2015 Ford Fusion Fuel system Problems
- Complaints
- 67about this part
- Share
- 7%of 997 total for the year
- Median mileage
- 63,892miles
- Trend
- FallingComplaints filed in the last 3 full calendar years are at least 25% lower than in the 3 years before.
NHTSA recorded 67 complaints about the fuel system of the 2015 Ford Fusion, 7% of the 997 complaints for this model year. Where a mileage was given, the median is 63,892 miles.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Takata recall I currently own a 2015 Ford Fusion se 2.0l turbo as the mileage has increased I have become aware of a problem with the purge vale, as I have having troubling starting my car after I put gas in it along with stalling. After some research I came upon articles of complaints about the same model car with the same purge valve problem. I believe this is a defect in the car that has dangerous safety hazards”
NHTSA complaint #11161865, filed 2018-12, 60,000 miles“The rpms rev and shifting hesitates. Was at a stop light, went to drive off from light and it stalled in intersection as it was stuck in gear and finally went into gear. It slow, hard shifts at usual times. The stalling happens out of the blue. I do not go far because I don't want to have an accident from it stalling in gear! I've put so much money on tranny work, this is ridiculous to not have a safe vehicle and have to worry about being stranded.”
NHTSA complaint #11374587, filed 2020-11, 123,018 miles“Engine unexpectedly shuts off while driving. While driving at low speed in parking lot I went over a bump and then the engine shut off. Odometer is at approximately 44000. This occurred once before several months ago under the same conditions but I was not sure what to make of it.”
NHTSA complaint #11098394, filed 2018-05, 44,000 miles“My engine light came on. So I went to 2 different companies and they told me that there was a misfire in cylinder 2. I replaced the coils and plugs. The engine light came on again so I took it to Ford. There they told me coolant was getting into my cylinders. They told me that it would cost $6,731 to fix a problem that multiple people with the same car and multiple different years are having. The car still moves but now it's overheating every 3 minutes.”
NHTSA complaint #11341229, filed 2020-07, 45 miles“The 2015 Fusion had a surge and the car jerked forward. My wife said that happened to her before. When it happened when I was in the car driving it we both looked at each other. This happened to us with the 2010 rav4 and the 2009 sienne that crashed into a tree. Please check this car for a computer problem.”
NHTSA complaint #10926644, filed 2016-11, 23,500 milesRelated service bulletins
- 11024707Oct 16, 2025The affected vehicles have an emissions control system that may not control tailpipe emissions effectively over time.
- 10169940Dec 11, 2019Some 2013-2015 Fusion/MKZ/Escape/MKC with a 1.6L GTDI, 1.5L GTDI, or 2.0L GTDI may exhibit a lack of power, loss of power, or stall when placed in gear with DTCs P00C6, P0087…
- 10205010Mar 17, 20162.0L Ecoboost - Fuel odor
- 10075275Mar 17, 20162.0L ECOBOOST - FUEL ODOR ISSUE Some 2013-2016 Escape, 2015-2016 MKC vehicles built on or before 12/15/2015, 2013-2016 Fusion, MKZ, 2013-2015 Explorer, 2013-2014 Focus ST and…
- 10204987Feb 5, 201649 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
- 10204986Feb 5, 201649 CFR Part 579.5 Monthly Communications - January 2016
- 10057598Nov 24, 2014Ford: some ford fusion 2014-2015 vehicles may experience an hard start, long crank, or an run-through condition if equipped with an 1.5l gtdi engine.
- 10056776Aug 1, 2014Ford/lincoln: diagnostic trouble code (dtc) p025a (fuel pump module a control circuit/open) has concern of crank no start or stall due to unpowered fuel pump control module in…
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2020 | 13 | 7% |
| 2019 | 17 | 5% |
| 2018 | 30 | 7% |
| 2017 | 37 | 3% |
| 2016 | 92 | 6% |
| 2015 | 67 | 7% |
| 2014 | 82 | 6% |
| 2013 | 141 | 8% |
| 2012 | 65 | 3% |
| 2011 | 236 | 8% |
| 2010 | 705 | 14% |
| 2009 | 12 | 1% |
| 2008 | 11 | 1% |
| 2007 | 18 | 2% |
| 2006 | 15 | 2% |
Other parts of the 2015 Ford Fusion
272 complaintsSteering
163 complaintsTransmission and drivetrain
145 complaintsOther or unknown
126 complaintsBrakes
125 complaintsElectrical system
102 complaintsEngine cooling
52 complaintsAir bags
39 complaintsBody and structure
32 complaintsSeat belts
24 complaintsWheels
23 complaintsVisibility (wipers, defrost, mirrors)
18 complaints
← All problems reported for the 2015 Ford Fusion
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology