsSteering
3 complaintsSuspension
2 complaintsTransmission and drivetrain
2 complaintsAir bags
1 complaintsElectrical system
1 complaintsLatches, locks and linkages
1 complaintsSeat belts
1 complaintsVehicle speed control
1 complaints
← All problems reported for the 2007 Ford E-350
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology