2024 Toyota Tacoma Suspension Problems

“While the vehicle was parked in my driveway, I noticed oil leaking on the ground and discovered that the rear shock absorber had suffered a catastrophic structural failure. The vehicle is a 2024 Toyota Tacoma TRD Off-Road covered under the manufacturer's original factory warranty. This specific vehicle configuration is included under active federal safety recall campaign 26TB14 / 26TA14 (NHTSA Campaign Number 26V514) for rear suspension failure. …”

“I was driving along and the top hat on my suspension blew out. Toyota used a cast aluminum top hat on the top of the coil over and the shock blew through the top of the top shock mount. They used a steel top hat on the 4Runner so I believe they know it is an issue but haven’t had enough issues with it yet to do a recall. I uploaded a picture of what my coil over looks like after it happened and what it is supposed to look like. Stock trd offroad suspension.”

“The rear leaf spring broke on my 2024 Toyota Tacoma at approximately 16,000 miles during normal highway driving. The vehicle drove without issue on the way to my destination. On the return trip, I noticed a creaking sound, loud clunks, particularly when going over bumps or turning, and also increased sway. Given how new the vehicle is, a catastrophic suspension failure was not something I anticipated. The failure was confirmed on February 12th by my authorized Toyota dealer, Toyota of Muskegon in Muskegon, MI as a manufacturer defect. …”

“Car drove fine day before incident, went to drive to water a neighbors plants and noticed a puddle of oil in my garage. Did the shock test by making the rear of the vehicle shake on each side. Rear drivers side shock failed as the vehicle kept bouncing and had no tension when pushing down. Seal between oil reservoir and shock blew and all oil had leaked out. Shock no longer functions, dealer is holding vehicle until a replacement arrives. Dealer confirmed the shocked failed and has ordered the part. It is on a national back order. …”

“The strut blew through the top hat on the drivers side strut assembly/strut mount driving on a state highway. This design has a cast aluminum top hat that bears the dynamic forces and shocks. It can, and in my case, did catastrophically fail. Had failure happened at higher speeds or under other circumstances it could impair controlability at speed. There are no warning lights or sensors available for this problem. Online owner's forums for the new 2024 model year of the Toyota Tacoma (so-called 4th generation) are starting to report this identical failure. …”