2015 Ford F-150 Suspension Problems
- Complaints
- 11about this part
- Share
- 1%of 1,746 total for the year
- Median mileage
- 33,985miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 11 complaints about the suspension of the 2015 Ford F-150, 1% of the 1,746 complaints for this model year. Where a mileage was given, the median is 33,985 miles. 1 of these say a crash was involved, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Truck rear end bounces and shifts violently going over bumps and on rough roads driving over 40 MPH. When driving over speed bumps the truck feels as though it has bottomed out or the rear shocks have fully compressed and giving no support. These symptoms happen daily and makes driving dangerous on rough roads.”
NHTSA complaint #10903431, filed 2016-09, 8,000 miles“Unknown my truck at 65 to 69 shakes crazy bad and everybody i talk to says theirs does as well and Walter's Ford in pikeville ky has no clue y it is doing it therefore they couldn't fix it and it it's dangerous to drive”
NHTSA complaint #11635784, filed 2025-01“The contact owns a 2015 Ford F-150. The contact stated that while an independent mechanic was performing an oil change on the vehicle, the contact was informed that there was a hole in the passenger's side subframe, at the cross member and transmission connecting point. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 39,970.”
NHTSA complaint #11585824, filed 2024-04, 39,970 miles“The contact owns a 2015 Ford F-150. The contact stated that while driving at an undisclosed speed, he heard an abnormal sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the rear driver’s and passenger’s side wheel bearings failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 70,000. …”
NHTSA complaint #11515528, filed 2023-04, 70,000 miles“The contact owns a 2015 Ford F-150. The contact stated while driving at various speeds, he heard abnormal clunking sounds coming from the front of the vehicle. The vehicle was taken to the dealer where it was diagnosed that the Integrated Wheel End (IWE) had failed and damaged the wheel hubs, rotors, and brake pads. The vehicle was repaired under an unknown Ford Technical Service Bulletin; however, the failure reoccurred at 51,000 miles. The vehicle was taken back to the dealer who provided the same diagnostic information. …”
NHTSA complaint #11480637, filed 2022-08, 28,000 milesRelated service bulletins
- 10109068Sep 19, 2016Some 2015-2016 F-150 vehicles may exhibit a vibration on acceleration or cruise that is originating from the driveshaft and/or rear axle. During preliminary inspection look for…
Suspension: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 1 | 1% |
| 2024 | 3 | 2% |
| 2023 | 8 | 2% |
| 2022 | 14 | 2% |
| 2021 | 13 | 1% |
| 2020 | 10 | 1% |
| 2019 | 11 | 1% |
| 2018 | 23 | 1% |
| 2017 | 12 | 1% |
| 2016 | 18 | 1% |
| 2015 | 11 | 1% |
| 2014 | 10 | 1% |
| 2013 | 20 | 1% |
| 2012 | 19 | 1% |
| 2011 | 14 | 1% |
| 2010 | 16 | 2% |
| 2009 | 4 | 1% |
| 2008 | 11 | 3% |
| 2007 | 16 | 3% |
| 2006 | 25 | 4% |
| 2005 | 49 | 4% |
| 2004 | 118 | 6% |
| 2003 | 14 | 3% |
| 2002 | 20 | 2% |
| 2001 | 35 | 3% |
| 2000 | 41 | 4% |
| 1999 | 43 | 4% |
| 1998 | 132 | 10% |
| 1997 | 204 | 7% |
| 1996 | 21 | 6% |
| 1995 | 44 | 7% |
| 1994 | 41 | 6% |
| 1993 | 25 | 4% |
| 1992 | 9 | 2% |
| 1991 | 4 | 1% |
| 1990 | 6 | 2% |
| 1989 | 5 | 2% |
| 1988 | 4 | 3% |
| 1986 | 1 | 2% |
| 1985 | 3 | 11% |
Other parts of the 2015 Ford F-150
434 complaintsBrakes
317 complaintsEngine
266 complaintsOther or unknown
208 complaintsElectrical system
176 complaintsBody and structure
148 complaintsVehicle speed control
146 complaintsVisibility (wipers, defrost, mirrors)
97 complaintsSteering
84 complaintsFuel system
81 complaintsSeats
44 complaintsWheels
40 complaints
← All problems reported for the 2015 Ford F-150
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology