2002 Chevrolet Silverado 2500 Transmission and drivetrain Problems
- Complaints
- 12about this part
- Share
- 3%of 351 total for the year
- Median mileage
- 92,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 12 complaints about the transmission and drivetrain of the 2002 Chevrolet Silverado 2500, 3% of the 351 complaints for this model year. Where a mileage was given, the median is 92,000 miles. 1 of these say a crash was involved, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“2002 Chevrolet suburban 2500. In parking lot, pressed brake and truck lurched forward causing damage to my suburban and another car resulting in an insurande surdharge for accident over $2500. Dealer, mirak Chevrolet of arlington ma could not find defect. Upon braking today,I felt a surge forward but no accident this time. Please advise of any past recalls or similar incidents.”
NHTSA complaint #10314122, filed 2010-02, 64,000 miles“Internal components wear a small hole in the rear of the case housing allowing the fluid to leak out without you knowing it. Once the fluid is gone the gears grind down to the point where the transmission locks up and you skid to a stop. I've been told this is still an on going problem all the way up to the 2010 model year.”
NHTSA complaint #10429357, filed 2011-10, 114,000 miles“There is a defect in the transfer case that results in a clip breaking loose and rubbing a hole in the rear housing, allowing the lubricant to leak out, which can cause the transfer case to fail and possibly locking up the wheels in an unexpected manner, causing a crash.”
NHTSA complaint #10411233, filed 2011-07, 150,000 miles“The holding clip for the oil pump inside of transfer case broke which allowed the oil pump to shake inside of case and consequently rubbed a hole thru t case which effectively emptied all the lubricating oil from t case ruining most of the parts inside.”
NHTSA complaint #10458260, filed 2012-05, 121,000 miles“Vehicle clunks when shifting between gears and will jump between gears. Will not shift into overdrive until 65mph or a distance of approximately 12 miles. Loss of reverse. Has been to dealer under warranty twice at mileage of 25,000 miles.”
NHTSA complaint #10073183, filed 2004-05, 22,198 milesRelated service bulletins
- 11006421Jul 24, 2024GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or…
- 10249579Jan 12, 2024This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10242843Sep 1, 2023The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the…
- 10220319Sep 1, 2022This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the…
- 10145478Sep 12, 2018This Preliminary Information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or…
Transmission and drivetrain: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2026 | 2 | 15% |
| 2025 | 10 | 32% |
| 2024 | 36 | 25% |
| 2023 | 17 | 36% |
| 2022 | 19 | 20% |
| 2021 | 30 | 34% |
| 2020 | 33 | 30% |
| 2019 | 9 | 12% |
| 2018 | 6 | 11% |
| 2017 | 9 | 17% |
| 2016 | 18 | 15% |
| 2015 | 20 | 11% |
| 2014 | 5 | 13% |
| 2013 | 4 | 8% |
| 2012 | 5 | 9% |
| 2011 | 10 | 10% |
| 2010 | 2 | 10% |
| 2009 | 2 | 3% |
| 2008 | 14 | 7% |
| 2007 | 21 | 10% |
| 2006 | 32 | 18% |
| 2005 | 21 | 8% |
| 2004 | 15 | 4% |
| 2003 | 30 | 7% |
| 2002 | 12 | 3% |
| 2001 | 26 | 7% |
| 2000 | 7 | 5% |
| 1999 | 1 | 1% |
| 1998 | 3 | 4% |
| 1997 | 1 | 2% |
Other parts of the 2002 Chevrolet Silverado 2500
212 complaintsEngine cooling
43 complaintsFuel system
30 complaintsSteering
16 complaintsEngine
13 complaintsTires
12 complaintsElectrical system
10 complaintsBody and structure
10 complaintsVisibility (wipers, defrost, mirrors)
7 complaintsAir bags
5 complaintsSuspension
5 complaintsWheels
5 complaints
← All problems reported for the 2002 Chevrolet Silverado 2500
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology