2004 Honda Element Suspension Problems

“I took my Honda Element to the dealer complaining of a vibration in the right front of the car. I was told that my compliance bushings needed replaced but axles were fine. I picked up my car only to have the same problem. Upon further examination, the mechanic came to the conclusion that the right axle was bad. I had that replaced still have a vibration. I have now been told to replace the left axle. I came upon an interesting thread on a forum stating that Honda held education meetings about the frame causing the axles to wear incorrectly. …”

“2004 Honda Element: (I have 2 and both have the following exact problems)1. Airbags warning lights indicating problems 2. Drivers seat is loose and rocks 3. Passenger seat causes extreme discomfort to hip and back on long tips (this is occurs with all passengers, young and older) 3. Under carriage brushes failure 4. A/c air compressor failure 5. Straps in back seats pulled out and seat cannot be reclined 6. Engine decelerates without warning. Power cutback during passing makes this very dangerous. 7. Drivers seatbelt buckle is difficult to secure (only 1 car with this problem) 8. …”

“Excessive corrosion rear suspension near control arm. Honda has already issued a recall in Canada. I was unaware of this problem until a big piece of rusty metal fell off the bottom of my car when I closed the rear driver’s door. My control arm is ready to fall out which could have led to a fatal accident. There are Honda forums all over the internet with thousands of posts in the USA with the same issue as the Canada recall.”

“The trailer arm rusted at the mount. I was told it was not safe to drive. I have learned that this is a common problem with this vehicle and Honda has issued a recall in Canada, but not the USA. I also learned that there is a similar issue with I believe the Honda CRV and that has been in recall from Honda in I believe both Canada and the US. I found a place to do the repair and he said he has seen a lot worse than mine and has done many of these repairs.. The total repair cost is $1500. …”

“Just like the same era's Honda CR-V (the Honda Element's sibling car with many of the same components), the undercarriage rust on my vehicle is excessive: as described in the same era Honda CR-V's NHTSA Recall (23V-228). Large sections of my car’s rear frame are completely missing, and as shown in the photographs even the rear bumper fell off because of all of the rust. Just like with the CR-V, a recall for the rear frame corrosion first occurred in Canada and then in the US: see NHTSA Recall 23V-228’s chronology. …”