2016 Toyota Tacoma Fuel system Problems
- Complaints
- 14about this part
- Share
- 4%of 324 total for the year
- Median mileage
- 21,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 14 complaints about the fuel system of the 2016 Toyota Tacoma, 4% of the 324 complaints for this model year. Where a mileage was given, the median is 21,000 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“After a commute drive I parked my vehicle in the garage. An hour later, went back in the garage and smelled a strong amount of fuel leak. After verification I found the high pressure fuel lines were leaking right above the driver side exhaust manifold. Drove to the nearest Toyota dealer and had new lines put in.”
NHTSA complaint #11328247, filed 2020-06, 80,112 miles“Off-roading, restarted vehicle after a stop. Check engine light came on as well as trac off illuminated. Tried to drive forward and truck stalled and message said high transmission temp. Goggled issue to discover a recall for crank position sensor failure. Looked up my VIN and I don't have that recall although I have the stated year and model. Had this happened while driving on road it could have caused an accident.”
NHTSA complaint #11321537, filed 2020-04, 120,700 miles“This car has shut off twice while driving. First time while towing a boat... While turning left on a high speed two lane road and second while going 45 towards a green light. Both times the car just shut off. We could have been killed...twice! Toyota says fixed' the problem twice . We asked them to buy the car back after the second time, as we no longer felt safe in it.......they refused. As a gesture of good will they offered us an extended warranty, which we had already gotten when we purchased the car so it was pointless. We created a case with them after it occurred the second time. …”
NHTSA complaint #11308914, filed 2020-02, 16,000 miles“Driving on the interstate 70 MPH, engine quits. 2 dash lights come on truck maxes out at 40mph out of nowhere. Pulled over shut truck off and started it up no ran fine note: check eng light is now on. Bad gas diagnosis. Gas replaced happens 1 more time. Diagnosed with bad fuel injectors not covered under extended warranty, cause was bad gas. The loss of power happened 2 other times.”
NHTSA complaint #11230835, filed 2019-07, 67,000 miles“Chirping noise comes and goes. Very loud. Also a constant clicking. Anything that makes noise like that will fail soon. Also had a grinding noise while in four wheel drive on beach and truck started to lose power.grinding went away but happens often.”
NHTSA complaint #10981550, filed 2017-05, 26,000 milesRelated service bulletins
- 10236191Apr 5, 2023DP: Although the high-pressure fuel pump is covered by Toyota?s New Vehicle Limited Warranty for 5 years or 60,000 miles (whichever comes first), we at Toyota care about the…
- 10230385Dec 22, 2022TSB: Some 2019 ? 2022 model year Avalon, 2018 ? 2023 model year Camry, 2017 ? 2022 model year Highlander, 2017 ? 2020 model year Sienna, and 2016 ? 2023 model year Tacoma…
- 10203540Oct 5, 2021TT: Use the following aids in conjunction with the repair manual when removing the fuel tank from 2016-2022 model year Tacoma vehicles.
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 2 | 15% |
| 2025 | 2 | 2% |
| 2024 | 5 | 3% |
| 2023 | 1 | 2% |
| 2022 | 6 | 10% |
| 2021 | 9 | 11% |
| 2020 | 23 | 26% |
| 2019 | 75 | 34% |
| 2018 | 66 | 32% |
| 2017 | 25 | 10% |
| 2016 | 14 | 4% |
| 2015 | 5 | 5% |
| 2014 | 4 | 4% |
| 2013 | 6 | 5% |
| 2012 | 53 | 18% |
| 2011 | 3 | 2% |
| 2010 | 7 | 2% |
| 2009 | 6 | 1% |
| 2008 | 14 | 3% |
| 2007 | 13 | 2% |
| 2006 | 16 | 2% |
| 2005 | 11 | 2% |
| 2004 | 24 | 6% |
| 2003 | 22 | 6% |
| 2002 | 6 | 2% |
| 2001 | 7 | 2% |
| 1999 | 2 | 1% |
| 1998 | 3 | 1% |
| 1997 | 1 | 1% |
| 1996 | 5 | 2% |
| 1995 | 3 | 2% |
Other parts of the 2016 Toyota Tacoma
136 complaintsOther or unknown
50 complaintsEngine
47 complaintsElectrical system
37 complaintsSeats
22 complaintsBody and structure
22 complaintsBrakes
19 complaintsExterior lighting
17 complaintsSuspension
14 complaintsVehicle speed control
10 complaintsVisibility (wipers, defrost, mirrors)
10 complaintsAir bags
5 complaints
← All problems reported for the 2016 Toyota Tacoma
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology