2001 Ford E-450 Problems
- Complaints
- 16filed with NHTSA
- Median mileage
- 54,200miles, 8 complaints with mileage
- Recalls
- 2campaigns on record
- Trend
- FallingComplaints filed in the last 3 full calendar years are at least 25% lower than in the 3 years before.
Sources: NHTSA records for the 2001 Ford E-450 (complaints, recalls, investigations). Report an error
NHTSA recorded 16 consumer complaints for the 2001 Ford E-450. The part named most often is tires, with 7 complaints (44% of the total), followed by suspension (4) and engine cooling (3). 8 of the complaints include a mileage, and 50% of those were filed for vehicles with under 50,000 miles; the median is 54,200 miles. NHTSA lists 2 recall campaigns and 3 technical service bulletins for this model year. Suspension complaints overlap with 1 technical service bulletin filed under the same part.
This model year has fewer than 25 complaints on record, so the numbers below can change a lot with a few new reports.
Which parts are reported most
Complaints can name more than one part, so the counts add up to more than the total. Select a part to see its complaints, recalls and bulletins.
- Tires7 44%
- Suspension4 25%
- Engine cooling3 19%
- Brakes2 13%
- Air bags1 6.3%
Example complaints
Tires: “I just had a tire blowout/tread separation on a 2001 Ford e450 rv. The vehicle has 28000 miles and the treads show little wear. The tires are firestone steeltex radial r4s ii lt225/75 r 16 load range e. Upon inspection of the other tires, notices cracks on the sidewalls of all the remaining tires and a bubble on the sidewall of one tire. What are my actions in regards to replacement of these tires? Thanks.”
NHTSA complaint #10164958, filed 2006-08, 28,500 milesSuspension: “During t wo trips on interstate highways we encountered winds from 10 to 30 MPH. On these occasions I found it necessary to slow down to 40 to 50 MPH speed in order to control motor home. I had to keep the steering wheel turned at 45 to 90 degrees to keep the unit going straight. Additionally each time a 18 wheel truck passed I had to hold the wheel tightly, as the unit was pushed to the right side of the road and swayed from side to side. When the gas tank is filled with 55 gallons (330 lbs) the steering changes completely. The front end of the truck feels light. …”
NHTSA complaint #748754, filed 2001-07Engine cooling: “1- traveling from east coast west through indiana 2- spark plug came out of cylinder causing a breakdown and towing 3- service required to replaced plug and harness - cost of 75 for tow and 213.85 for parts/labor.”
NHTSA complaint #10140175, filed 2005-10, 94,292 milesBrakes: “For an unknown reason my 2001 Ford e450 ABS light came on stayed on after I started my motorhome. The unit was parked for 4 days prior to this problem. The light didn't come one while driving to the location, only after being parked for the four days.”
NHTSA complaint #10165693, filed 2006-08, 19,750 milesMileage when problems were reported
50% of the 8 complaints with a mileage were filed for vehicles with under 50,000 miles; the middle half falls between 28,500 and 94,292 miles.
Complaints by year filed
Trend: falling. Complaints filed in the last 3 full calendar years are at least 25% lower than in the 3 years before.
Recalls and investigations
- 09V399000Oct 13, 2009Vehicle speed controlCovers: Ford E-450 1992–2003, E-150 1992–2003, E-350 1992–2003 +12 more
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and…
- 06V286000Aug 1, 2006Vehicle speed controlCovers: Ford E-450 1996–2002, F-250 1994–2002, F-350 1994–2002 +10 more
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Recall details for the 2001 Ford E-450 → · Check a VIN at nhtsa.gov/recalls
Technical service bulletins
TSBs are manufacturer notes to dealers about known repair procedures. They are not recalls and do not by themselves mean a vehicle has a fault. 3 on record; the latest 3 are shown.
- 10013298Nov 14, 2005Body and structure. Cracks in the left or right spring tower flange. *tt spring tower weld repair and replacement procedure.
- 10018941Jan 1, 2005Suspension. Vibration/harshness above 45 mph (72 km/h) after tire balance.
- 10013320Jan 1, 2005Transmission and drivetrain. Fluid leaking from the vent on the transmission mounted parking brake assembly.
Other model years of the Ford E-450
| Year | Complaints | Median mi | Recalls | Crash ★ | MPG | Score (50 = typical) | Trend |
|---|---|---|---|---|---|---|---|
| 2022 | 13 | 4,000 | 3 | — | — | — | Not enough data |
| 2021 | 27 | 9,508 | 6 | — | — | Not compared (fewer than 3 comparable model years) | Stable |
| 2019 | 5 | 111,059 | 0 | — | — | — | Not enough data |
| 2018 | 5 | 3,514 | 4 | — | — | — | Not enough data |
| 2017 | 11 | 6,000 | 3 | — | — | — | Not enough data |
| 2016 | 17 | 7,206 | 5 | — | — | — | Falling |
| 2015 | 6 | 50,878 | 2 | — | — | — | Not enough data |
| 2014 | 5 | 13,257 | 3 | — | — | — | Not enough data |
| 2013 | 12 | 25,900 | 2 | — | — | — | Not enough data |
| 2011 | 7 | 33,750 | 8 | — | — | — | Not enough data |
| 2010 | 5 | 23,652 | 6 | — | — | — | Not enough data |
| 2008 | 6 | 13,926 | 8 | — | — | — | Not enough data |
| 2007 | 12 | 30,477 | 13 | — | — | — | Not enough data |
| 2006 | 20 | 35,000 | 13 | — | — | — | Falling |
| 2005 | 34 | 21,000 | 8 | — | — | Not compared (before 2008) | Stable |
| 2004 | 27 | 28,010 | 6 | — | — | Not compared (before 2008) | Stable |
| 2003 | 18 | 38,270 | 4 | — | — | — | Rising |
| 2002 | 13 | 38,750 | 2 | — | — | — | Not enough data |
| 2001 | 16 | 54,200 | 2 | — | — | — | Falling |
| 2000 | 42 | 34,350 | 3 | — | — | Not compared (before 2008) | Stable |
| 1999 | 73 | 34,323 | 2 | — | — | Not compared (before 2008) | Stable |
| 1998 | 5 | 22,008 | 2 | — | — | — | Not enough data |
| 1997 | 18 | 54,000 | 2 | — | — | — | Stable |
All Ford E-450 model years · Best and worst years by complaints
Frequently asked questions
How many NHTSA complaints does the 2001 Ford E-450 have?
NHTSA recorded 16 consumer complaints for the 2001 Ford E-450 as of Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
What part of the 2001 Ford E-450 is reported most often?
Tires is named most often, in 7 complaints (44% of the total), followed by suspension with 4.
Has the 2001 Ford E-450 been recalled?
NHTSA lists 2 recall campaigns for this model year. To check a specific vehicle, enter its VIN at nhtsa.gov/recalls.
At what mileage are problems with the 2001 Ford E-450 reported?
Among the 8 complaints that include a mileage, the median is 54,200 miles and the middle half falls between 28,500 and 94,292 miles; 50% were filed for vehicles with under 50,000 miles.
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
Complaint counts come from NHTSA’s public complaint database; we count each complaint once. The source records for this vehicle are on nhtsa.gov. Scores and trends are our own summaries of that data, described in the methodology. This page is not legal, safety or repair advice: for a specific vehicle, check its VIN at nhtsa.gov/recalls and ask a qualified mechanic. See an error? Tell us.