2021 Mercedes-Benz S 580 Wheels Problems

“I have had one tire blow out after traveling over a moderate pot hole, and 3 other tires that have been damaged with bubbles due to excessive stress from normal driving. In addition to the damaged tires, I have had 3 bent wheels all due to normal driving because the 21 inch wheels/tires on this vehicle cannot tolerate the loads during normal driving. This is a well-known defect by Mercedes and I believe it is a design defect and that it is dangerous.”

“I’ve had to replace six tires due to blowouts from hitting small potholes, something I’ve never experienced in the past 40 years of driving other vehicles! This seems to be a manufacturing defect in the vehicle, as the tires can’t support the weight of the car, and any pressure on them causes them to blow out. I’m now hesitant to drive long distances, fearing that one or more tires could blow out at any time. Without a spare tire in the trunk, I’m left stranded. Below are answers to your question: 1. The tires failed, yes they are available for inspection. …”

“I purchased this vehicle used at a dealer in Virginia. I drove it home to Chelsea Alabama, outside Birmingham. After a couple of days, my front right tire went flat. I took it to the dealer and they said the flat tire was caused by a cracked rim and required both to be replaced. Almost $3,000 for tire and rim. I continued to drive the car, maybe 4,000-5,000 miles and I had another tire go flat. This was the drivers side rear tire. This was a Pirelli 285/35 R20 run flat tire. Again when I took it to the dealer, this rim was cracked and also needed to be replaced along with the tire. $2,790. …”

“I have had 3 tire failures(blowouts)when I have hit potholes with my 21” wheels and Pirelli P Zero tires. I read on a MBZ Forum for my specific make of car - 2021/2022 MBZ S580 - that many others have experienced the same failures with these Pirelli tires. Those that have Michelin have had none. With such a small area between the road and the rim afforded by super low profile 21” setups, a tire like Pirelli with a weak sidewall will fail when the car strikes a pothole or obstruction. Another owner on the Forum said when he contacted Mercedes, they said it was not their problem, but Pirelli’s. …”

“Three wheels had rim a total of eight cracks that lead to one tire unable to hold air. Loss of air in tire can lead to crash. Mercedes service inspected car after first crack was noticed by Discount Tire when they diagnosed deflation in tire. Mercedes service reported that two additional wheel rims were cracked. Discount Tire subsequently determined a total of eight cracks and took pictures. Mercedes service representative stated that initial OEM wheels on 2021 S Class were weak and frequently failed. …”