2004 Toyota Tundra Engine Problems
- Complaints
- 6about this part
- Share
- 1%of 466 total for the year
- Median mileage
- 106,758miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 6 complaints about the engine of the 2004 Toyota Tundra, 1% of the 466 complaints for this model year. Where a mileage was given, the median is 106,758 miles. 2 of these say a crash was involved, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Vehicle began to accelerate down a steep hill and no matter what I tried to do to stop the vehicle nothing happened. It just kept accelerating. Lost control of vehicle, and was unable to negotiate the right hand turn. Vehicle slammed into a dirt embankment, then rolled over and reversed it's position. Consequently, I was trapped in a running vehicle with gasoline leaking and unable to shut off the engine. Had to wait 30n minutes for ems/fire rescue to arrive. Extrication took another 25-30 minutes. Transported to trauma center, york, pa.”
NHTSA complaint #11387346, filed 2021-01, 142,000 miles“The 2004 and earlier Toyota Tundra has had major corrosion issues and frame recalls. My Tundra was just inspected by the local Toyota dealer and major corrosion was noted on the vehicle frame. Toyota applied a fiberglass based rustproofing to the frame. However, they would not acknowledge any other corrosion or rot on the vehicle. My vehicles motor mounts are so corroded that I am afraid that the engine will fall out of the vehicle. Also, the mounts that hold the radiator are so corroded they are almost gone. …”
NHTSA complaint #10546877, filed 2013-10, 84,000 miles“Catalytic converter failed at 55,023 miles and was replaced under warranty. The same catalytic converter failed again at 110,000 miles and when I went to a dealer was told that it wasn't under warranty and that I would have to pay $1200.00 for the part alone and labor would be extra. I also told the dealer that the high rear brake light housing was melting from the heat of the lights. They did nothing. The frame is rusting badly and is becoming a safety hazard. I called Toyota customer service and they said there was no recall for any of these items and there was nothing they could do. …”
NHTSA complaint #10487693, filed 2012-12, 55,023 miles“Tl-the contact owns a 2004 Toyota Tundra. The contact stated that while driving at approximately 10 MPH, the vehicle stalled without warning and the front passenger's side tire dislodged from the vehicle. The vehicle was unable to restart. The vehicle was towed to an independent mechanic where the upper ball joint, the lower ball joint, the control arm, the ABS speed sensor, and rt front brake line leading system needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA campaign numbers: 07v013000 (suspension) and 05v225000 (suspension). …”
NHTSA complaint #10670669, filed 2015-01, 123,360 milesRelated service bulletins
- 10164330Jul 1, 2019TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections…
- 10149217Sep 14, 2016TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are…
- 10134223Sep 15, 2015TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.
- 10096556Sep 15, 2015Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
- 10132529Aug 24, 2015TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been…
- 10134128Jan 15, 2015TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix…
- 10096036Jan 15, 2015"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. Flash calibration updates for specific vehicle models/ecus are released as field-fix…
- 10132812May 1, 2014Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft Position Sensor Circuit) and/or P0340 (Camshaft Position Sensor Circuit) due to…
Engine: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 8 | 22% |
| 2025 | 47 | 33% |
| 2024 | 153 | 44% |
| 2023 | 168 | 41% |
| 2022 | 165 | 38% |
| 2021 | 1 | 4% |
| 2020 | 6 | 13% |
| 2019 | 2 | 3% |
| 2018 | 12 | 12% |
| 2017 | 5 | 6% |
| 2016 | 6 | 5% |
| 2015 | 3 | 6% |
| 2014 | 7 | 8% |
| 2013 | 23 | 27% |
| 2012 | 57 | 37% |
| 2011 | 35 | 26% |
| 2010 | 10 | 6% |
| 2009 | 5 | 13% |
| 2008 | 36 | 11% |
| 2007 | 27 | 7% |
| 2006 | 18 | 3% |
| 2005 | 10 | 3% |
| 2004 | 6 | 1% |
| 2003 | 4 | 1% |
| 2002 | 4 | 1% |
| 2000 | 8 | 1% |
Other parts of the 2004 Toyota Tundra
200 complaintsSuspension
152 complaintsAir bags
50 complaintsOther or unknown
49 complaintsTransmission and drivetrain
46 complaintsBrakes
36 complaintsSteering
26 complaintsElectrical system
13 complaintsVehicle speed control
11 complaintsTires
9 complaintsFuel system
8 complaintsVisibility (wipers, defrost, mirrors)
8 complaints
← All problems reported for the 2004 Toyota Tundra
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology