2025 Ford F-150 Lane departure Problems

“On October 8, 2025, my wife and I purchased a 2025 Ford F-150 Lariat, 3.5L Full Hybrid, with Ford's BlueCruise hands-free driving feature. As first-time users, I reviewed the owner's manual and Ford’s videos to understand BlueCruise. After several uses, I noted unpredictable behavior and now report a serious safety issue warranting federal investigation. On October 15, 2025, while driving north on I-95 near Boston with BlueCruise engaged in hands-free mode on an approved route, I pressed the Memory 1 recall button to adjust my seat. …”

“On November 2nd, 2025 at approximately 6pm, in Houston, Texas, my 2025 Ford F‑150 with Ford BlueCruise engaged in Hands‑Free mode was traveling with traffic at about 70 mph on a major thoroughfare. Without driver input, the system rapidly reduced speed to about 50 mph after it appeared to misinterpret an unknown speed‑limit change. This sudden, uncommanded deceleration created a hazardous speed differential with surrounding traffic. I swiftly took over manual control to maintain traffic flow and prevent a potential rear‑end collision. …”

“The driver-side rear tail lamp on my 2025 Ford F-150 Lightning developed a crack and internal condensation/moisture without a known impact event. The condition was confirmed by a Ford dealer, which recommended replacement of the LH tail lamp assembly. Ford denied warranty coverage and classified the lamp as non-warrantable cracked housing / outside-force damage. My concern is that cracking and moisture intrusion in a rear lamp assembly may affect lamp integrity, visibility, and safe operation, especially if similar failures are occurring in other recent F-150 Lightning vehicles. …”

“Driver side rear tail light housing has a crack that has allowed moisture to enter the housing. Oct 2025 Took it to dealer to notify of the problem of water getting in the tail light housing once noticed around 500 miles on truck about a month after purchase. Told to make an appointment to get it submitted for warranty. I was able to dry out the tail light housing and epoxied the crack to prevent water from getting back in. When I finally had the time for an appointment with recall service I had the dealer submit the claim April 2026. Ford denied the claim on 5/11/2026 due to GSB26-7012. …”

“On October 13 at 9:23 PM in Seguin, TX, with Ford BlueCruise hands‑free engaged, the vehicle abruptly steered strong left and headed toward the left barrier. I immediately overrode the system and steered back to avoid a collision. No impact occurred. The maneuver was sudden and without adequate warning, presenting a serious crash risk.”