2024 GMC Sierra 2500 Fuel system Problems
- Complaints
- 9about this part
- Share
- 8%of 108 total for the year
- Median mileage
- 32,619miles
- Trend
- Too newThis model year is less than 4 years old, so a trend is not meaningful yet.
NHTSA recorded 9 complaints about the fuel system of the 2024 GMC Sierra 2500, 8% of the 108 complaints for this model year. Where a mileage was given, the median is 32,619 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Replaced the exhaust tail pipe tip past the DPF and warning light came on after miles of driving. Vehicle was locked up and only able to drive 55 Mph and there was a countdown to it dropping even lower. Dangerous to limit speed. This shouldn’t happen anyway with just changing out exhaust tailpipe. Very costly unnecessary repair”
NHTSA complaint #11649759, filed 2025-03“The contact owns a 2024 GMC Sierra 2500. The contact stated that after parking and turning off the vehicle, the vehicle failed to restart. No warning light was illuminated. The vehicle was towed to the dealer for diagnostic testing, but no diagnostic trouble codes were retrieved. The dealer replaced the fuel pump module. No further information was available. The manufacturer was made aware of the failure and advised the contact to file a vehicle safety complaint with the NHTSA Hotline. The failure mileage was approximately 11,000.”
NHTSA complaint #11662578, filed 2025-05, 11,000 miles“The contact owns 2024 GMC Sierra 2500. The contact stated that while driving 25 MPH and depressing the accelerator pedal, the vehicle decelerated and stopped independently. A dealer was contacted. The vehicle was taken to the dealer and was diagnosed with fuel pump driver control module failure. The contact was informed that the fuel pump driver control module needed to be replaced. The contact associated the failure with Technical Service Bulletin: 24-NA-139 (Fuel Pump Driver Control Module stalling or no-start conditions); however, the VIN was not included in the TSB. …”
NHTSA complaint #11766384, filed 2026-09, 54,238 miles“The vehicle experienced a loss of engine power accompanied by a check engine warning light and a “Reduced Acceleration”/reduced-power condition. The exact component causing the malfunction has not yet been determined. The vehicle and any affected components are available for inspection upon request. While driving the truck uphill toward our residence, the vehicle lost significant power and had difficulty maintaining acceleration. The truck stalled several times. …”
NHTSA complaint #11766690, filed 2026-09“The contact owns a 2024 GMC Sierra 2500. The contact stated that while driving at various speeds, the two outside cabs were smoking. There was smoke detected near the fuel tank. The contact stated that there was an abnormal odor of diesel and DEF detected. There were no warning lights illuminated. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. While driving, there was a lot of smoke detected from the vehicle. The vehicle was taken back to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. …”
NHTSA complaint #11611647, filed 2024-08, 100 milesRelated service bulletins
- 11025665Nov 24, 2025Emission Recall. General Motors has decided to conduct a Voluntary Emission Recall involving certain 2024 Model Year Chevrolet Silverado and GMC Sierra vehicles with a 6.6L…
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 1 | 7% |
| 2025 | 1 | 4% |
| 2024 | 9 | 8% |
| 2022 | 4 | 9% |
| 2021 | 2 | 4% |
| 2020 | 2 | 3% |
| 2019 | 6 | 19% |
| 2018 | 6 | 17% |
| 2017 | 3 | 8% |
| 2016 | 12 | 20% |
| 2015 | 12 | 13% |
| 2014 | 3 | 10% |
| 2013 | 9 | 20% |
| 2012 | 5 | 16% |
| 2011 | 3 | 5% |
| 2009 | 2 | 6% |
| 2008 | 4 | 6% |
| 2007 | 3 | 4% |
| 2006 | 2 | 3% |
| 2005 | 3 | 3% |
| 2004 | 8 | 6% |
| 2003 | 15 | 9% |
| 2002 | 12 | 9% |
| 2001 | 12 | 9% |
| 2000 | 2 | 4% |
| 1999 | 2 | 6% |
| 1998 | 2 | 13% |
| 1997 | 1 | 7% |
Other parts of the 2024 GMC Sierra 2500
33 complaintsTransmission and drivetrain
27 complaintsBrakes
16 complaintsOther or unknown
13 complaintsEngine
12 complaintsBody and structure
6 complaintsVehicle speed control
6 complaintsSteering
4 complaintsTires
4 complaintsExterior lighting
3 complaintsForward collision avoidance
3 complaintsLane departure
3 complaints
← All problems reported for the 2024 GMC Sierra 2500
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology