2025 Honda CR-V Body and structure Problems

“Right after purchase, the hood wobbled up and down at highway speeds. When passing a semi traveling the opposite direction at 60 mph on a two lane section of road, it jumped enough to make me wonder if the latch had come loose and the hood was going to open. I notified the dealer to have it looked at and it was discovered that welds holding the hood were broken. A new hood is being ordered and it is being replaced at no charge. I am reporting this issue in case this is not an isolated incident.”

“Subject: Safety Concern – Hood Instability on 2025 Honda CR-V Hybrid Dear NHTSA, I am writing to formally report a potential safety defect with my 2025 Honda CR-V Hybrid. The hood does not close securely and exhibits visible gaps, uneven alignment, and noticeable movement or rattling at highway speeds. This raises serious concerns about the structural integrity of the hood and the possibility of it disengaging while driving. I brought this issue to Lia Honda, where I was told the movement is “by design” and not a defect. …”

“From the day I drove my brand new 2025 Honda CR-V off the lot after purchasing it, in the driver's side rear view mirror, the mirror vibrates terribly as soon as you are going 35/45+mph. The faster the speed, the worse the vibration is. You can visible see the mirror glass shaking. It is very dangerous at all times to not be able to see with this side mirror. It is especially dangerous on the highways because it distorts the view so greatly and also makes me feel disoriented and dizzy when I try to use it to safely navigate the roads. …”

“The component due to an improperly produced steering gearbox worm wheel, the wheel can swell during use, reducing the grease film thickness between the worm wheel and worm gear in which this was recalled on Oct 3, 2024 but did not discovered it until Oct 13, 2024 in an incident caused by the recall. All of the sudden my steering wheel became hard to maneuver and when I had difficulty turning it, I had something from the issue, as a result the under cover of the car got damaged due this issue in which I didn’t find out when I tried to schedule a service appointment on the Honda website. …”

“The factory hood anti-flutter adhesive (NVH mastic) separating the inner hood support frame from the outer sheet metal skin has failed and unbonded. As a result, the outer hood skin flexes, vibrates, and flutters severely at highway speeds, creating a distraction and posing a potential risk of structural latch or hood fatigue failure over time.”