1999 Chevrolet Suburban Fuel system Problems
- Complaints
- 37about this part
- Share
- 6%of 634 total for the year
- Median mileage
- 85,000miles
- Trend
- FallingComplaints filed in the last 3 full calendar years are at least 25% lower than in the 3 years before.
NHTSA recorded 37 complaints about the fuel system of the 1999 Chevrolet Suburban, 6% of the 634 complaints for this model year. Where a mileage was given, the median is 85,000 miles. 1 of these say a crash was involved and 1 a fire, according to the filers.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Purchased vehicle used for family vehicle, after having it for six months and 4,000 miles the brake lines have failed. Rusted to the point of total replacement, as well as the fuel line being rusted so bad that the repair shop would not touch the brake lines without replacing fuel lines, we have six children that could have been injured or killed because of this... Please do something, it is expensive and dangerous. I see all other complaints have felt useless, why is this not being taken care of? How many people will have to go through this same problem? …”
NHTSA complaint #10544968, filed 2013-09, 117,000 miles“I stopped at a store, did some shopping, came back out and the truck would not start. I then called a tow truck and had it taken to a shop. The next morning I got a call from the shop that the truck started just fine. I had them run $280 worth of test to find nothing that stood out but was informed that it was probably the fuel pump. They changed the fuel filter and everything has worked since; until today. Now my truck will not start. …”
NHTSA complaint #10105885, filed 2005-01, 72,100 miles“It will not start!! I have to listen for the fuel pump to start circulating before I turn the ket on all the way. I have dropped the fuel tank, and replaced the fuel pump 5 times, the plug and wires on the fuel pump, the fuel relay, you name it I have fixed it at least twice. After a month or no longer than two, I'm fixing it again. This will be the 6th time unless I got some more helpful information. We have a new motor in it and new transmission too. It has 140,000 miles on it and I take very good care of it.”
NHTSA complaint #10186092, filed 2007-03, 130,000 miles“Vehicle is a 1999 Chevrolet Suburban k2500 with GM 6.5 liter turbo-diesel engine. The vehicle stalled in interstate traffic (I-270) multiple times on october 21, 2003. I called the dealer, and was informed that the likely cause was the electronic fuel injection pump, which GM has warranted for 10 years or 120,000 miles. The dealer thereafter replaced the injection pump under warranty. While I am pleased that the part was replaced at no cost to me, I believe that this represents an unacceptable defect. …”
NHTSA complaint #10047452, filed 2003-11, 73,000 miles“Check engine warning light would illuminate during normal vehicle operation and subsequent mechanical inspections could not detect the following impending problem. My family and I were returning from a weekend vacation in arizona on our way home. While driving through the middle of the desert just past the california/arizona state line I heard a loud pop and our vehicle lost power. We were towed back into needles, ca and it was determined that the fuel pump had failed. We were forced to stay the night in a local hotel as a new pump had to be installed in the gas tank. …”
NHTSA complaint #10163605, filed 2006-07, 85,614 milesRelated service bulletins
- 10208027Jan 14, 2022This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester…
- 10157018Sep 20, 2017This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester…
- 10114453Apr 7, 2015This Preliminary Information communication provides information to the technician about vehicles that may have a buzz noise at idle after fuel pressure regulator replacement…
- 10137901May 9, 2014This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.
Fuel system: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2024 | 2 | 4% |
| 2023 | 6 | 5% |
| 2022 | 13 | 10% |
| 2021 | 32 | 16% |
| 2020 | 3 | 7% |
| 2018 | 4 | 5% |
| 2017 | 6 | 4% |
| 2016 | 5 | 2% |
| 2015 | 27 | 6% |
| 2014 | 2 | 3% |
| 2013 | 5 | 4% |
| 2012 | 2 | 2% |
| 2011 | 6 | 4% |
| 2010 | 3 | 3% |
| 2009 | 6 | 6% |
| 2008 | 6 | 3% |
| 2007 | 11 | 4% |
| 2005 | 8 | 6% |
| 2004 | 14 | 7% |
| 2003 | 11 | 4% |
| 2002 | 27 | 9% |
| 2001 | 60 | 14% |
| 2000 | 40 | 14% |
| 1999 | 37 | 6% |
| 1998 | 11 | 5% |
| 1997 | 46 | 11% |
| 1996 | 23 | 6% |
| 1995 | 7 | 2% |
| 1994 | 15 | 2% |
| 1993 | 1 | 0% |
| 1991 | 1 | 2% |
| 1989 | 2 | 3% |
| 1988 | 3 | 10% |
| 1987 | 3 | 17% |
| 1986 | 1 | 14% |
Other parts of the 1999 Chevrolet Suburban
246 complaintsTires
92 complaintsElectrical system
58 complaintsSteering
52 complaintsTransmission and drivetrain
47 complaintsVisibility (wipers, defrost, mirrors)
44 complaintsEngine cooling
33 complaintsSuspension
33 complaintsLatches, locks and linkages
23 complaintsBody and structure
20 complaintsVehicle speed control
19 complaintsExterior lighting
15 complaints
← All problems reported for the 1999 Chevrolet Suburban
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Nov 1, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology