2003 Ford Expedition Fuel system Problems

“The truck would just turn off while driving at 55 or 60 miles an hour , no steeringwas on highway ,no brakes put in neural to get to side of road with cars all around me .this has happened 3 times, then it would not start at all when fulled up with gas, had to be towed, then when I was down to 1/4 tank ,would not turn over, had gas in it too, but would not start, had to be towed in shop now again 3rd time ,had problems with the door agar going off had senor replaced still comes up”

“The engine stops running without warning. I was driving on the freeway at 70+ in heavy traffic. All of a sudden the engine shuts down. I put the vehicle in neutral and engaged the flashers. I tried to restart the vehicle while maneuvering to the side of the road avoiding multiple close calls. Once stopped, I put the vehicle in park and tried to restart. After a couple of minutes the car restarted. I took the vehicle to the autozone to see if there were any fault codes. One code indicated the fuel pump was an issue. …”

“The car was running well and suddenly it die. No lights in dash board, no shakes, no any previous sign of trouble. Simply it die. I pumped the accelerator pedal and the car continue running. Next time, few days after the incident, the car does the same. This time do not continue running when I pump gas. I have to put in neutral and start it again. It start at once. Could be more than two weeks without signal of problem and then, it happen again. Some other time, it happen 4 or 5 times in a half hour trip.”

“While driving down the freeway I put my foot on the gas and did not get any response. In a few seconds I pushed on the gas again and nothing. I started to pull over and pushed on the gas again and the car had power. The same thing happened 25 minutes later getting back onto the freeway. Next incident was starting from a stop light the car just died. No warning. Engine light, battery light and service now lights come on. Again I pulled over put the car in park and it started back up. We had the coils and plugs changed. …”

“Why is there no warning light,or signal of any kind when the PCM fails? Our PCM failed, which caused our catalytic converters, 02 sensors, & fuel pump to fail. Our ignition coils had to be replaced. Would have been nice if a warning light came on the dash. This has caused our Expedition engine to randomly shut off while driving countless times! I have miraculously been able to maneuver my Expedition to the side of the freeway &have it towed eight times without killing myself, my family or any one else! …”