2007 Toyota Tundra Engine cooling Problems
- Complaints
- 31about this part
- Share
- 8%of 390 total for the year
- Median mileage
- 66,543miles
- Trend
- StableComplaints filed in the last 3 full calendar years are within 25% of the 3 years before.
NHTSA recorded 31 complaints about the engine cooling of the 2007 Toyota Tundra, 8% of the 390 complaints for this model year. Where a mileage was given, the median is 66,543 miles.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Failed inspection code p2440,2441 took to Toyota dealer checked p2240 .need to replace air pump,air switch valve bank and bank 2.cost $2700 . This is second time failed. Last year air pump failed. Toyota dealer estimated $4000 replace. I did buy air pump ang replace it ,cost me $ 1100. Mileage were 69329 and this time 101,450.”
NHTSA complaint #10394098, filed 2011-04, 101,300 miles“My wife came very close to getting into an accident while bringing the kids to school a few weeks ago. She was leaving a stop sign getting onto a very busy highway when our 2007 Toyota Tundra unexpectedly had drastically reduced power. After a trip to the dealership and some research I have found that the reduction in power was caused by a failure in the secondary air injection system. This system is part of the emissions system and is designed to increase efficiency during cold starts. …”
NHTSA complaint #10330863, filed 2010-05, 42,500 miles“2007 Toyota Tundra has air injection failure which puts the truck in limp mode or no power. I was entering the expressway and could not get my truck above 40 miles per hour. I was able to pull onto the shoulder to avoid a major crash. Toyota is aware of the problem but charges $4000 for the repair. My truck has been at the dealer for over 6 weeks. This is due to impart to a national recall. This seems in my opinion as a way for Toyota to profit from a faulty design and a potential life threatening condition.”
NHTSA complaint #10341282, filed 2010-07, 85,000 miles“I am the owner of a 2007 Toyota Tundra and while driving cross country with my wife and 2yr daughter the truck automatically went into limp mode while driving 65 MPH and stopped dead almost causing an accident.trouble codes were pulled and found to be air injection valves for emission control upon startup only .this was midway thru a 2300 mile trip.truck has 67000 miles on it and it out of warranty so cost to me is between 4000-5000 $.truck should not enter limp mode while driving as it is just a matter of time before an accident occurs.”
NHTSA complaint #10403949, filed 2011-06, 66,543 miles“Stuck gas pedal. The incident occurred over a year ago when I was driving on us101 highway near tillamook, oregon with two of my brothers, one on the front passenger seat, and one on the back. When I slightly press on the gas pedal, the truck took off with RPM at about 6000 and speed of about 70mph, and I could not stop the truck via pressing really hard on the brake. Finally, I was able to stop it by pushing the shift handle to neutral. I turned off the engine and checked the gas pedal to make sure nothing would get jammed, and I did not find anything. …”
NHTSA complaint #10316286, filed 2010-03, 18,500 milesRelated service bulletins
- 10253223Mar 4, 2024This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the…
- 10182949Apr 22, 2016On vehicles equipped with the SET accessory Split Rear Dual Exhaust system, the
- 10076047Apr 22, 2016Tundra Split Rear Dual Exhaust Revised Exhaust Hangers On vehicles equipped with the SET accessory Split Rear Dual Exhaust system, the exhaust pipe may become loose due to the…
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 1 | 1% |
| 2024 | 25 | 7% |
| 2023 | 48 | 12% |
| 2022 | 39 | 9% |
| 2014 | 1 | 1% |
| 2013 | 1 | 1% |
| 2012 | 3 | 2% |
| 2010 | 8 | 5% |
| 2009 | 1 | 3% |
| 2008 | 19 | 6% |
| 2007 | 31 | 8% |
| 2006 | 5 | 1% |
| 2005 | 15 | 4% |
| 2004 | 5 | 1% |
| 2003 | 8 | 2% |
| 2002 | 7 | 1% |
| 2001 | 12 | 3% |
| 2000 | 44 | 4% |
Other parts of the 2007 Toyota Tundra
73 complaintsVehicle speed control
65 complaintsBody and structure
61 complaintsSuspension
57 complaintsBrakes
32 complaintsFuel system
32 complaintsEngine
27 complaintsElectrical system
24 complaintsOther or unknown
23 complaintsTires
20 complaintsAir bags
14 complaintsEquipment
13 complaints
← All problems reported for the 2007 Toyota Tundra
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology